FOREWORD This wiring diagram manual has been prepared to provide information on the electrical system of the 2005 CAMRY. Applicable models: MCV30, 31 Series ACV30 Series For service specifications and repair procedures of the above models other than those listed in this manual, refer to the following manuals; Manual Name 2005 CAMRY Repair Manual 2005 TOYOTA New Car Features Pub. No. RM1121U NCF275U All information in this manual is based on the latest product information at the time of publication.
005 CAMRY ELECTRICAL WIRING DIAGRAM Section Code Page INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . A . . . . 2 HOW TO USE THIS MANUAL . . . . . . . . . . . . . . B . . . . 3 TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . C . . . . 12 ABBREVIATIONS . . . . . . . . . . . . . . . . . . . . . . . . . D . . . . 17 GLOSSARY OF TERMS AND SYMBOLS . . . . E . . . . 18 RELAY LOCATIONS . . . . . . . . . . . . . . . . . . . . . . . F . . . . 20 ELECTRICAL WIRING ROUTING . .
A INTRODUCTION This manual consists of the following 13 sections: No. Section Description INDEX Index of the contents of this manual. INTRODUCTION Brief explanation of each section. B HOW TO USE THIS MANUAL Instructions on how to use this manual. C TROUBLE– SHOOTING Describes the basic inspection procedures for electrical circuits. D ABBREVIATIONS Defines the abbreviations used in this manual. E GLOSSARY OF TERMS AND SYMBOLS Defines the symbols and functions of major parts.
HOW TO USE THIS MANUAL B This manual provides information on the electrical circuits installed on vehicles by dividing them into a circuit for each system. The actual wiring of each system circuit is shown from the point where the power source is received from the battery as far as each ground point. (All circuit diagrams are shown with the switches in the OFF position.
B HOW TO USE THIS MANUAL ∗ The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION. [A] Stop Light From Power Source System (See Page 66) 15A STOP 7.
B [A] : System Title [H] : Indicates the wiring color. Wire colors are indicated by an alphabetical code. [B] : Indicates a Relay Block. No shading is used and only the Relay Block No. is shown to distinguish it from the J/B Example: Indicates Relay Block No.1 B = Black W = White BR = Brown L = Blue V SB = Sky Blue = Violet R = Red G = Green LG = Light Green [C] : ( ) is used to indicate different wiring and connector, etc. when the vehicle model, engine type, or specification is different.
B HOW TO USE THIS MANUAL [N] System Outline Current is applied at all times through the STOP fuse to TERMINAL 2 of the stop light SW. When the ignition SW is turned on, current flows from the GAUGE fuse to TERMINAL 8 of the light failure sensor, and also flows through the rear lights warning light to TERMINAL 4 of the light failure sensor.
B [N] : Explains the system outline. [O] : Indicates values or explains the function for reference during troubleshooting. [P] : Indicates the reference page showing the position on the vehicle of the parts in the system circuit. Example : Part ”L4” (Light Failure Sensor) is on page 36 of the manual. ∗ The letter in the code is from the first letter of the part, and the number indicates its order in parts starting with that letter.
B HOW TO USE THIS MANUAL The ground points circuit diagram shows the connections from all major parts to the respective ground points. When troubleshooting a faulty ground point, checking the system circuits which use a common ground may help you identify the problem ground quickly. The relationship between ground points ( EA , IB and IC shown below) can also be checked this way. I GROUND POINT W–B FAN MAIN Relay 5 A/C Relay No.2 5 A/C Relay No.
B The ”Current Flow Chart” section, describes which parts each power source (fuses, fusible links, and circuit breakers) transmits current to. In the Power Source circuit diagram, the conditions when battery power is supplied to each system are explained. Since all System Circuit diagrams start from the power source, the power source system must be fully understood.
B HOW TO USE THIS MANUAL K CONNECTOR LIST I14 I15 Dark Gray Gray 1 1 2 [A] I16 J1 J2 Black 2 A A 1 2 A A A A B B D D A A B CC CD D A 6 7 8 [B] J3 J4 K1 K2 L1 1 2 1 2 Dark Gray A A A A A A A A A B B DD A A B CC CDD L2 L3 L4 M1 M2 1 2 3 4 5 6 7 8 9 101112 1 2 3 45 6 78 M3 1 2 1 1 2 3 4 2 M4 [D] N1 Gray 1 2 3 [C] Black Gray 1 1 1 7 5 6 2 3 4 8 9 10 N2 O1 O2 Gray Black Dark Gray 1 2 1 1 [A] : Indicates connector to be connected to a part.
B L PART NUMBER OF CONNECTORS Code Part Name Part Number Code D4 Part Name Diode (Courtesy) Part Number A1 A/C Ambient Temp. Sensor 90980–11070 A2 A/C Condenser Fan Motor 90980–11237 D5 Diode (Interior Light) 90980–10962 A3 A/C Condenser Fan Relay 90980–10940 D6 Diode (Moon Roof) 90980–11608 90980–10848 A4 A/C Condenser Fan Resistor 90980–10928 D7 Door Lock Control Relay A5 A/C Magnetic Clutch 90980–11271 D8 Door Lock Control SW LH A6 A/T Oil Temp.
C TROUBLESHOOTING To Ignition SW IG Terminal Fuse [A] SW 1 Voltmeter [B] VOLTAGE CHECK (a) Establish conditions in which voltage is present at the check point. Example: [A] – Ignition SW on [B] – Ignition SW and SW 1 on [C] – Ignition SW, SW 1 and Relay on (SW 2 off) (b) Using a voltmeter, connect the negative lead to a good ground point or negative battery terminal, and the positive lead to the connector or component terminal. This check can be done with a test light instead of a voltmeter.
C To Ignition SW IG Terminal Test Light Fuse Case Short [A] SW 1 Short [B] Disconnect Disconnect Light (a) Remove the blown fuse and disconnect all loads of the fuse. (b) Connect a test light in place of the fuse. (c) Establish conditions in which the test light comes on. Example: [A] – Ignition SW on [B] – Ignition SW and SW 1 on [C] – Ignition SW, SW 1 and Relay on (Connect the Relay) and SW 2 off (or Disconnect SW 2) (d) Disconnect and reconnect the connectors while watching the test light.
C TROUBLESHOOTING HOW TO REPLACE TERMINAL (with terminal retainer or secondary locking device) Reference: 1. PREPARE THE SPECIAL TOOL 10 3 1 HINT : To remove the terminal from the connector, please construct and use the special tool or like object shown on the left. 2. DISCONNECT CONNECTOR 1 Example: (Case 1) 0.2 (mm) Up Tool 3. DISENGAGE THE SECONDARY LOCKING DEVICE OR TERMINAL RETAINER.
C Tool Tab Tab Example: (Case 1) [B] Terminal Retainer Tool [Male] Access Hole ( Mark) Tool For Waterproof Type Connector HINT : Terminal retainer color is different according to connector body. Example: Terminal Retainer Black or White Black or White Gray or White : Connector Body : Gray : Dark Gray : Black [Female] ”Case 1” Type where terminal retainer is pulled up to the temporary lock position (Pull Type).
C TROUBLESHOOTING Push the terminal retainer down to the temporary lock position. Retainer at Full Lock Position Retainer at Temporary Lock Position [Male] [Female] (c) Release the locking lug from terminal and pull the terminal out from rear. Locking Lug Tool 4. INSTALL TERMINAL TO CONNECTOR (a) Insert the terminal. HINT: 1. Make sure the terminal is positioned correctly. 2. Insert the terminal until the locking lug locks firmly. 3.
ABBREVIATIONS D ABBREVIATIONS The following abbreviations are used in this manual.
E GLOSSARY OF TERMS AND SYMBOLS GROUND The point at which wiring attaches to the Body, thereby providing a return path for an electrical circuit; without a ground, current cannot flow. BATTERY Stores chemical energy and converts it into electrical energy. Provides DC current for the auto’s various electrical circuits. CAPACITOR (Condenser) A small holding unit for temporary storage of electrical voltage. CIGARETTE LIGHTER An electric resistance heating element.
E RELAY Basically, an electrically operated 1. NORMALLY switch which may be normally CLOSED closed (1) or open (2). Current flow through a small coil creates a magnetic field which either opens or closes an attached switch. SPEAKER An electromechanical device which creates sound waves from current flow. 2. NORMALLY OPEN SWITCH, MANUAL 1. NORMALLY OPEN RELAY, DOUBLE THROW A relay which passes current through one set of contacts or the other.
F RELAY LOCATIONS [Engine Compartment] [Body] 20 2005 CAMRY (EWD586U)
F [Instrument Panel] [Seat] 21 2005 CAMRY (EWD586U)
F RELAY LOCATIONS 1 : Engine Room R/B Engine Compartment Left (See Page 20) 22 2005 CAMRY (EWD586U)
F 2 : ABS R/B Radiator Side Support LH (See Page 20) 23 2005 CAMRY (EWD586U)
F RELAY LOCATIONS : Engine Room J/B Engine Compartment Left (See Page 20) 24 2005 CAMRY (EWD586U)
F 25 2005 CAMRY (EWD586U)
F RELAY LOCATIONS [Engine Room J/B Inner Circuit] 26 2005 CAMRY (EWD586U)
Memo 27 2005 CAMRY (EWD586U)
F RELAY LOCATIONS : Driver Side J/B Lower Finish Panel (See Page 21) 28 2005 CAMRY (EWD586U)
F 29 2005 CAMRY (EWD586U)
F RELAY LOCATIONS [Driver Side J/B Inner Circuit] 30 2005 CAMRY (EWD586U)
F 31 2005 CAMRY (EWD586U)
F RELAY LOCATIONS [Driver Side J/B Inner Circuit] 32 2005 CAMRY (EWD586U)
F 33 2005 CAMRY (EWD586U)
F RELAY LOCATIONS : Passenger Side J/B Instrument Panel Brace RH (See Page 21) 34 2005 CAMRY (EWD586U)
Memo 35 2005 CAMRY (EWD586U)
G ELECTRICAL WIRING ROUTING Position of Parts in Engine Compartment [1MZ–FE, 3MZ–FE] A 1 A/C Ambient Temp.
G Position of Parts in Engine Compartment [1MZ–FE, 3MZ–FE] I 1 Ignition Coil and Igniter No.1 I 2 Ignition Coil and Igniter No.2 I 3 Ignition Coil and Igniter No.3 I 4 Ignition Coil and Igniter No.4 I 5 Ignition Coil and Igniter No.5 I 6 Ignition Coil and Igniter No.6 I 7 Injector No.1 I 8 Injector No.2 I 9 Injector No.3 I 10 Injector No.4 I 11 Injector No.5 I 12 Injector No.
G ELECTRICAL WIRING ROUTING Position of Parts in Engine Compartment [2AZ–FE] A 1 A/C Ambient Temp.
G Position of Parts in Engine Compartment [2AZ–FE] I 1 Ignition Coil and Igniter No.1 I 2 Ignition Coil and Igniter No.2 I 3 Ignition Coil and Igniter No.3 I 4 Ignition Coil and Igniter No.4 I 7 Injector No.1 I 8 Injector No.2 I 9 Injector No.3 I 10 Injector No.
G ELECTRICAL WIRING ROUTING Position of Parts in Instrument Panel A 13 A 14 A 15 A 16 A 18 A 19 A 20 A 21 A 22 A 23 A 24 A 27 A 28 A 34 A 35 A 36 A 37 A 38 A 39 A 40 A/C Control Assembly A/C Room Temp.
G Position of Parts in Instrument Panel G 3 Glove Box Light and SW H10 Heater Control SW H 11 Heater Control SW H13 Heated Oxygen Sensor (Bank 1 Sensor 3) I 13 Ignition Key Cylinder Light I 14 Ignition Key Cylinder Light Transponder Key Amplifier I 15 Ignition SW J 1 J 2 J 4 J 5 J 6 J 7 J 8 J 13 J 14 J 15 J 16 J 17 J 22 J 23 Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Con
G ELECTRICAL WIRING ROUTING Position of Parts in Body A 32 ABS Speed Sensor Rear LH A 33 ABS Speed Sensor Rear RH C13 C14 C15 C16 C17 D 4 D 5 D 6 D 7 D 8 D 9 D10 Choke Coil Curtain Shield Airbag Sensor LH Curtain Shield Airbag Sensor RH Curtain Shield Airbag Squib LH Curtain Shield Airbag Squib RH Diode Door Control Receiver Door Courtesy SW Front LH Door Courtesy SW Front RH Door Courtesy SW Rear LH Door Courtesy SW Rear RH Door Key Lock and Unlock SW Front LH Door Lock Motor Front LH Door Unlock Detect
G Position of Parts in Body L L L L 1 2 3 4 License Plate Light LH License Plate Light RH Luggage Compartment Door Key Unlock SW Luggage Compartment Door Opener Motor Luggage Compartment Light SW L 5 Luggage Compartment Light M 2 Mirror Heater LH Remote Control Mirror LH M 3 Mirror Heater RH Remote Control Mirror RH M 4 Moon Roof Control ECU and Motor R 6 R 7 R 8 R 9 R10 Rear Combination Light LH Rear Combination Light RH Rear Speaker LH Rear Speaker RH Remote Control Mirror SW S 15 Side Airbag Sensor
G ELECTRICAL WIRING ROUTING Position of Parts in Seat [w/ Power Seat] B 9 Buckle SW LH B 10 Buckle SW (Front Passenger’s Side) B 11 Buckle SW LH Seat Position Airbag Sensor J 18 J 19 J 20 J 21 Junction Connector Junction Connector Junction Connector Junction Connector O O O O O O Occupant Classification ECU Occupant Classification ECU Occupant Classification Sensor Front RH Occupant Classification Sensor Rear RH Occupant Classification Sensor Front LH Occupant Classification Sensor Rear LH 3 4 5 6 7 8
F Position of Parts in Seat [w/o Power Seat] B 9 Buckle SW LH B 10 Buckle SW (Front Passenger’s Side) B 11 Buckle SW LH Seat Position Airbag Sensor P 28 Power Seat Control SW (Driver’s Seat Lumbar Support Control) P 29 Power Seat Motor (Driver’s Seat Lumbar Support Control) J 20 Junction Connector J 21 Junction Connector S 18 Seat Heater RH S 19 Side Airbag Squib LH S 20 Side Airbag Squib RH O 9 O10 O11 O12 O13 O14 Occupant Classification ECU Occupant Classification ECU Occupant Classification Sensor
G ELECTRICAL WIRING ROUTING : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points [1MZ–FE, 3MZ–FE] : Location of Splice Points 46 2005 CAMRY (EWD586U)
G Connector Joining Wire Harness and Wire Harness EA1 1 2 3 4 EA2 Black 2 4 1 3 1 2 3 4 EB1 Gray 2 1 4 3 1 2 3 4 Dark Gray 2 1 4 3 EB2 Dark Gray Gray 1 2 3 4 Code EA1 EA2 EB1 EB2 2 1 4 3 Joining Wire Harness and Wire Harness (Connector Location) Engine Room Main Wire and Engine Room No No.
