FORM NO. 3315-843 WHEEL HORSE® LAWN TRACTOR rl1( WITH 32" AND 38" MOWERS [\ Y A 508 SET-UP 5O0R 118 INSTRUCTIONS MODEL NO, 71203 — & U LOOSE PARTS Note: Use the chart below to verify all parts have been shipped. DESCRIPTION QTY. USE Fran Wheel 2 Flat Washer 2 Hub Cap 2 install front wheels. Cotter Pin 2 Steering Wheel 1 Foll Pin 1 Install steering wheel. Seat 1 Knob 1 install the seat. Flat Washer 1 Key 1 Use in ignition switch. Operator's Manual 1 Read manual before operating tractor.
SST-Up Instructions INSTALL FRONT WHEELS Note: If wheels are already installed, refer to Check Tire Pressure (below). 1. Install wheel onto axle with valve stem out. 2. Slide the flat washer onto the axle. Insert cotter pin through the axle and bend the ends of the pin apart (Fig. 1). Figure 1 2. Softer pin 1, Fiat washer 3. Hubcap 3. Push the hub cap (Fig. 1) onto the end of the axle. 4. Repeat steps 1-3 on opposite side. 5. Grease the wheel bearings. CHECK TIRE PRESSURE Check front and rear tire pressure.
Set-Up instructions POTENTIAL HAZARD * Battery electrolyte contains sulfuric acid which is a deadly poison and it causes severe burns, WHAT CAN HAPPEN * 1f you carelessly drink electrolyte you could die or if it gets onto your skin you will be burned. HOW TO AVOID THE HAZARD * Do not drink electrolyte and avoid contact with skin, eyes or clothing, Wear safety glasses to shield your eyes and rubber gloves to protect your hands.
Set-Up Instructions 3. Leave the filler caps off and connects 3 to 4 amp battery charger to the battery posts (Fig. 5). Charge the battery at a rate of 4 amperes or less for 4 hours (12 violist. Figure 5 3. Charger red wire 4. Charger black wire 1. Positive post 2. Negative post Lt POTENTIAL HAZARD + Charging battery produces gasses, WHAT CAN HAPPEN | * Battery gasses can explode, | HOW TO AVOID THE HAZARD | Keep cigarettes, sparks and flames away from hatter. 4.