User manual

ManualsBrandsTower pro ManualsHobbyTowerPro 70cc 4-stroke TP

TORQPRO TP-70

70cc four stroke engine single:best for 50-60cc aero and scale

Lightweight, high-powered, long life, great sound

Specifications Accessories

Displacement 70cc Iridium Spark Plug

Bore 50mm Ignition module

Stroke 36mm Exhaust pipe

RPM 1300~6800RPM Standoff

Weight 2040g (engine)

105g (ignition)

Fuel Mix gas1/40

Fully synthetic two stroke oil

Prop 23*12 . 24*8. 24*10 .

The specifications are subject to alteration for improvement without notice

Summary of content (8 pages)

PAGE 1
TORQPRO TP-70 70cc four stroke engine single:best for 50-60cc aero and scale Lightweight, high-powered, long life, great sound Specifications Displacement Bore Stroke RPM Weight Accessories 70cc Iridium Spark Plug 50mm Ignition module 36mm Exhaust pipe 1300~6800RPM Standoff 2040g (engine) 105g (ignition) Fuel Mix gas1/40 Fully synthetic two stroke oil Prop 23*12 . 24*8. 24*10 .
PAGE 2
Safety instruction READ THIS! WARNING! This engine is not toy. If misused or the safety precautions and instructions are not observed, may cause severe harm to you. Torqpro is not responsible for any loss, injury or damage resulting from the miss-use of its products. You alone are responsible for the safety operation of your engine. This engine can stop at any time, for a variety of reasons. Do not fly your plane in such a way that may cause damage if the motor stops running.
PAGE 3
PAGE 4
NO. Code No. Description 1 Rocker Cover 2 Cylinder Head 3 Head Gasket(1pcs.
PAGE 5
6 Cylinder 7 Cylinder Gasket 8 Crankcase 9 Piston Pin Retainer(2pcs./1pair) 10 Piston Pin 11 Needle bearing Washer 12 Needle bearing 13 prop washer 14 prop shaft 15 prop driver 16 Rotation Sensor 17 Crankshaft Ball Bearing(Front) 18 Woodruff Key 19 bearing spacer 20 Crankshaft Ball Bearing(milddle) 21 Valve Spring Retainer(2pcs.) 22 Split Cotter(4pcs./2pair) 23 Valve Spring (2pcs.) 24 valve(2pcs.
PAGE 6
Fuel Must need to use high octane gasoline, alcohol based glow fuel cannot be used in TP70 engine. TP70 engine use 40:1 ratio mix gas fuel , must use fully synthetic two stroke oil .Follow the oil manufacturer's recommendations concerning the mixture ratio of gasoline and oil . A 400cc tank will provide 10-15minutes normal flight, use a tank designed for gasoline. Prop Make sure that the propeller is well balanced.
PAGE 7
When starting the engine for the first time ,set both the high speed needle 1.75turn open, the slow speed needle 1.5turn open .with this position both high and slow speed mixtures will be rich.if the settings are upset,come back to this setting and adjust them according to procedure in the needle setting section. Installation Use a strong enough material for the mounting face of the model ,such as birch ply firewall of more than 8mm thick. Make sure the mounting face of the model is flat.
PAGE 8
TP70 WARRANTY         Your TP70 engine and ignition system covered with a 30h run times warranty by Torqpro, starting from the date of purchase. This warranty covers defects in workmanship and materials only. Do not disassemble the engine or ignition system. Improper disassembly or assembly of the motor ignition system will void the warranty on the item. Any modifications to the engine, or the ignition system, other than those authorized by Torqpro , will void this warranty.