G ELECTRICAL WIRING ROUTING : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points [2AZ–FE] : Location of Splice Points 48 2005 CAMRY (EWD586U)
G Connector Joining Wire Harness and Wire Harness EA1 1 2 2 1 3 4 4 3 Code EA1 EA2 EA2 Black 1 2 3 4 Gray 2 1 4 3 Joining Wire Harness and Wire Harness (Connector Location) Engine Room Main Wire and Engine Room No No.
G ELECTRICAL WIRING ROUTING : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points 50 2005 CAMRY (EWD586U)
G Connector Joining Wire Harness and Wire Harness Code IA1 IB1 IB2 IC1 IC2 Joining Wire Harness and Wire Harness (Connector Location) Front Door LH Wire and Floor Wire (Left Kick Panel) Front Door LH Wire and Instrument Panel Wire (Left Kick Panel) Instrument Panel Wire and Floor Wire (Left Kick Panel) ID1 Engine Room Main Wire and Floor Wire (Left Side of Driver Side J/B) IE1 Instrument Panel Wire and Roof Wire (Inside of Front Left Pillar) IF1 IF2 IF3 IF4 Engine Room Main Wire and Instrument Panel
G ELECTRICAL WIRING ROUTING : Location of Connector Joining Wire Harness and Wire Harness : Location of Splice Points 52 2005 CAMRY (EWD586U)
G Connector Joining Wire Harness and Wire Harness Code Joining Wire Harness and Wire Harness (Connector Location) II1 II2 Instrument Panel Wire and Instrument Panel No.3 Wire (Behind ( the Glove Box)) II3 IJ1 Instrument Panel Wire and Instrument Panel Wire (Instrument Panel Reinforcement RH) IK1 Instrument Panel Wire and Cowl No.
G ELECTRICAL WIRING ROUTING : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points : Location of Splice Points 54 2005 CAMRY (EWD586U)
G Connector Joining Wire Harness and Wire Harness BA1 1 2 3 4 5 6 7 8 9 10 11 4 3 2 1 11 10 9 8 7 6 5 BB1 1 2 3 4 5 6 7 8 9 10 11 4 3 2 1 11 10 9 8 7 6 5 Code Joining Wire Harness and Wire Harness (Connector Location) BA1 Rear Door LH Wire and Floor Wire (Left Center Pillar) BB1 Rear Door RH Wire and Floor No.
G ELECTRICAL WIRING ROUTING : Location of Connector Joining Wire Harness and Wire Harness [w/ Power Seat] 56 2005 CAMRY (EWD586U)
G Connector Joining Wire Harness and Wire Harness BE1 1 2 3 4 5 6 Gray 3 2 1 6 5 4 Code Joining Wire Harness and Wire Harness (Connector Location) BE1 Floor No.
H SYSTEM CIRCUITS 2005 CAMRY ELECTRICAL WIRING DIAGRAM SYSTEM CIRCUITS ABS (TMC Made) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ABS (TMMK Made) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Audio System (Built–in Type Amplifier w/o Navigation System) . . . . . . . . . . Audio System (Separate Type Amplifier w/o Navigation System) . . . . . . . . . Audio System (w/ Navigation System) . . . . .
H Radiator Fan and Condenser Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Rear Window Defogger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Remote Control Mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Seat Belt Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Seat Heater . . . . . . . . . . . . . . . . . . . . . .
Power Source 5A ECU–ACC ACC Relay 5 3 1 2 10A RAD NO. 2 15A CIG 15A POWER POINT 5A AM1 7 2A 2 2A L–R W 10A ECU–IG 10A FAN RLY 10A GAUGE1 10A GAUGE2 10A HTR B–G 2 2E 5 3 1 2 B–Y 15A WASHER 20A SEAT HTR G1 Generator 25A WIPER IG1 Relay 8 2A 40A DEF B B–G 1 2E DEF Relay 2 1 3 1 5 2 10A MIR HTR L B–G B B–G 1 TAIL Relay 1 1 1 2 10A TAIL 5 3 10A PANEL 1 2 120A ALT 50A ABS NO. 1 2 1 7. 5A OBD B–G 15A FOG 1 15A STOP 30A PWR NO.
I15 Ignition SW L–R W W 2 AM1 ACC 3 L–R IG1 4 B–Y ST1 1 B–Y 10A IG2 W–R 3 IF6 W–R 7 AM2 IG2 6 B–R ST2 8 B–W 8 IF1 B–R 7 IF1 B–W 8 1C 15A IGN B–W B–Y 10A ECU–B 7 2F 30A AM2 30A D. C. C 1 1D 5A ALT–S 20A EFI 10A ETCS 25A A/F 20A RAD NO. 1 R 7.
Power Source ST Relay B–W B–W B–W 1 1 5 3 1 2 1 1 B–R 3 1C 5A ST W–B 10A HEAD RH UPR R R R–L R–L 10A HEAD LH UPR DRL NO.
Service Hints I15 Ignition SW 2–3 : Closed with the ignition SW at ACC or ON position 2–4 : Closed with the ignition SW at ON or ST position 2–1 : Closed with the ignition SW at ST position 7–6 : Closed with the ignition SW at ON or ST position 7–8 : Closed with the ignition SW at ST position TAIL Relay 5–3 : Closed with the light control SW at HEAD or TAIL position HEAD Relay 5–3 : Closed with the light control SW at HEAD position or dimmer SW at FLASH position Closed with the engine running and parking br
Starting and Ignition for 1MZ–FE and 3MZ–FE 8 IF1 ACC IG1 W–R 7 AM2 ST1 1 B–Y IG2 6 B–R ST2 8 B–W I15 Ignition SW IF6 7 IF1 5 IF1 W W–R B–Y 3 B–R B–Y 2 AM1 B–R 2 1A 2 1J B–Y 1 5 1 ST Relay 3 11 1K 4 2 A4 Park/Neutral Position SW 2 2E 1 7 1K 8 1K B–Y Combination Meter 30A AM2 B–W 5A AM1 B–W 2 1E B–W 2 2A 8 1H 1 W–B 1 2 1H 3 1C 1 1J N B–W IF1 B–R 1 2 B–W B–G B–G P 1 I8 B–W B–W 2 5 5A ST 120A ALT B–Y 1 B–W 1 W–B 4 1K B–R B–G 7 1L FL M
STA 16 NSW W–R B–Y 8 IGT1 1 +B 24 IGF GND 4 IGT 3 E9 9 IGT2 W–R IGT 3 LG–B 1 +B GND 4 E9 W–R 10 IGT3 IGT 3 L–Y 1 +B GND 4 E9 11 IGT4 E10 Engine Control Module 2005 CAMRY (EWD586U) I4 Ignition Coil and Igniter No. 4 IGF 2 W–R I3 Ignition Coil and Igniter No. 3 IGF 2 W–R I2 Ignition Coil and Igniter No. 2 IGF 2 P W–R 1 +B GND 4 IGF IGT 2 3 12 IGT5 1 +B GND 4 IGF IGT 2 3 I6 Ignition Coil and Igniter No. 6 W–B E6 B–R W–B I5 Ignition Coil and Igniter No.
Starting and Ignition for 1MZ–FE and 3MZ–FE Service Hints I15 Ignition SW 2–1 : Closed with the ignition SW at ST position 7–6 : Closed with the ignition SW at ON or ST position 7–8 : Closed with the ignition SW at ST position A4 Park/Neutral Position SW 4–5 : Closed with the A/T shift lever in P or N position S2 (A), S3 (B) Starter Point closed with the Park/Neutral position SW at P or N position and the ignition SW at ST position : Parts Location Code See Page Code See Page A4 36 (*1) I4 37 (*1) E
Memo 67 2005 CAMRY (EWD586U)
Starting and Ignition for 2AZ–FE 8 IF1 ACC B–R IG1 IG2 6 B–R ST2 8 B–W 7 IF1 I1 (M/T) 2 1E B–Y 2 2A C6 Clutch Start SW W–R 1 8 1H B–W B–W B–W 2 1A 5 1 4 ST Relay IF1 B–W B–G B–G 2 1J 2 1 B–Y 1 (A/T) B–W 1 2 2E 8 1K I1 B–W 30A AM2 (M/T) Combination Meter 5A AM1 B–W 2 3 A4 Park/Neutral Position SW W–R B–Y I15 Ignition SW IF6 W 3 IF1 B–Y 5 7 AM2 B–Y B–Y (A/T) ST1 1 (A/T) 2 AM1 B–R P N 2 5 11 1K 1 1 1 5A ST 120A ALT (A/T) B–W 1 1J (A/T)
B–R 8 1C 15A IGN B–R 8 1L B–R B–R E12 B–R E12 E12 B–R B–R E12 B–R B–R B–R B–R 1 1 1 1 R–W W–B W–R P W–B IGF IGT GND 2 3 4 IGF IGT GND 2 3 4 I4 Ignition Coil and Igniter No. 4 4 W–B 3 L–Y IGT GND 2 W–R IGF 4 I3 Ignition Coil and Igniter No. 3 GND W–B IGT 3 +B LG–B IGF 2 W–R +B W–R +B I1 Ignition Coil and Igniter No. 1 +B I2 Ignition Coil and Igniter No.
Starting and Ignition for 2AZ–FE Service Hints I15 Ignition SW 2–1 : Closed with the ignition SW at ST position 7–6 : Closed with the ignition SW at ON or ST position 7–8 : Closed with the ignition SW at ST position A4 Park/Neutral Position SW (A/T) 4–5 : Closed with the A/T shift lever in P or N position S2 (A), S3 (B) Starter Point closed with the Park/Neutral position SW at P or N position and the ignition SW at ST position (A/T) Point closed with the clutch start SW on and the ignition SW at ST position
Memo 71 2005 CAMRY (EWD586U)
Charging From Power Source System (See Page 60) ACC B–R AM1 IG1 ST1 7 AM2 IG2 6 8 IF1 10A GAUGE1 8 1C B–R 1 2M 10A IG2 W ST2 7 1C B–O W–R I15 Ignition SW * 1 : TMC Made 1MZ–FE, TMC Made 3MZ–FE * 2 : Except * 1 8 2G 3 IF6 W 2 1E 4 1L SB W–R 5 2O 27 Charge C7 Combination Meter 5A ALT–S W 33 SB 30A AM2 2 1A 106 3B Cut Off 67 3A B B–G B 116 3B 126 3B 117 3A 1 W SB 2 Y–G 1 18 120A ALT ALTL 13 IL2 14 IL2 B–G 1 1 A 1 B 4 B B S L FL MAIN 3.
Service Hints G2 (B) Generator (B) 1–Ground : 13.9–15.1 volts with the engine running at 2000 rpm and 25°C (77°F) 13.5–14.
Engine Control for 1MZ–FE and 3MZ–FE * * * * ACC W 2 AM1 1: 2: 3: 4: 1MZ–FE TMC Made TMMK Made Shielded B–W IG1 7 AM2 ST1 1 B–Y IG2 6 B–R B–Y ST2 8 2 2A IF1 W–R B–R I15 Ignition SW 5A AM1 B–Y B–W B–R 2 2E L B–W B–R B–Y L B–W 8 1C B–W IF6 W–R 3 10A IG2 2 1E 4 1B 9 1B 3 1B 4 1C 1 C/OPN Relay 4 1D 6 1C 7 1C B–O 6 1K 2 G–R 3 L–B 3 1 5 2 3 1 1 B B–W 1 1 W–B B–G 5 1C 1 A/F HTR Relay 5 EFI Relay 2 2 1A 5 20A EFI 25A A/F 30A AM2 B–G 1 1 120A AL
B–W B–W From Power Source System (See Page 60) 5 IF1 B–Y B–Y B–O 15A STOP 8 1H 13 2G W 3 2 8 1K SB B–Y B–Y S14 Stop Light SW B–W 4 1 5 B–W B–Y B–Y B–W 2 A 8 A 3 A 16 E 17 E +B +B2 MREL BATT NSW 7 2G 41 3A IF2 7 IJ1 G–W B–R 1 A 61 3A R–B B–R 5 4 2M G–W N G–W P R–B I10 A4 Park/Neutral Position SW 4 B–R G–W 7 1K B–O IF4 B–O 12 12 B 19 B STA ST1– STP E 6(A), E 7(B), E 8(C), E 9(D), E10(E) Engine Control Module ACM OX1B HT1B 21 D 25 D 3 1 L
Engine Control for 1MZ–FE and 3MZ–FE * * * * B–W 1: 2: 4: 5: 1MZ–FE 3MZ–FE Shielded Automatic A/C BR 9 IC2 BR IL1 BR 10 1 V11 Vapor Pressure Sensor I6 VG 3 E2G THA 2 4 T12 Throttle Control Motor Throttle Position Sensor 1 M+ M– VTA2 VTA1 4 6 1 4 IC2 2 ID1 VC 5 P 2 2 3 E2 2 PTNK 3 P E2 E4 Engine Coolant Temp.
From Power Source System (See Page 60) 15A IGN 10A TAIL 1 2G 16 2G B–R 10 1L 10A MIR HTR B–R B–R B–R 1 1 1 I12 Injector No. 6 B–R 2 I11 Injector No. 5 2 I10 Injector No. 4 2 I9 Injector No. 3 2 I8 Injector No. 2 B–R E5 B–R E5 B–R E5 1 1 Y W R–L G G B–Y 2 E 3 E 4 E 5 E 3 D 12 A 13 A L I8 R L L B–R 2 1 (* 5) E5 B–R B–R 2 I7 Injector No.
Engine Control for 1MZ–FE and 3MZ–FE From Power Source System (See Page 60) 10A ETCS 2 1B L–R I1 Ignition Coil and Igniter No. 1 I2 Ignition Coil and Igniter No. 2 I3 Ignition Coil and Igniter No. 3 I4 Ignition Coil and Igniter No. 4 I5 Ignition Coil and Igniter No. 5 I6 Ignition Coil and Igniter No.
* * * * * * 2 : TMC Made 3 : TMMK Made 5 : Automatic A/C 6 : Manual A/C 7 : Manual A/C TMMK Made USA 8 : Manual A/C TMMK Made Canada, Manual A/C TMC Made V–W T11 Transponder Key Computer G–R A23 Airbag Sensor Assembly Y–G L–B R–L P–B IF4 6 IJ1 6 R IF3 16 IF4 18 IF4 17 IF4 2 IF3 B 6 W G–R L 22 V–W GSW2 FAN NO. 1 Relay FAN NO. 2 Relay EFII 12 (*2) 7 (*3) A/C Lock Sensor EFIO 13 6 Diode (A/C No.
Engine Control for 1MZ–FE and 3MZ–FE 10A ECU–B 10A GAUGE1 From Power Source System (See Page 60) * 9 : w/ VSC *10 : w/o VSC TMC Made *11 : w/o VSC TMMK Made 7. 5A OBD 4 2A 6 2M 1 2M V–W G–R W W Y–G 125 3B 66 3A 67 3A 102 3A 105 3B 96 3A 97 3A 92 3A B–O B–O P–B W W W W W W G–R W J22(A), J23(B) Junction Connector 31 3B 32 3B W W R 35 A 11 A 12 A 1 A 21 A 16 B 36 A 84 3B 97 3B B B 74 3B 71 3B 22 3B 107 3B W B 13 7 16 Temp.
System Outline This system utilizes an engine control module and maintains overall control of the engine, transmission and so on. An outline of the engine control is explained here. 1. Input Signals (1) Engine coolant temp. signal circuit The engine coolant temp. sensor detects the engine coolant temp. and has a built–in thermistor with a resistance which varies according to the water temp. is input into TERMINAL THW of the engine control module as a control signal. (2) Intake air temp.
Engine Control for 1MZ–FE and 3MZ–FE 2. Control System ∗ SFI system The SFI system monitors the engine condition through the signals, which are input from each sensor to engine control module. The best fuel injection volume is decided based on this data and the program memorized by the engine control module, and the control signal is output to TERMINALS #10, #20, #30, #40, #50 and #60 of the engine control module to operate the injector (Inject the fuel).
Service Hints E4 Engine Coolant Temp. Sensor 1–2 : Approx. 15.04 kΩ (–20 C, –4 F) Approx. 5.74 kΩ (0 C, 32 F) Approx. 2.45 kΩ (20 C, 68 F) Approx. 1.15 kΩ (40 C, 104 F) Approx. 0.584 kΩ (60 C, 140 F) Approx. 0.318 kΩ (80 C, 176 F) E6 (A), E7 (B), E8 (C), E9 (D), E10 (E) Engine Control Module Voltage at engine control module wiring connector BATT–E1 : Always 9.0–14.0 volts +B, +B2–E1 : 9.0–14.0 volts (Ignition SW at ON position) VC–E2 : Always 4.5–5.5 volts (Ignition SW at ON position) VTA1–E2 : 0.3–0.
Engine Control for 1MZ–FE and 3MZ–FE : Parts Location Code See Page Code A4 36 (*1) A9 36 (*1) I1 A10 36 (*1) I2 40 A18 A23 A13 A C3 H10 See Page B 41 Code See Page K3 37 (*1) 37 (*1) K4 37 (*1) 37 (*1) M1 37 (*1) I3 37 (*1) P1 37 (*1) 40 I4 37 (*1) S1 37 (*1) 40 I5 37 (*1) S14 41 36 (*1) I6 37 (*1) T11 41 C7 A 40 I7 37 (*1) T12 37 (*1) C8 B 40 I8 37 (*1) V3 37 (*1) D3 40 I9 37 (*1) V4 43 E4 36 (*1) I10 37 (*1) V6 37 (*1) E6 A 40 I
: Connector Joining Wire Harness and Wire Harness Code See Page EB1 46 (1MZ–FE) Joining Wire Harness and Wire Harness (Connector Location) EB2 46 (3MZ–FE) IC2 50 Instrument Panel Wire and Floor Wire (Left Kick Panel) ID1 50 Engine Room Main Wire and Floor Wire (Left Side of Driver Side J/B) 50 Engine g Room Main Wire and Instrument Panel Wire (Right ( g Side of Steering g Column Tube)) 52 Instrument Panel Wire and Instrument Panel Wire (Instrument Panel Reinforcement RH) 52 Engine Wire and
Engine Control for 2AZ–FE ACC B–Y IG1 B–W 2 AM1 B–Y ST1 1 B–R W 7 AM2 IG2 6 (* 4) B–R W ST2 W–R 8 IF1 B–R I15 Ignition SW B–Y 3 B–W IF6 2 2A B–W B–R 2 1E B–Y 5A AM1 W–R B–R 9 1B 3 1B 4 1C 8 1C 2 2E B–G 10A IG2 2 3 1 3 2 4 1D 6 1C 7 1C C/OPN Relay EFI Relay 5 B–O 5 G–R 1 20A EFI 120A ALT 30A AM2 2 L–B 1 1 1 2 1A 5 1C 6 1K B–G B–W 1 L–B B–W W–B B–G 5 ID1 4 F8 Fuel Pump FL MAIN 3.
B–O B–Y B–Y B–W W W (* 4) (*4) BR 1 : TMC Made 2 : TMMK Made 3 : Shielded 4 : California I6 M1 Mass Air Flow Meter BR I6 5 +B E2 E4 Engine Coolant Temp.
Engine Control for 2AZ–FE B–O B–O B–Y 5 IF1 B–Y * * * * B–Y BR 1 : TMC Made 2 : TMMK Made 3 : Shielded 4 : California 9 IC2 IL1 BR 10 BR BR I6 BR I6 1 E2 Y BR M+ I18 Intake Air Control Valve VTA2 VTA1 2 ID1 1 4 6 5 6 B W B–R LG 8 E 5 E 4 E 19 E 20 E IL1 Y I7 Y (*3) (*4) G 4 IC2 VC Y 2 M– 1 (*4) G–W (*4) P VDD P GND OUT G–B 2 Y 3 M 4 1H PTNK 3 E2 2 9 1K 10 1H VCC Y BR (* 4) (* 4) 5 3 Y 4 T12 Throttle Control Motor Throttle Position Sen
From Power Source System (See Page 60) 15A STOP B–O IF4 W 3 2 SB B–O 13 2G 2 (A/T) A4 Park/Neutral Position SW 4 S14 Stop Light SW B–W 61 3A (M/T) N 41 3A 4 1 7 2G G–W 5 (A/T) B–Y B–W 11 1K G–W P 7 IJ1 (A/T) B–W 2 1J G–W B–Y 8 1K (M/T) B–Y 8 1H 12 1 C6 Clutch Start SW B–Y (A/T) I1 R–B B–Y B–O B–O 4 2M SB 30 A 12 A NSW 16 A STA 4 B ST1– STP E 6(A), E 7(B), E 9(D), E10(E) Engine Control Module HA1A A1A+ 21 E A1A– E1 31 E G2+ 3 E 26 E NE– NE+ 3
Engine Control for 2AZ–FE From Power Source System (See Page 60) 15A IGN 2 I3 Ignition Coil and Igniter No. 3 IGT IGF IGT IGF IGT IGF 3 2 3 2 3 2 2 W–R W–R IGF 2 W–R IGT E15 W–R Y W R–W P LG–B L–Y W–R E15 R E15 5 D 2 D 1 D 17 E 16 E 15 E 14 E 23 E L I8 I4 Ignition Coil and Igniter No. 4 3 W–R B–R 2 I10 Injector No. 4 B–R 1 I9 Injector No. 3 B–R 1 I8 Injector No. 2 B–R E13 I2 Ignition Coil and Igniter No. 2 L L I1 Ignition Coil and Igniter No.
From Power Source System (See Page 60) * * * * * 10A MIR HTR 2 2S 2 1B 12 7 EFIO GSW2 13 (* 1) 6 (* 2) 22 L G B R–L L–B B–Y A B FAN NO. 1 Relay FAN NO. 2 Relay Diode (A/C No.
Engine Control for 2AZ–FE From Power Source System (See Page 60) 7.
From Power Source System (See Page 60) * * * * * 1: 2: 7: 8: 9: TMC Made TMMK Made w/ VSC w/o VSC TMC Made w/o VSC TMMK Made 10A ECU–B 10A GAUGE1 6 2M 1 2M W W V–W 102 3A 66 3A 67 3A 92 3A 96 3A 97 3A G–R Y–G W 125 3B W G–R W W W 12 A 16 B 36 A 1 A 21 A Malfunction Indicator Lamp W 11 A Temp.
Engine Control for 2AZ–FE System Outline The engine control system utilizes a microcomputer and maintains overall control of the engine, transaxle etc. An outline of the engine control is given here. 1. Input Signals (1) Engine coolant temp. signal circuit The engine coolant temp. sensor detects the engine coolant temp. and has a built–in thermistor with a resistance, which varies according to the engine coolant temp.. The engine coolant temp.
2. Control System ∗ SFI system The SFI system monitors the engine condition through the signals input from each sensor to the engine control module. And the control signal is output to TERMINALS #10, #20, #30, #40 of the engine control module to operate the injector (Inject the fuel). The SFI system controls the fuel injection operation by the engine control module in response to the driving conditions.
Engine Control for 2AZ–FE Service Hints E6 (A), E7 (B), E9 (D), E10 (E) Engine Control Module BATT–E1 : Always 9.0–14.0 volts VC–E2 : 4.5–5.5 volts (Ignition SW at ON position) VTA1–E2 : 0.3–1.0 volts (Ignition SW on and throttle valve fully closed) 3.2–4.9 volts (Ignition SW on and throttle valve fully open) VG–E2G : 1.1–1.5 volts (Engine idling and A/C SW off) THA–E2 : 0.5–3.4 volts (Engine idling and intake air temp. 20°C, 68°F) THW–E2 : 0.2–1.0 volts (Engine idling and coolant temp.
: Parts Location Code See Page A4 38 (*2) Code See Page F8 42 Code See Page J11 42 A8 38 (*2) H6 38 (*2) J16 D 41 A18 40 H13 41 J17 E 41 A23 40 I1 39 (*2) J22 A 41 J23 B 41 A38 B 40 I2 39 (*2) A40 A 40 I3 39 (*2) K2 39 (*2) C1 38 (*2) I4 39 (*2) M1 39 (*2) C3 38 (*2) I7 39 (*2) P1 39 (*2) C6 40 I8 39 (*2) S1 39 (*2) C7 A 40 I9 39 (*2) S14 41 C8 B 40 I10 39 (*2) T11 41 D3 40 I15 41 T12 39 (*2) E4 38 (*2) I18 39 (*2) V4
Engine Control for 2AZ–FE : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) IC2 50 Instrument Panel Wire and Floor Wire (Left Kick Panel) ID1 50 Engine Room Main Wire and Floor Wire (Left Side of Driver Side J/B) 50 Engine g Room Main Wire and Instrument Panel Wire (Right ( g Side of Steering g Column Tube)) 52 Instrument Panel Wire and Instrument Panel Wire (Instrument Panel Reinforcement RH) 52 Engine Wire and Instrumen
Memo 99 2005 CAMRY (EWD586U)
Engine Immobilizer System From Power Source System (See Page 60) 10A ECU–B * * * * * 1 : Automatic A/C 1MZ–FE 2 : Automatic A/C 2AZ–FE 3 : Manual A/C 4 : TMC Made 5 : TMMK Made D3 Data Link Connector 15A IGN SIL 12 1B B–R 1 E7 Engine Control Module IF1 22 3B IMI ANT2 GND TXCT VC5 7 5 1 W R–L L–B 1 1 2 2 9 9 13 6 12 (* 4) 7 (* 5) +B CODE CODE 4 15 11 IG VC5 14 8 D TXCT AGND IND 4 12 5 13 8 3 KSW EFII GND 16 14 L 3 10 V G–W EFIO 34 3B 36 3B 44 3B 26 3B J22(A
Service Hints T11 Transponder Key Computer 1–Ground : Always approx. 12 volts 2–Ground : Approx.
Headlight From Power Source System (See Page 60) 1 40A MAIN 2 R 1 HEAD Relay 2 3 11 1H 3 1F R 3 1G 5 R–B 4 1G R–L 1 1 2 (* 4) 1 (* 3) 3 DRL NO. 2 Relay 1 (* 4) 2 (* 3) 5 2 1F 10A HEAD LH UPR 1 5A DRL 2 1 1 W–R W–R W–B W–L 3 W–L 1 2 W–B W–B 1 1 D16 Daytime Running Light Resistor 2 (*3) 1 (*4) R–B 2 H3 Headlight RH (High) 1 1 W–B 5 DRL NO.
From Power Source System (See Page 60) 10A ECU–B 1 : Pedal Type 2 : Lever Type 3 : TMMK Made 4 : TMC Made 10A ECU–IG 9 SIG B 6(A), B 7(B) Body ECU GND HRLY 12 DRL SGND PKB 8 2R 3 2F 4 2F 11 2B 11 2G BR R–W (*1) 8 2L R 18 R–B 24 W–B 16 SB 15 7 2S (*2) B R–W 1 * * * * J22(A), J23(B) Junction Connector 70 3B C A 90 3B 20 A (* 2) W 15 A R–W SB C B 28 A 38 A 1 (*4) 2 (*3) 3 86 3B 1 103 3A 76 3B BR R–L R–L R–W W–B 1 W–B W–L 93 3A 1 W DRL NO.
Headlight * * * * 5 : USA 6 : Canada 7 : TMC Made 1MZ–FE, TMC Made 3MZ–FE 8 : Except *7 B 6(A), B 7(B) Body ECU 16 B CLTS 17 B ALTL TAIL 18 B HEAD 8 A HF 9 A HU 10 A 17 R R–Y R–B R–Y P–L GR–R V–Y 14 13 8 7 126 3B 1 3 4 CLTB CLTE CLTS T 116 3B Light Control SW SB 13 14 B H HF EL HL 12 HU DRL(* 5) A (* 6) DRL OFF(* 5) OFF (* 6) A38 Automatic Light Control Sensor SDRL(*5) AUTO(* 6) 6 2R Y–G 15 B CLTE IL2 DRL(* 5) Tail Head Dimmer SW Y Low High Flash C11 C
System Outline Daytime Running Light Operation When the engine is started, a signal from the generator is input into TERMINAL (B) 18 of the body ECU. At this time, if the parking brake pedal is depressed or parking brake lever is pulled (Parking brake SW ON), the body ECU is not activated, and the daytime running light system does not operate. When the parking brake pedal or parking lever is released (Parking brake SW OFF), a signal is input into TERMINAL 18 of the body ECU.
Headlight : Ground Points Code EB EC II IJ IK See Page Ground Points Location 46 (*1) Right Fender 48 (*2) 46 (*1) Left Fender 48 (*2) 50 Cowl Side Panel LH 50 Instrument Panel Brace LH : Splice Points Code E2 See Page 46 (*1) * 1 : 1MZ–FE, 3MZ–FE Wire Harness with Splice Points Engine Room Main Wire * 2 : 2AZ–FE Code E2 * 3 : w/ Power Seat * 4 : w/o Power Seat 124 2005 CAMRY (EWD586U) See Page 48 (*2) Wire Harness with Splice Points Engine Room Main Wire
Memo 125 2005 CAMRY (EWD586U)
Fog Light From Power Source System (See Page 60) 1 15A HEAD LH LWR 15A FOG 2 5 1 1 3 R FOG Relay 2 4 2R 10 2C R–Y R IF2 R 12 2G G–R 6 105 3A 85 3A 11 10 Fog SW OFF Dimmer SW G–R BFG LFG G–R E10 GR R–Y R Low 17 HL HU EL HF ON High Flash 16 F2 Front Fog Light RH 1 W–B W–B 1 2 W–B 2 F1 Front Fog Light LH W–B C11 Combination SW A J4 Junction Connector EC EB IK 126 2005 CAMRY (EWD586U)
Service Hints FOG Relay 5–3 : Closed with the light control SW at HEAD position, dimmer SW at LOW position and fog SW on : Parts Location Code See Page C11 F1 Code See Page Code See Page 40 F1 38 (*2) F2 38 (*2) 36 (*1) F2 36 (*1) J4 41 : Relay Blocks Code 1 See Page Relay Blocks (Relay Block Location) 22 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 2C 28 Instrument Panel Wi
Automatic Light Control From Power Source System (See Page 60) 1 * 1 : USA * 2 : Canada 1 40A MAIN 120A ALT 2 10A ECU–IG 10A ECU–B 2 B–G 1 1 2E 9 15 14 B R–B 11 1H DCTY SGND GND 1 C 24 3 2F 11 2B 8 2R F 12 CLTB CLTE CLTS 15 B 16 B 17 B P–L 14 GR–R SDRL(*1) AUTO(* 2) W–B 2 HRLY BR 3 TRLY R–G 3 B TAIL Relay HEAD Relay 2 SIG V–Y 1 J23 Junction Connector 5 W 5 R–B 1 B 7(B), B 8(C) Body ECU 1 R–G F 10 IC2 EL R–G H DRL(* 1) A (* 2) D6 Door Courtesy
System Outline The automatic light control system works when the light control SW is turned to AUTO. The automatic light control sensor detects the brightness around the vehicle. By this function, the system automatically turns the taillight and headlight on if the brightness is below the regular level and turns the taillight and headlight off when the surroundings become brighter than the regular level. Service Hints Body ECU 9–Ground : Approx.
Light Auto Turn Off System From Power Source System (See Page 60) 1 * 1 : USA * 2 : Canada 1 40A MAIN 120A ALT 2 10A ECU–IG 10A ECU–B 2 B–G 1 1 2E 9 5 1 3 2 TRLY HRLY HEAD 14 15 9 A DCTY SGND 1 C 24 11 2B GND 12 3 2F J23 Junction Connector R R–B R–Y R–B 11 1H TAIL 8 A F 8 2R W–B 3 B TAIL Relay HEAD Relay 2 SIG BR 5 R–G 1 B 6(A), B 8(C) Body ECU 1 R–G F 10 IC2 EL H R–G 14 13 DRL(* 1) A (*2) T DRL(* 1) D6 Door Courtesy SW Front LH Light Control SW
System Outline 1. Normal Lighting Operation With the light control SW turned to TAIL position, a signal is input into TERMINAL (A) 8 of the body ECU. Due to this signal, the current flowing to TERMINAL 14 of the ECU flows to TERMINAL (A) 8 to TERMINAL 14 of the light control SW to TERMINAL 16 to GROUND, and TAIL relay causes taillights to turn on. With the light control SW turned to HEAD position, a signal is input into TERMINALS (A) 8 and (A) 9 of the body ECU.
Light Auto Turn Off System : Ground Points Code II IJ IK See Page Ground Points Location 50 Cowl Side Panel LH 50 Instrument Panel Brace LH 132 2005 CAMRY (EWD586U)
Memo 133 2005 CAMRY (EWD586U)
Interior Light From Power Source System (See Page 60) 10A ECU–B 7.
B 6(A), B 8(C) Body ECU LGCY 6 C R B2 B2 R B2 R G–R R R 5 1 2 IC2 G R R 4 IE1 R G 8 2S 3 1 G G–R DOOR 2 L5 Luggage Compartment Light 1 ON OFF I17 Interior Light G4 Personal Light V10 Vanity Light RH 1 (* 3) 2 (* 4) 2 1 G 2 IE1 W–B 2 D4 Diode W–B W–B W–B R R–Y 5 B5 L4 Luggage Compartment Light SW 2 V9 Vanity Light LH R 2 (* 3) 1 (* 4) B1 B1 W–B B1 W–B R 1 W–B B5 R R R W–B N4 Noise Filter 2 2 IE1 R 1 : w/ Engine Immobilizer System 2 : w/o Engine I
RCTY F 3 2S 9 IN4 1 BR 20 W–B PCTY D9 Door Courtesy SW Rear RH F 7 2K R–W 11 A BR W–B 1 R–W 1 D8 Door Courtesy SW Rear LH R–G DCTY R–W R–G 4 IN4 R–G J23 Junction Connector 1 C D7 Door Courtesy SW Front RH R–G 10 IC2 R–G D6 Door Courtesy SW Front LH Interior Light B 6(A), B 8(C) Body ECU 12 GND 24 8 2R SGND 11 2B 1 II 136 2005 CAMRY (EWD586U) IJ
Service Hints Body ECU 9–Ground : Approx. 12 volts with the ignition SW at ON or ST position 12, 24–Ground : Always continuity 1–Ground : Always approx.
Illumination W 2 2M 68 3A 10A PANEL 38 3A 3 28 3A 27 3A 48 3A 2 TAIL Relay G G G G (*2) G 1 (*1) 14 35 A (*3) 3 B (*4) 3 5 1 2 1 2 C4 Cigarette Lighter R B–G 40 A (*3) 20 B (*4) S4 Seat Heater SW (Driver’ s Seat) TAIL 8 A S5 Seat Heater SW (Front Passenger’ s Seat) TRLY A13(A), A40(B) A/C Control Assembly B 6(A) Body ECU 1 2E H10 Heater Control SW 5 2 4 14 T 1 H EL DRL(* 7) A (* 8) W–G W–G W–G (* 2) W–G DRL(* 9) (* 1) Light Control SW 120A ALT 1 W–G DRL
* 1 : Automatic A/C * 2 : Manual A/C * 3 : 1MZ–FE * 4 : 2AZ–FE * 5 : Separate Type Amplifier * 6 : Built–In Type Amplifier * 7 : USA * 8 : Canada * 9 : w/ Navigation System * 10 : w/o Navigation System * 11 : TMC Made * 12 : TMMK Made 78 3A 88 3A 128 3A 108 3A 3 1 (*1) 1 (*2) LH RH W–B W–G (*5) 5 IH1 W–B (* 5) W–G 2 W–G 6 SWG Steering Pad SW G3 Glove Box Light and SW A36 A/T Shift Lever Illumination G C5 Clock 4 1 R(*12) EAU R13 Radio and Player (* 10) Radio and Player with Displa
Illumination From Power Source System (See Page 60) 10A GAUGE1 1 2M 10A ECU–B *11 : TMC Made *12 : TMMK Made 6 2M W W 98 3A 66 3A 97 3A 96 3A W 21 A 1 A G W G 67 3A C 7(A), C 8(B) Combination Meter 26 A (*11) (* 11) (*11) Power (*12) 4 20 A W G 1 B Y(*12) O(* 11) 1 7 B LG(*11) 20 B W(* 12) 11 B W–G Illumination 3 53 3A R5 Rheostat 86 3B BR 76 3B IJ 140 2005 CAMRY (EWD586U)
Service Hints TAIL Relay 5–3 : Closed with the light control SW at TAIL or HEAD position C11 Combination SW 14–16 : Closed with the light control SW at TAIL or HEAD position : Parts Location Code A13 See Page A 40 A36 A40 B6 Code C8 See Page B 40 Code R3 See Page B 41 40 C10 40 R4 41 B 40 C11 40 R5 41 A 40 G3 41 R13 41 C4 40 H10 41 S4 41 C5 40 J4 41 S5 41 C7 A 40 R2 A 41 : Relay Blocks Code 1 See Page Relay Blocks (Relay Block Location) 22 Engine Room R/B (En
Turn Signal and Hazard Warning Light From Power Source System (See Page 60) * * * * * * 10A GAUGE1 1: 2: 3: 4: 5: 6: Automatic A/C Manual A/C TMMK Made TMC Made 1MZ–FE 2AZ–FE 15A HAZ LG–B (*2) 1 2M LG–B 1 1B W W (*1) H B 67 3A 8 J22(A), J23(B) Junction Connector IF3 F A 7 W–B GND 6 G–Y ER 5 G–B EL T7 Turn Signal Flasher Relay C11 Combination SW G–Y LR 2 G–W LL 3 1 3 LH 6 Turn 5 2 (* 3) 2 (* 4) 64 3A W–B W–B R7 Rear Combination Light RH 3 (* 3) 1 (* 4) 8 2M 6 20 A A
Service Hints T7 Turn Signal Flasher Relay 1–Ground : Approx. 12 volts with the ignition SW at ON or ST position 4–Ground : Always approx.
Taillight B–G 1 2E 1 * * * * 5 1 : TMMK Made 2 : TMC Made 3 : USA 4 : Canada TAIL Relay 2 3 10A TAIL 14 TRLY B 6(A) Body ECU TAIL 3 2G 19 2K G G R 15 2G G 8 A 14 T H EL DRL(* 3) A (*4) Light Control SW DRL OFF(* 3) OFF (* 4) DRL(*3) Tail G B8 G B3 B9 Head G G 16 G C11 Combination SW G B–G AUTO(*4) 6 2 1 L2 License Plate Light RH Tail Tail 6 L1 License Plate Light LH 2 4 R7 Rear Combination Light RH 2 4 2 1 W–B W–B (*2) W–B W–B (*1) W–B B–G 1 1
Service Hints TAIL Relay 5–3 : Closed with the light control SW at TAIL or HEAD position C11 Combination SW 14–16 : Closed with the light control SW at TAIL or HEAD position : Parts Location Code B6 See Page A Code 40 C11 F10 40 F9 See Page Code 36 (*1) See Page L1 43 38 (*2) L2 43 36 (*1) J4 41 R6 43 38 (*2) J11 42 R7 43 : Relay Blocks Code 1 See Page Relay Blocks (Relay Block Location) 22 Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector
Stop Light From Power Source System (See Page 60) * * * * 1 : w/ Rear Spoiler 2 : w/o Rear Spoiler 3 : TMMK Made 4 : TMC Made 15A STOP W 13 2G 2 S14 Stop Light SW G–W 1 7 2G G–W 15 2K 6 W–B Stop 1 R7 Rear Combination Light RH 2 G–W B6 (*1) G–W G–W B6 (*2) G–W Stop 1 R6 Rear Combination Light LH G–W G–W B5 G–W G–W B8 1 1 H12 High Mounted Stop Light 1 H12 High Mounted Stop Light 2 N4 Noise Filter 6 B11 W–B (* 3) B11 W–B (* 1 *4) W–B (* 1 *3) W–B (* 2 *3) W–B
Service Hints S14 Stop Light SW 2–1 : Closed with the brake pedal depressed : Parts Location Code See Page Code See Page Code See Page H12 42 N4 43 R7 43 J11 42 R6 43 S14 41 : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 2G 28 Engine Room Main Wire and Driver Side J/B (Lower Finish Panel) 2K 28 Floor Wire and Driver Side J/B (Lower Finish Panel) : Ground Points Code See Page Ground Points Location BQ 54 Front Sid
Back–Up Light From Power Source System (See Page 60) * 1 : TMMK Made * 2 : TMC Made 10A GAUGE2 R–L 6 2B 3 IL1 R–L 2 (A/T) R–L (M/T) 2 A4 Back–Up Light SW B1 Back–Up Light SW R–B 1 R–B (A/T) 1 (M/T) IL1 R–B 2 5 2R R–B 3 2K R6 Rear Combination Light LH W–B (* 1) W–B B11 (*1) W–B W–B W–B B11 (*1) 6 W–B 6 Back–Up 2 R7 Rear Combination Light RH R–B 2 Back–Up R–B B8 (* 2) BS BQ 148 2005 CAMRY (EWD586U)
Service Hints B1 Back–Up Light SW (M/T) 1–2 : Closed with the shift lever at R position A4 Back–Up Light SW (A/T) 1–2 : Closed with the shift lever at R position : Parts Location Code See Page A4 Code See Page 36 (*1) B1 38 (*2) 38 (*2) R6 43 Code R7 See Page 43 : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) 2B 28 Instrument Panel Wire and Driver Side J/B (Lower Finish Panel) 2K 28 Floor Wire and Driver Side J/B (Lower Fini
Navigation and Audio System From Power Source System (See Page 60) R 4(A), R12(B), R13(C) Radio and Player with Display 10A RAD NO. 2 20A RAD NO. 1 GR AMP MUTE 3 A 7 A F. R 8 A F. L 9 A R. R 18 A R.
SWG GND SW2 6 C REV 20 A 8 C 3 B V–W W W 93 3B 52 3A 66 3A 67 3A 83 3B 92 3A 96 3A 97 3A BR (* 5) O 1 2M R–B 10 (* 4) B (* 5) B (* 4) R (* 5) Y (* 4) L 6 2M 12 10A GAUGE2 SPD 5 B 6 2B 11 10 11 EAU AU2 W 5 2L W MODE W Seek+ 36 A 1 A 21 A Seek– 5 2R 1 R BR 2 IH3 7 IH2 R–L W–B 2 12 B IL1 35 A W GND 13 A C 7(A), C 8(B) Combination Meter A4 A/T Indicator Light SW S12(A), S13(B) Stereo Component Amplifier 3 Power R–L IL1 R–B 2 W–B Volume– S
Navigation and Audio System System Outline The navigation system displays the operating status and instructions for the radio and player with display. Additionally, the navigation system precisely measures the current vehicle position, displays the map obtained from the map database on the screen, and informs the route to the destination shown on the map using voice guidance. Service Hints R4 (A) Radio and Player with Display (A)11–Ground : Approx.
: Splice Points Code I3 See Page 52 Wire Harness with Splice Points Code See Page Wire Harness with Splice Points Instrument Panel No.
Audio System for Separate Type Amplifier From Power Source System (See Page 60) R 4(A), R13(B) Radio and Player with Display 10A RAD NO. 2 20A RAD NO.
* 1 : TMC Made * 2 : TMMK Made R 4(A), R13(B) Radio and Player with Display SWG O(*1) 10 BR 11 12 10 11 AU1 EAU AU2 Steering Pad SW GND 20 A 8 B R(* 2) B(* 1) L(* 2) Y(* 1) 12 C10 Combination SW SW2 6 B B(* 2) SW1 7 B Seek+ MODE Seek– Volume+ Volume– S12(A), S13(B) Stereo Component Amplifier RL+ RL– RR+ RR– GND BR 4 IN2 1 2 R8 Rear Speaker LH BR 1 IN2 W 5 IN2 B 2 IN2 W–B 7 IH2 W 2 IH3 R 3 IH1 R 1 IH1 Y 6 IH1 Y 2 IH1 B W–B 13 A W 10 A R 3 A Y 1
Audio System for Separate Type Amplifier Service Hints R4 (A) Radio and Player (A)11–Ground : Approx. 12 volts with the ignition SW at ACC or ON position (A) 1–Ground : Always approx. 12 volts (A)20–Ground : Always continuity S12 (A), S13 (B) Stereo Component Amplifier (B) 2–Ground : Approx. 12 volts with the ignition SW at ACC or ON position (A) 7–Ground : Always approx.
Memo 257 2005 CAMRY (EWD586U)
Audio System for Built–In Type Amplifier From Power Source System (See Page 60) 1 1 2 1 IN2 4 IN2 W R 5 IN2 R Y 2 IN2 Y 4 A ACC+B 2 B 3 A R9 Rear Speaker RH B L–Y 1 2A GR 5 2A R8 Rear Speaker LH 20A RAD NO. 1 W 10A RAD NO.
Service Hints R2 (A) Radio and Player (A) 3–Ground : Approx. 12 volts with the ignition SW at ACC or ON position (A) 4–Ground : Always approx.
Combination Meter 10A GAUGE1 From Power Source System (See Page 60) 10A ECU–B V–W Radio and Player with Display V–W Engine Control Module W 6 2M B–O 7 1C W 1 2M 10A IG2 67 3A 8 2G 66 3A 97 3A 52 3A 96 3A 92 3A 102 3A 72 3A 32 3A 5 2O W W W Clock 36 A EEPROM Power Temp.
From Power Source System (See Page 60) 5A ECU–ACC ” PANEL” Fuse B–W B–W 91 3B W 9 A B–W W W 81 3B 8 A IF1 C 7(A), C 8(B) Combination Meter (*2) ABS Maint Reqd Illumination 11 A 4 B 3 B 17 B SB W W W R–B R–Y LG–R 11 B W–G 12 A (* 1) 14 A W–B Illuminations Clock Skid Control ECU with Actuator Skid Control ECU with Actuator Engine Control Module Engine Control Module 1 Buckle SW LH R5 Rheostat 39 A Airbag Sensor Assembly 4 W(*3) LG(* 2) 3 20 B O(*2) 7 B Y(* 3)
Combination Meter From Power Source System (See Page 60) 1 15A HEAD LH LWR 2 DRL NO.
W–B 1 6 2G Skid Control ECU with Actuator B2 Brake Fluid Level Warning SW R–L W W 16 A 2005 CAMRY (EWD586U) D N Turn RH Turn LH P R 3 2 L O/D OFF Brake O W W W W W W W SB SB C 7(A), C 8(B) Combination Meter Transmission Control SW A/T Indicator Light SW Transmission Control SW Engine Control Module Turn Signal Flasher Relay A/T Indicator Light SW 22 B 25 A 6 A 24 A 23 A 22 A 5 A 2 A 4 A 3 A 30 A 3 2N 2 ED 263
Combination Meter Service Hints B2 Brake Fluid Level Warning SW 1–2 : Closed with the float down C7 (A) Combination Meter (A) 21, (A) 27–Ground : Approx. 12 volts with the ignition SW at ON or ST position (A) 1–Ground : Always approx. 12 volts (A)15, (A) 20, (B) 12–Ground : Always continuity O1 Oil Pressure SW 1–Ground : Continuity with the oil pressure above approx. 20 kpa (2.8 psi, 0.
Memo 265 2005 CAMRY (EWD586U)
I GROUND POINT W–B (* 20) W–B(* 6, * 17) W–B W–B(* 16) Pressure SW E4 W–B W–B(* 11) W–B E4 W–B (* 6, * 17) E4 W–B W–B W–B E3 (* 5, * 14, * 19) Skid Control ECU with Actuator (* 12) (GND) (*12) W–B E4 (GND1) (*13) Skid Control ECU with Actuator (* 13) W–B Front Fog Light RH (GND2) (GND) (*12) W–B Headlight RH (Low) W–B Skid Control ECU with Actuator(* 11) W–B W–B Washer Level Sensor (GND1) Keyless Buzzer Front Turn Signal Light RH W–B W–B(* 15) W–B W–B E4 W–B(* 17)
I * 1 : 1MZ–FE, 3MZ–FE * 2 : 2AZ–FE * 3 : Automatic A/C * 4 : Manual A/C * 5 : TMC Made * 6 : TMMK Made * 7 : Separate Type Amplifier * 8 : Built–in Type Amplifier * 9 : w/ Navigation System *10 : w/o Navigation System *11 : w/ VSC *12 : TMC Made w/o VSC *13 : TMMK Made w/o VSC *14 : * 13 w/ Power Adjustable Pedals *15 : * 13 w/o Power Adjustable Pedals *16 : w/ VSC TMC Made 2AZ–FE *17 : w/ VSC TMC Made 1MZ–FE, w/ VSC TMC Made 3MZ–FE *18 : w/ VSC TMMK Made 2AZ–FE *19 : w/ VSC TMMK Made 1MZ–FE, w/ VSC TMMK M
I GROUND POINT Combination Meter 76 3B 11 2B (SGND) Body ECU 86 3B W (ES) BR BR W–B (E2) Airbag Sensor Assembly IJ BR BR BR BR (SG) Data Link Connector 3 (HP) Engine Control Module (* 21) BR 78 3B 129 3B 98 3B 118 3B W BR BR (*1) 128 3B (*2) BR (*21) (ECC) Combination SW 16 * 1 : 1MZ–FE, 3MZ–FE * 2 : 2AZ–FE * 3 : Automatic A/C * 4 : Manual A/C * 21 : Automatic A/C 1MZ–FE * 22 : Manual A/C 2AZ–FE IL2 BR (*2) BR (* 1) BR (* 1) (E01) (E02) BR W–B W–B W–B Ignition
I A/C Control Assembly (GND) Heater Control SW (GND) (* 3) (* 4) Unlock Warning SW 5 IG1 W–B (* 4) W–B (* 4) W–B Air Vent Mode Control Servo Motor Glove Box Light and SW 54 3A 24 3A W–B 74 3A 125 3A W–B Shift Lock Control ECU W–B 104 3A 84 3A W–B Transmission Control SW W–B (GND) 14 3A 124 3A W–B Transponder Key Computer Clock 34 3A W–B W–B A/C Amplifier (* 22) W–B 64 3A 44 3A 17 IM1 W–B W–B B13 W–B Door Key Lock and Unlock SW Front RH Door Unlock Detection SW F
I GROUND POINT * 5 : TMC Made * 6 : TMMK Made * 21 : Automatic A/C 1MZ–FE * 23 : w/ Power Seat * 24 : w/o Power Seat * 25 : w/ Rear Spoiler * 26 : w/o Rear Spoiler W–B (*21) (TX1–) Clock 60 3B 70 3B 80 3B 90 3B 30 3B SB W–B SB TRAC OFF SW Combination Meter SB W–B W–B Power Seat Control ECU (Front Passenger’ s Seat) W–B A W–B A W–B A A Occupant Classification ECU W–B 4 1K Data Link Connector 3 Steering Sensor Turn Signal Flasher Relay (E) 1 1J W–B 1 Combination SW ST Relay
I License Plate Light LH W–B W–B License Plate Light RH (* 5) (* 5) W–B A (*5 * 26) W–B (* 5) B10 A A W–B High Mounted Stop Light W–B (* 5) B10 W–B (* 5) W–B B10 W–B (* 5) (* 5) W–B (* 5) Luggage Compartment Door Key Unlock SW J11 Junction Connector A A (* 5 *25) W–B W–B (* 5) (* 5) High Mounted Stop Light Rear Combination Light LH Rear Combination Light RH BS (* 5) W–B(* 5) BQ (* 5) Fuel Pump W–B Remote Control Mirror SW W–B W–B B4 W–B Seat Heater LH Buckle SW LH
I GROUND POINT : Parts Location Code See Page Code See Page J1 41 J18 A 44 (*3) J2 41 J19 B 44 (*3) J4 41 J11 42 J20 A Code J21 See Page B 44 (*3) 45 (*4) 44 (*3) 45 (*4) : Relay Blocks Code 1 See Page 22 Relay Blocks (Relay Block Location) Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code 1C 1J 1K 2B 2D See Page 25 Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) 25 Engine Wire and Engine Room J/B (Engine Compartment
I : Ground Points Code EA EB EC ED See Page Ground Points Location 46 (*1) 48 (*2) Right Fender 46 (*1) 48 (*2) 46 (*1) 48 (*2) Left Fender 46 (*1) 48 (*2) EE 46 (*1) Left Side of Cylinder Head EF 46 (*1) Right Side of Cylinder Head EG 48 (*2) Left Side of Cylinder Head EH 48 (*2) Intake Side of Cylinder Block 50 Cowl Side Panel LH 50 Instrument Panel Brace LH 50 Instrument Panel Brace RH 50 Instrument Panel Reinforcement RH BO 54 Under the Driver’s Seat II IJ IK IL IM IN BP
J POWER SOURCE (Current Flow Chart) 304 2005 CAMRY (EWD586U)
J 305 2005 CAMRY (EWD586U)
J POWER SOURCE (Current Flow Chart) Engine Room J/B (See Page 24) Fuse 5A System Page ALT–S Charging 72 ST Combination Meter Starting and ignition (1MZ–FE, 3MZ–FE) Starting and ignition (2AZ–FE) 260 64 68 10A ETCS Cruise Control (1MZ–FE, 3MZ–FE) Cruise Control (2AZ–FE) Engine Control (1MZ–FE, 3MZ–FE) Engine Control (2AZ–FE) 192 198 74 86 10A HEAD LH UPR Headlight Multiplex Communication System (BEAN) 120 104 10A HEAD RH UPR Headlight Multiplex Communication System (BEAN) 120 104 HORN H
J Fuse 25A System Page A/F Engine Control (1MZ–FE, 3MZ–FE) 74 25A DOOR1 Multiplex Communication System (BEAN) Theft Deterrent and Door Lock Control Wireless Door Lock Control 104 152 158 30A ABS NO.
J POWER SOURCE (Current Flow Chart) Fuse 10A 10A 10A ECU–B ECU–IG FAN RLY System Page ABS (TMC Made) ABS (TMMK Made) Automatic Air Conditioning (1MZ–FE) Automatic Air Conditioning (2AZ–FE) 176 180 272 278 Automatic Light Control Clock Combination Meter Cruise Control (1MZ–FE, 3MZ–FE) 128 246 260 192 Cruise Control (2AZ–FE) Electronically Controlled Transmission and A/T Indicator (1MZ–FE, 3MZ–FE) Electronically Controlled Transmission and A/T Indicator (2AZ–FE) 198 Engine Control (1MZ–FE, 3MZ–
J Fuse 10A 10A GAUGE1 GAUGE2 System Page Charging Clock Combination Meter Cruise Control (1MZ–FE, 3MZ–FE) 72 246 260 192 Cruise Control (2AZ–FE) Electronically Controlled Transmission and A/T Indicator (1MZ–FE, 3MZ–FE) Electronically Controlled Transmission and A/T Indicator (2AZ–FE) 198 Engine Control (1MZ–FE, 3MZ–FE) Engine Control (2AZ–FE) Illumination Key Reminder 74 86 138 150 Multiplex Communication System (BEAN) Navigation System, Audio System Seat Belt Warning Shift Lock 104 250 224 21
J POWER SOURCE (Current Flow Chart) Fuse System Page 10A TAIL Engine Control (1MZ–FE, 3MZ–FE) Engine Control (2AZ–FE) Taillight 15A CIG Power Outlet and Cigarette Lighter 234 15A FOG Fog Light 126 15A POWER POINT Power Outlet and Cigarette Lighter 234 ABS (TMC Made) ABS (TMMK Made) Cruise Control (1MZ–FE, 3MZ–FE) Cruise Control (2AZ–FE) 176 180 192 198 Electronically Controlled Transmission and A/T Indicator (1MZ–FE, 3MZ–FE) Electronically Controlled Transmission and A/T Indicator (2AZ–F
J Fuse 50A 120A ABS NO.
K CONNECTOR LIST A1 A2 A3 A4 A6 Black Gray Gray Gray Gray 1 2 1 1 A7 2 1 2 2 1 3 5 6 2 2 3 4 7 8 9 A8 A9 A10 A11 A12 Dark Gray Dark Gray Dark Gray Yellow Yellow 1 1 1 2 1 2 1 2 3 4 3 4 3 4 A13 A14 A15 Black Black 12 12 2 A16 A20 1 2 3 4 5 1 2 3 4 5 Black 12 A21 A21 (Automatic A/C) (Manual A/C) 1 2 3 4 5 1 2 3 4 5 6 7 8 1 4 A22 A23 A24 Yellow Yellow Yellow 1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8 9 10 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
K A35 A36 A37 (TMMK Made) 1 2 3 4 5 6 7 8 9 10111213 14 1 2 3 4 1 2 3 4 1 2 3 4 5 6 7 8 A39 A40 1 2 3 4 5 6 7 8 9 10 1 2 3 4 5 6 7 8 9 10 11 12 B3 1 B4 B5 Black Black 2 3 B1 B2 Gray Gray 1 1 2 2 11 12 13 14 15 16 17 18 19 20 13 14 15 16 17 18 19 20 21 22 23 24 1 A38 Yellow B6 4 1 2 3 B7 2 1 2 3 4 5 6 7 8 9 10 11 4 12 13 14 15 16 17 18 19 20 21 22 B8 B9 1 2 3 4 5 6 7 8 9 101112 B10 B10 (TMC Made) (TMMK Made) 1 2 3 4 1 2 3 4 5 6 7 8 9 1 1 2 2 10 11 12 13 1
K CONNECTOR LIST C6 C7 C8 Black 1 2 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 C9 C10 Black Black C11 1 2 3 4 5 6 7 8 9 1 2 3 4 5 6 1 10 11 12 131415 16 17 18 7 8 9 10 11 12 9 10 1112131415 16 17 C13 2 3 C12 4 5 6 7 1 2 8 C14 C15 C16 C16 Yellow Yellow (TMC Made) Black (TMMK Made) Yellow 1 2 1 1 2 1 2 1 2 C17 C17 D1 D2 (TMC Made) Black
K D12 D13 D13 (TMC Made) (TMMK Made) Black 1 1 2 3 4 5 6 2 1 3 4 5 6 7 8 9 D14 2 1 3 4 5 6 2 3 4 5 6 7 8 9 10 10 11 12 13 14 15 16 17 18 D15 D16 E3 Gray Gray E4 E4 (1MZ–FE, 3MZ–FE) Dark Gray (2AZ–FE) Black 1 2 1 2 3 4 1 5 6 7 8 9 10 E5 1 2 1 2 3 4 5 6 7 8 9 10 11 12 13 2 E6 E7 E8 Black 1 2 1 2 3 4 5 6 1 7 8 9 10 11 12 13 14 15 16 17 2 3 4 3 4 5 2 3 26 27 30 31 28 29 30 28 29 28 29 31 32 33 34 35 6 7 1 2 3 4 5 6 30 F1 F2 Brown Brown
K CONNECTOR LIST *1 : w/ Rear Spoiler *2 : w/o Rear Spoiler F12 F12 (TMC Made) Black (TMMK Made) Black G1 *3 : 2AZ–FE California TMC Made *4 : 2AZ–FE California TMMK Made G2 G3 Black Black 1 1 1 2 3 2 G4 1 2 3 4 1 H1 H2 H3 H4 Black Brown Black Brown 1 1 1 1 2 2 2 2 2 1 2 3 4 5 H6 H6 H7 H8 H9 (1MZ–FE, 3MZ–FE) Dark Gray (2AZ–FE) Black Black Black 1 1 2 3 4 1 2 1 2 3 4 3 4 H10 1 H11 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 2
K I11 I12 I13 I14 Gray Gray Gray Black 12 12 1 2 1 I15 2 3 4 5 6 7 1 2 3 4 5 6 7 8 I16 I17 I17 I18 J1 Black (TMC Made) (TMMK Made) Gray Black (1MZ–FE, 3MZ–FE) Dark Gray 1 2 3 1 2 3 1 2 3 A A A A A A A A A A A A A 1 2 3 4 5 6 7 4 5 J1 J2 J4 J5 (2AZ–FE) Dark Gray A A A Black A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A B B C C A D D D E E E J6 J7 J8 J11 A A B B C C A A B B C C A A B B C C D D D E E E D D E E F F D D E E F F Black
K CONNECTOR LIST *5 : TMC Made w/ Mirror Heater *6 : TMC Made w/o Mirror Heater J20 J21 J21 Gray (TMC Made) Gray (TMMK Made) J22 A A B B C C C D D E E A A B B A A A A A C C B B DE F GHI J K A A A A A C C B B DE F GHI J K J23 A A C C F F F F G G G H H H H DE F GHI J K K1 K2 K3 K3 Black Black (1MZ–FE) Dark Gray (3MZ–FE) Gray 1 A A B B C C C D D E E A 1 2 2 1 2 1 F F F F G G G H H H H K4 K4 L1 L2 (1MZ–FE) Dark Gray (3MZ–FE) Gray Gray Gray 1 2 1 2
K O6 O7 O8 O9 Black Black Black Gray 1 2 3 1 2 3 1 2 3 *7 : w/ Power Adjustable Pedals *8 : w/o Power Adjustable Pedals 1 2 3 4 5 6 7 8 9 101112 O10 O11 O12 O13 O14 Black Gray Black Black Black 1 2 3 4 5 6 7 8 9 101112 1 2 3 1 2 3 1 2 3 P1 P2 P3 P3 Black Gray (*7) Blue (*8) 1 2 3 P4 P5 2 1 2 1 1 2 1 4 1 1 2 3 P6 P6 P7 P7 P8 (TMC Made) (TMMK Made) (TMC Made) Black (TMMK Made) (TMC Made) 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 1 2 3 4 5 P8 P9 P9 P
K CONNECTOR LIST *9 : TMC Made w/o VSC P23 P24 P25 P28 P28 Black Black Black (TMC Made) (TMMK Made) P29 12 34 1 2 1 2 1 2 3 4 5 1 2 R1 R2 R3 R4 R5 Blue Gray 1 2 3 4 1 5 6 7 8 9 10 1 1 2 Black 2 1 3 4 5 6 2 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 R6 R7 R8 R9 R10 (TMC Made) 2 1 2 1 4 3 4 3 6 5 6 5 2 1 2 1 1 2 3 4 5 6 7 8 9 10 R10 R12 (TMMK Made) Black Gray 1 2 3 4 5 1 2 3 4 5 6 7 8 9 10 R13 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 S1 (*9)
K *10 : TMMK Made w/o VSC S1 (*10) Black 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 S1 S2 (w/ VSC) Black Black S3 1 1 1 2 31 32 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 33 34 35 36 37 38 39 40 41 42 43 44 45 46 S4 S5 Black Blue S6 1 2 3 4 5 6 1 2 3 4 5 6 S11 Gray S12 1 2 3 4 5 1 2 3 4 5 6 7 8 9 10 S13 S14 S15 Blue Yellow 1 2 3 4 5 6 7 8 9 1011121314 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 1 3 S16 S17 S18
K CONNECTOR LIST *11 : TMMK Made Except 2AZ–FE California *12 : TMMK Made 2AZ–FE California, TMC Made T7 T9 T10 T11 T12 Black Black 12 3 456 7 8 1 2 3 4 1 2 3 4 1 2 3 4 5 6 1 2 3 4 5 6 7 8 9 10 11 12 13 14 U1 1 2 V3 V4 V4 V6 Blue (*11) Blue (*12) Black (1MZ–FE, 3MZ–FE) Blue 1 1 2 2 1 2 1 2 V6 V7 V8 V9 V9 V10 (2AZ–FE) Black Black Black (TMC Made) Blue (TMMK Made) (TMC Made) Blue 1 1 2 1 2 1 2 1 2 V10 V11 V11 V13 V14 (TMMK Made) (TMC Made) Black (TMMK Ma
Memo 323 2005 CAMRY (EWD586U)
L PART NUMBER OF CONNECTORS Code Part Name Part Number Code Part Name Part Number A1 A/C Ambient Temp.
L Code Part Name Part Number Door Key Lock and Unlock SW Front RH D11 Door Lock Motor Front RH 90980–12226 Code D12 D13 Power Window Master SW 90980–12122 Door Lock Control SW RH (TMC Made) 82824–12270 Door Lock Control SW RH (TMMK Made) 90980–10797 Door Lock Motor Rear LH D14 Door Unlock Detection SW Rear LH Door Lock Motor Rear RH D15 90980–12226 Headlight RH (High) 90980–11095 H4 Headlight RH (Low) 90980–11096 Heated Oxygen Sensor (Bank 1 Sensor 2) (1MZ–FE, 3MZ–FE) 90980–10869 H
L PART NUMBER OF CONNECTORS Code Part Name J12 Junction Connector J13 Junction Connector J14 Junction Connector J15 Junction Connector J16 Junction Connector J17 Junction Connector J18 Junction Connector J19 Junction Connector J20 Junction Connector J21 Junction Connector J22 Junction Connector Part Number 90980–11915 90980–12355 90980–12374 90980–11915 Junction Connector K1 Keyless Buzzer 90980–11142 K2 Knock Sensor (Bank 1) 90980–11875 Knock Sensor (Bank 1) (1MZ–FE) 909
L Code Part Name P13 Pretensioner LH P14 Pretensioner RH P15 Power Seat Control SW (Driver’s Seat) P16 Power Seat Control SW (Front Passenger’s Seat) P17 Power Seat Motor (Driver’s Seat Front Vertical Control) P18 Power Seat Motor (Driver’s Seat Lifter Control) P19 Power Seat Motor (Driver’s Seat Reclining Control) P20 Part Number 90980–12253 90980–10997 Power Seat Motor (Driver’s Seat Slide Control) 90980–10825 Code Part Name Part Number S5 Seat Heater SW (Front Passenger’s Seat) 9
M OVERALL ELECTRICAL WIRING DIAGRAM 328 2005 CAMRY (EWD586U)
[A] : System Title [B] : Indicates the wiring color. Wire colors are indicated by an alphabetical code. B = Black W = White BR = Brown L = Blue V SB = Sky Blue = Violet R = Red G = Green LG = Light Green P Y GR = Gray = Pink = Yellow [F] : Junction Block (The num and the connector code Junction Blocks are shad from other parts. Example: 3C it is Jun No. O = Orange The first letter indicates the basic wire color and the second letter indicates the color of the stripe.
330 SYSTEM INDEX SYSTEMS LOCATION SYSTEMS ABS (TMC Made) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14–2 Moon Roof . . . . . . . . . . . . . . . . . . ABS (TMMK Made) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15–2 Multiplex Communication System Audio System (Built–in Type Amplifier w/o Navigation System) . . . 29–3 Audio System (Separate Type Amplifier w/o Navigation System) . 28–2 Audio System (w/ Navigation System) . . .
M OVERALL ELECTRICAL WIRING DIAGRAM 328 2005 CAMRY (EWD586U)
[A] : System Title [B] : Indicates the wiring color. Wire colors are indicated by an alphabetical code. B = Black W = White BR = Brown L = Blue V SB = Sky Blue = Violet R = Red G = Green LG = Light Green P Y GR = Gray = Pink = Yellow [F] : Junction Block (The number in the circle is the J/B No. and the connector code is shown beside it). Junction Blocks are shaded to clearly separate them from other parts. Example: 3C indicates that it is inside Junction Block No.
SYSTEMS LOCATION SYSTEMS LOCATION ABS (TMC Made) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14–2 Moon Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21–4 ABS (TMMK Made) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15–2 Multiplex Communication System (BEAN) . . . . . . . . . . . . . . . . . . . . . . 1–2 Audio System (Built–in Type Amplifier w/o Navigation System) . . .
(Cont.
2005 CAMRY (EWD586U) J Right Fender W–B Left Fender W–B ED W–B W–B 1 4 1 W–B H4 Headlight RH (Low) W–B W–B H1 Headlight LH (High) R–B DRL NO. 2 Relay HEAD Relay Horn System <17–4> HORN Relay EC 2 1 Left Fender W–B W–L ON OFF Flash High Low AUTO(*6) Head Tail IK A 16 EL W–B EB W–B R W R–L W R–G I W–R L–W DRL NO. 4 Relay H3 Headlight RH (High) R–B W–B W–R 2 1 R–W H R 1 1 3 R–Y F 1 DRL NO.
1 CAMRY (Cont’ d) (Cont.
D5 Door Control Receiver 2005 CAMRY (EWD586U) W–B W L5 Luggage Compartment Light BP G N4 Noise Filter Under the Front Passenger’ s Seat II W–B Cowl Side Panel LH 8 2R 8 2P A13(A), A40(C) A/C Control Assembly H10(B) Heater Control SW 96 3A 66 3A 46 3A 68 3B 18 3B W Left Fender 14 IF4 W–B 2 EA2 2 1 1 EA2 E SH 24 SH– 1 1 IF3 25 Lower Back Panel Center T1 Theft Deterrent Horn W–B W–B K1 Keyless Buzzer W–B W–B ED 11 3 LUG 1 2 6 IC2 BS W–B (*3) Front Side of Rear Quarter
1 CAMRY (Cont’ d) M ultiplex C om m un ic a tio n S ys te m (B E A N ) 17 * 3 : TMMK Made * 4 : TMC Made 20 19 18 B 6(A), B 7(B), B 8(C) Body ECU L1 ACTD 11 C UL1 5 6 UL2 21 A 5 2S ACT+ ACT– 11 23 LSR SGND 19 24 Y 4 2K 11 2H 5 2C 12 2H 6 2C 16 2K 10 2H 11 2B BR L–B L–O L–O D A 4 2S L–B L–R L–R L–R L–Y G–R LG LG G–R L–Y LSWP 18 A L–W 6 2S L2 7 LG 1 2S LSWD 17 A L 1 2K L–B 10 2K UL3 22 A E A J 7(A), J 8(B) Junction Connector F B E B F B 6 BA1 3 BA1
M OVERALL ELECTRICAL WIRING DIAGRAM W–B EF W–B W–R 3 IGT IGF G–R W–R 2 W–R 3 IGT IGF W–R W–R 3 IGT IGF LG–B W–R 2 4 1 B–R +B W–B GND I3 Ignition Coil and Igniter No. 3 W–B B–R L–Y 2 4 1 B–R +B W–B GND I4 Ignition Coil and Igniter No. 4 W–R 3 IGT IGF P W–R W–R 2 4 1 +B 3 B–R GND I2 Ignition Coil and Igniter No. 2 W–B Engine Control Module <5–16> 4 1 GND W–B W–B +B 4 I5 Ignition Coil and Igniter No.
3 CAMRY S tarting a nd Ig n itio n (2 A Z – F E ) P o w e r S o urc e 1 8 IF1 B–R ACC W 2 AM1 8 1C B–Y IG2 6 B–R ST2 8 B–W B–Y 7 AM2 7 IF1 B–Y (M/T) B–Y N 11 1K B–W (A/T) 2 +B IGT IGF GND IGT IGF GND IGT IGF GND IGT IGF GND 3 2 4 3 2 4 3 2 4 3 2 4 W–B W–R W–R W–B W–B W–R L–Y W–B W–R LG–B W–B W–R P W–B W–R A A Engine Control Module <6–16> W–B J2 Junction Connector W–B W–B S 2(A), S 3(B) Starter 1 B 8 IL1 4 1K B–R B–R 1 A I4 Ignition Coi
1 120A ALT 2005 CAMRY (EWD586U) B B–G B–G Battery W B–G G 1(A), G 2(B) Generator 2 IG B 4 S L B R–L Y (*1) Y–G(*2) 13 IL2 SB 1 B 116 3B 126 3B Body ECU <1–7> Y–G B SB 106 3B II 117 3A 67 3A W–B Cowl Side Panel LH 14 IL2 W 1 A 33 A C 7(A) Combination Meter 3 5 8 2R 1 2M 2 1 W FL MAIN 3.
(Cont.
ANT2 2005 CAMRY (EWD586U) I14 Transponder Key Amplifier VC5 1 W–B 64 3A 54 3A W–B P W Transponder Key Coil ANT1 4 G–W CODE B 7 2F W–B 5 L–Y TXCT GND 16 14 KSW 3 10 L 7 VC5 14 8 IND 8 3 V GND CODE 15 11 7 4 CTY EFIO 13 6 12 (*1) 7 (*2) EFII D 9 (*1) 9 (*2) B–R L–B R–L G–R +B +B2 8 A BATT MREL 3 A 8 26 B IMO 27 B IMI 10 A FC E 6(A), E 7(B), E 8(C), E 9(D), E10(E) Engine Control Module 1 A 2 A B–R 6 2M TXCT 4 12 R–G 66 3A 56 3A AGND 5 13 1 : TMC Made 2 : TMMK
5 CAMRY (Cont’ d) (Cont. next page) * * * * * E n gine C on trol (1 M Z – F E , 3 M Z – F E ) A B C D E 9 B B–W 12 11 10 B A SB SB B–O B–R B SB B–R B–R B–R B–R B–R B–R F BR BR BR BR 5 +B E2 VG E2G THA 3 2 4 1 2 M+ M– VTA2 VTA1 VC 2 1 4 6 5 Y Y G LG B–R W B (*5) BR G–B L–B L–W R L L (*3) Y B–O G R–L W R Y 2005 CAMRY (EWD586U) E4 Engine Coolant Temp.
2005 CAMRY (EWD586U) K3 Knock Sensor (Bank 1) Right Side of Cylinder Head W–B W–B W–B (*5) W–B EE W–B EF W–B BR (*6) Y 2 ME01 4 C W–B N B–W E05 6 D E04 7 D Left Side of Cylinder Head W–B O W (*6) 2 W (*6) 1 E02 6 E PSW 1 IGT1 * * * * 8 E A/CS 31 B 10 C STA 17 E P1 Power Steering Oil Pressure SW BR R(*7) 1 B(*7) 1 1 EB2 2 EB2 E01 7 E W–B M G W–B BR W (*6) W (*7) 1 EB1 E03 7 C ELS2 13 A W–B BR BR BR R (*7) G (*7) 1 EKNK 28 D ELS 12 A 9 E IGT2 ACLD
5 CAMRY (Cont’ d) E ng in e C o ntro l (1 M Z – F E , 3 M Z – F E ) SB B–O W D 70 3B 2 2 1 4 BR 4 2P 18 2G 7 2D W P–B P–B O(*1) W(*2) Airbag Sensor Assembly<16–4> Skid Control ECU with Actuator<14–4><15–4> Skid Control ECU with Actuator <13–8><14–4><15–4> 4 Combination Meter<30–5> CANCEL ECC W A/C Control Assembly<32–7> – SET C10 Combination SW + RES 5 2D BR Y–G (*3) Combination Meter<30–5> Electronically Controlled Transmission and A/T Indicator System <7–4> 124 3B W V18 V
(Cont. next page) 6 CAMRY E n gine Im m ob iliz er S ys te m (2 A Z – F E ) P ow e r S o urc e 1 2 AM1 3 IF6 8 IF1 B–R I J K 12 1B 10 1L 5 2G B–R 8 1C B–R 7 1C B–R 4 1C B–R (*1) 3 1B 9 1B B–R 2 1E B–O 1 1D B–R 2 H I15 Ignition SW B–Y 5 G 1 IF1 B–W 1 E F ST2 W–R R (*1) 10A GAUGE2 5A AM1 7. 5A OBD 17 2G IG1 Relay 1 5 1 2 B–R 3 17 2K B–W 3 15A IGN 2 10A IG2 C/OPN Relay EFI Relay 20A EFI 30A AM2 10A ETCS 8 2M 30A D. C. C.
6 CAMRY (Cont’ d) (Cont.
Clock <26–3> 2005 CAMRY (EWD586U) L I8 Injector No.
(Cont.
R 2005 CAMRY (EWD586U) Y–G 124 3B (A/T) W–L (M/T) Y–G (*4) W 2 IF4 W–L (M/T) W–L (M/T) 4 ECC C12 Cruise Control Clutch SW 2 1 R–L (M/T) D B J 7(A) J 8(B) Junction Connector 1 IF4 R–L (M/T) F A 127 3B 107 3B B–O 89 3A TACH B–O 109 3A SIL W CANCEL 2 IJ1 W–L (M/T) TC 62 3B 4 2P 4 2L 61 3B 3 2L 18 2G O(*2) W(*3) – SET CCS D 21 B WFSE W + RES ON–OFF 5 31 B ST1– 1 B 31 3B P–B BR L–Y W 5 2D 41 3B P–B BR LG–B W 105 3B B–R 7 2D 52 3B 42 3B 22 3B W 125 3B
Memo 2005 CAMRY (EWD586U)
1 II SB IG1 Relay 2005 CAMRY (EWD586U) 17 2G B–W EFI Relay Left Fender +B2 2 A SR E2 9 THO1 SLT+ SL2+ SL2– SL1+ SL1– S4 SL3– 12 6 13 3 11 M+ 3 C 4 17 D SL3+ GE01 17 C LG SB GR G O O V B–G E3 Electronically Controlled Transmission Solenoid SL3+ GR SL3– BR(*1) B–R(*2) S4 G SL1– Y–R SL1+ Y–B SL2– Y SL2+ 5 L–Y BR DSL 10 L–R W SLT– R–B B SLT+ 8 SPD 17 B 11 D 15 D 14 D 19 D 18 D 10 D 16 D DSL STP 19 B B–W Y THO 2 SLT– 12 D STA 17 E L L
7 CAMRY (Cont’ d) E le ctro n ic ally C o ntr olle d T ra ns m is s io n an d A /T In d ic ato r (1 M Z – F E , 3 M Z – F E ) A B 5 SB 8 7 6 R–L * 3 : w/o Power Adjustable Pedals R–L A4 A/T Indicator Light SW 2 RB RL PL 9 1 6 20 IL2 19 IL2 Skid Control ECU with Actuator <13–8> R–B 5 2R W W L–W 5 2L Y 99 3A 93 3B O 101 3B 123 3B G–W (*3) 119 3A W 111 3B B–R 109 3A R–B 121 3B W 112 3B W 122 3B W–L O L–W W F G 2 IL1 Radio and Player with Display <27–3> R–B W–L 1
1 II SB IG1 Relay 2005 CAMRY (EWD586U) 17 2G B–W EFI Relay Left Fender +B2 2 A SR E2 9 THO1 SLT+ SL2– SL1+ SL1– 12 6 13 SL3– 3 11 4 E M– 5 E M+ 4 16 D SL3+ GE01 8 E 8 D 17 D S4 SPD 8 B LG SB GR G O O V B–G E3 Electronically Controlled Transmission Solenoid SL3+ GR SL3– B–R(*1) BR(*2) S4 G SL1– Y–R SL1+ Y–B SL2– Y SL2+ 5 L–Y BR DSL 10 L–R W SLT– R–B B SLT+ 8 SL2+ 9 D 14 D 15 D 11 D 10 D DSL STP 4 B P Y THO 2 SLT– 13 D STA 12 A L
8 CAMRY (Cont’ d) E le ctro n ic ally C o ntr olle d T ra ns m is s io n an d A /T In dic ato r (2 A Z – F E ) A B 5 SB 8 7 6 R–L * 3 : w/o Power Adjustable Pedals R–L A4 A/T Indicator Light SW 2 RB RL PL 9 1 6 20 IL2 19 IL2 Skid Control ECU with Actuator <13–8> R–B R–B 5 2R W W L–W 5 2L Y 101 3B 99 3A 123 3B O 119 3A G–W (*3) 111 3B W 109 3A R–B 121 3B W 112 3B W 122 3B W–L O L–W W F G 2 IL1 W–L 119 3B 63 3B 110 3A 120 3A 35 3B 109 3B 103 3B 90 3A 100
2005 CAMRY (EWD586U) B–G 120A ALT B–G Light Control SW Instrument Panel Brace LH C11 Combination SW Left Fender R7 Rear Combination Light RH R6 Rear Combination Light LH G G G Lower Back Panel Center W–B (*2) W–B W–B (*1) W–B W–B (*1) W–B BS W–B W–B (*1) BQ W–B BS Lower Back Panel Center Stop R6 Rear Combination Light LH Stop Tail W–B (*1) W–B F9 Front Parking Light LH W–B W–B Front Side of Rear Quarter Wheel House LH Front Side of Rear Quarter Wheel House LH W–B A (*2 *4) W–B
Memo 2005 CAMRY (EWD586U)
R 10A PANEL 10A ECU–B TAIL Relay II SB IG1 Relay Cowl Side Panel LH 3 1 B 20 A 30A D. C.
10 CAMRY (Cont’ d) Illu mina tio n * 1 : Automatic A/C * 2 : Manual A/C * 7 : Separate Type Amplifier * 8 : Built–In Type Amplifier * 9 : w/ Navigation System *10 : w/o Navigation System Audio System <27–4><28–4><29–4> G G G G G (*8) G G C10 Combination SW 10 EAU G (*7) LH G3 Glove Box Light and SW A36 A/T Shift Lever Illumination C5 Clock W–G (*7) W–G (*7) Steering Pad SW W–B W–G W–B W–G W–G W–G (*8) R4 Radio and Player (*10) Radio and Player with Display (*9) R 2(A), R 3(B) Ra
B–G 15A HAZ 2005 CAMRY (EWD586U) Cowl Side Panel LH II 10A GAUGE1 B–G F12 Front Turn Signal Light RH B–G Right Fender G–B W–B (*3) W–B F11 Front Turn Signal Light LH W–B W–B 5A AM1 EB G–Y Left Fender W–B (*3) BQ Turn W–B EC R7 Rear Combination Light RH W–B (*3) G–B W–B (*4) Front Side of Rear Quarter Wheel House LH A A Body ECU <1–15> 1 B (*6) GND 1 A (*5) SW1 34 A (*5) 17 B (*6) 64 3A 34 3A SB Instrument Panel Brace LH 76 3B 86 3B W 32 BR W–B R6 Rear Combination Light
12 CAMRY P ow er S ou rc e B a c k– U p L igh t 1 F og L igh t 4 3 2 W 2 AM1 IG1 4 B–Y 1 15A FOG 105 3A 2 2E 8 2A 1 R FOG Relay 2 5 1 1 HEAD Relay R IG1 Relay 5A AM1 3 5 10A GAUGE2 1 40A MAIN R 2 5 6 IF2 2 3 2 3 2 R B–G B–G B–G 8 2R 6 2B 12 2G 4 2R 3 1F 11 1H R–Y R–L W–B 1 2 5 2R 3 IL1 Multiplex Communication System<1–5> 2 2 1 F2 Fog Light RH F1 Fog Light LH Back–Up 6 R7 Rear Combination Light RH R6 Rear Combination Light LH Back–Up 2 IL1 2 1 6
W 7 2F 6 2M W–R 10A ECU–B R 30A D. C. C 2005 CAMRY (EWD586U) 1 30A AM2 B–G B–G 1 7 1E 2 5A AM1 Cowl Side Panel LH 3 5 II 8 2R 2 1 8 2A W–B Battery FL MAIN 3.
13 CAMRY (Cont’ d) (Cont.
2005 CAMRY (EWD586U) L B W P–B L–O ABS Instrument Panel Brace LH 76 3B 86 3B II J2 Junction Connector BR BR L–O R–Y R–B L R–L LG Cowl Side Panel LH 1 E 2 E 2 D 1 D W–B A IK A 1 GND IG 5 C C Instrument Panel Brace LH J4 Junction Connector 2 CANL 3 CANH W–B IJ W–B 1 C 1 B W–B K J I R–Y 74 3B 84 3B W R–B Slip W H VSC A A W–B F VSC OFF 20 A Brake Buzzer W (2AZ–FE) G 35 A B–R R (2AZ–FE) L 3 B S11 Steering Sensor J13(A), J14(B), J15(C), J16(D), J17
14 CAMRY A B S (T M C M a de ) P ow e r S ou rc e 1 2 4 3 W C 7(A), C 8(B) Combination Meter 1 A I15 Ignition SW 2 AM1 ABS IG1 4 Brake B–Y 66 3A ST1 Power B–G W 10A ECU–B 7 AM2 IG2 6 7 IF3 21 IF4 O GND 24 14 15 BRL TS FR– FR+ 30 31 D/G 16 18 TC 10 PKB FL– FL+ 8 9 STP BR Y W–B W–B G R 9 IF4 4 ID1 L P 1 W 1 ID1 PN L P 120A ALT 50A ABS NO.
2005 CAMRY (EWD586U) Cowl Side Panel LH II G R 30A D. C. C B–G L 50A ABS NO.
(Cont.
B A P (*3) L (*8) 2005 CAMRY (EWD586U) C14 Curtain Shield Airbag Sensor LH C16 Curtain Shield Airbag Squib LH 2 ESL 1 S15 Side Airbag Sensor LH VUPL 2 S19 Side Airbag Squib LH 1 2 BR (*3) 1 G–W (*3) 1 Y–V (*3) ESCL DSP– 17 A DBE– 18 A FSP– 24 C DBE+ 10 A 3 A (*6) 4 B (*7) FSP+ 16 C DSP+ 9 A 1 B 1 A G (*10) 2 PBEW 13 B 2 B 2 A G–B (*10) VUCL SFD– 2 A SFD+ 1 A ESD 21 A VUPD 19 A P–AB 17 B Y–O (*3) A22(A), A23(B), A24(C) Airbag Sensor Assembly P–L (*3) ICD– 3 A
16 CAMRY (Cont’ d) SRS A B 9 W 12 11 10 B–O 66 3A *10 : w/ Power Seat *11 : w/o Power Seat *12 : TMC Made w/ Power Seat *13 : TMMK Made w/ Power Seat 86 3A W–R B–O 8 IN4 3 IN4 W–R (*10) B–O (*10) O7 Occupant Classification Sensor Front LH 6 BE1 5 BE1 SVC1 SIG1 1 2 O5 Occupant Classification Sensor Front RH SGD1 3 SVC2 1 SIG2 2 O8 Occupant Classification Sensor Rear LH SGD2 3 SVC3 SIG3 1 2 2 SGD4 3 W–R (*11) BR B(*10) R(*11) V W Y GR O L W G SB R R (*12) W–R(*13)
2 2E B–G II IG1 Relay Cowl Side Panel LH 3 5 B–G 10A GAUGE1 W B–G 2005 CAMRY (EWD586U) 76 3B W–B 5A AM1 BR J20(A), J21(B) Junction Connector BR BO W–B (*3 * 6, *4) Instrument Panel Brace LH Under the Driver’ s Seat 3 B (*4) 3 A (*3) B 9(A), B11(B) Buckle SW LH 2 A (*3) 6 B (*4) G (*3 *5) IJ K B D A SB W–B (*3 *5) 14 2K 5 2N 39 A J20(A), J21(B) Junction Connector 81 3A 91 3A B A B B B A L–Y A A A B W–B (*3 *5) 14 A G–Y (*3 *5) L–Y 86 3B 1 2M 20 A 21 A Driver Seat B
Memo 2005 CAMRY (EWD586U)
3 5 IG1 Relay Cowl Side Panel LH 2 1 1 2E 2 1 1 2H 1 2C 8 2H 9 2H 3 5 G–Y V B–G 2005 CAMRY (EWD586U) Up B–G B–G R 5 M P7 Power Window Control SW Rear LH P11 Power Window Motor Rear LH Down 4 1 D R–Y 3 U 2 SD V 5 G–Y SU 9 BA1 (*3) 7 BA1 (*4) R–Y 6 BA1 10 BA1 9 IA1 10 13 RLD D12 Power Window Master SW DU 4 4 4 G G 2 BA1 4 B G–Y 8 IA1 12 12 RLU SIG 11 R LMT 2 17 LMT * * * * P9 Power Window Motor Front LH M 5 9 9 (*2) DD P o w er W ind o w R 3 BA1 4
18 CAMRY (Cont’ d) P ow e r W in do w 5 8 7 6 * * * * 1 : w/ Jam Protection 2 : w/o Jam Protection 3 : TMMK Made 4 : TMC Made D12 Power Window Master SW PU PD 13 18 RRU 18 10 15 15 W–B W–B L–W (*1) P8 Power Window Control SW Rear RH U D 3 1 4 M P12 Power Window Motor Rear RH 5 V V L–W (*1) W–B C V B L–W (*1) V (*2) A 10 IA1 R P10 Power Window Motor Front RH 2 IA1 Down M 5 V (*1) 2 SD G R G V 4 R–B 1 R–B 3 Down Up D 5 SU Up P6 Power Window Control SW Front
II 8 2R 2 1 ACC Relay Cowl Side Panel LH 6 2H B–G 2005 CAMRY (EWD586U) B–G 5A AM1 W M 2(A), (B), (C) Remote Control Mirror LH 2 C (*3) 3 B (*2) 2 A (*1) M+ M 10 IB2 3 C MH M 3(A), (B), (C) Remote Control Mirror RH Y–G 2 C (*3) 3 B (*2) 2 A (*1) M+ M 1 C (*3) MV 4 B M 6 A (*1) 2 B (*2) 3 A 3 IM1 14 IM1 10 IA1 7 E W–B BO 4 * 1 : TMMK Made * 2 : TMC Made w/ Mirror Heater * 3 : TMC Made w/o Mirror Heater W–B M 1 C MV 3 C B–R MH L–B 2 B 14 IB1 Right/ Down Y–G 6 M+ L
20 CAMRY P o w e r S o urc e R e ar W ind ow D e fog ge r 1 M irro r H ea ter 4 3 2 * * * * * * 1 : Automatic A/C 2 : Manual A/C 3 : TMMK Made 4 : TMC Made 5 : 1MZ–FE, 3MZ–FE 6 : 2AZ–FE W ACC 2 AM1 IG1 4 ST1 B–G 2 2A B–Y B–G W I15 Ignition SW 2 2E 8 2A 1 2E 1 2 DEF Relay 3 Noise Filter 2 IG1 Relay 1 2 2 2 B–G B–G 8 2R 8 2M 2 2J 4 2C 18 2K 2 2S B–Y (*5) 2 16 2G B–Y B–Y 1 G A RDEF 1 1 M2 Mirror Heater LH M3 Mirror Heater RH 4 (*3) 5 (*4) 4 5 W–B W–B 34 3A C13
5A AM1 2 2E B–G II 8 2R 2 1 8 2A IG1 Relay Cowl Side Panel LH 3 5 7 2B 10A GAUGE2 R–L R–L B–G 2005 CAMRY (EWD586U) B–G R–L W–B Instrument Panel Reinforcement RH E W–B (* 2) 10 2B 2 1 B 2 4 1 E1 7 5 3 IE1 30A PWR NO.
22 CAMRY P ow er S ou rc e W ipe r a nd W a s he r 1 +B ACC 2 AM1 IG1 4 B–Y +2 +S INT2 INT1 B1 OFF Wiper SW ST1 2 2E 8 2A 2 2A L L–W B–Y B–G W I15 Ignition SW +1 MIST Washer SW W 4 3 2 6 2F 11 2A INT EW WF Off On LO 5 2F HI Wiper Relay IG1 Relay 5A AM1 3 2 +B 25A WIPER 1 15A WASHER 5 17 +1 7 +2 +S 8 EW C9 Combination SW 16 2 WF 11 L L–W P W–B L–Y L–O L–B L W–B B–G 2 M 1 W2 Washer Motor 1 2 10 IF1 4 IF1 3 IF1 P 2005 CAMRY (EWD586U) 8 2R
W 2005 CAMRY (EWD586U) 1 II Cowl Side Panel LH 15A POWER POINT B–G A E C4 Cigarette Lighter Instrument Panel Brace LH 64 3A 125 3A 1 Shift Lock Solenoid J4 Junction Connector S6 Shift Lock Control ECU SLS+ STP 3 SLS– 11 IC2 S17 Seat Heater LH W–B W–B P V V B–G W–B Under the Front Passenger’ s Seat RH 7 IN4 4 C B B A 2 1 A A A B W–B BP W–B (*1) W–B W–B W–B BO J20(A), J21(B) Junction Connector A A E W–B (*1) A B 2 1 C B B A 6 S5 Seat Heater SW (Front Passen
24 CAMRY 1 W–B W–B W Y J20(A), J21(B) Junction Connector L–O L–O L–O Rear Front Down Up Down Up Rear Front Rear Front Down Up Down Up Rear Front B–G W–B W–B W–B BR P V W B G Y L R–B R–W R(*1) L–Y(*2) L–Y(*1) R(*2) L–W L–R L–B L W–B M J20(A), J21(B) Junction Connector P19 Power Seat Motor (Driver’ s Seat Reclining Control) P18 Power Seat Motor (Driver’ s Seat Lifter Control) M W–B P17 Power Seat Motor (Driver’ s Seat Front Vertical Control) M P20 Power Seat Mot
25 CAMRY L–R 2005 CAMRY (EWD586U) 1 B–G 30A ADJ PDL 1 B–G B–G Battery II IG1 Relay Cowl Side Panel LH 2 1 G–W (*2) G–W (*1) Skid Control ECU with Actuator<13–8> G–W G–W 10A GAUGE2 W–B W–B W–B W–B 5A AM1 W EC W–B 1 ADJ PDL Relay Left Fender 3 5 1 Y–B FL MAIN 3.
26 CAMRY W R L–R B–Y W ACC Relay IG1 Relay 5A AM1 3 30A D. C. C 3 7. 5A DOME 5A ECU–ACC 10A GAUGE1 R 17 5 (*2) 4 (*1) PBEW PAON SW1 Steering Pad SW W–B R–L GR R B–W G–R G–Y (*1) V–W L (*1) B–R (*1) LG–R (*1) R J 7(A), J 8(B) Junction Connector C B W–B (1MZ–FE) Battery Audio System <27–4><28–4><29–4> A A C10 Combination SW R SRS System <16–3> ” IGN” Fuse <5–10><6–10> Injector No.
L–Y 20A RAD NO. 1 R Cowl Side Panel LH II 10 A B W–B 2 A 1 2 9 A FL– 30A D. C.
28 CAMRY A u dio S ys te m (S e pa ra te T y pe A m plifie r w /o N a v ig ation S y s tem ) P ow er S ou rc e 1 * 1 : TMC Made * 2 : TMMK Made L–Y L–Y ACC 3 W 1 2A R 4(A), R13(B) Radio and Player L–R 2 2E 7 2A 5 2A AMP+ 3 A MUTE 7 A FR+ 8 A FL+ 9 A RR+ 18 A RL+ 19 A SGND 16 A BEEP 17 A SLD 10 A SW1 7 B O(*1) B(*2) 11 AU2 1 B +B RL– RR+ 3 A 11 A 12 B 6 B 5 B AMP+ MUTE FRIN FLIN S12(A), S13(B) Stereo Component Amplifier RR– 10 A FL+ FL– 2 A 14 B 13 B RRIN RLIN 11 B FR+
29 CAMRY L–Y 20A RAD NO. 1 R ACC Relay Cowl Side Panel LH 3 5 1 2 30A D. C.
Memo 2005 CAMRY (EWD586U)
W R 10A ECU–B II IG1 Relay 1 2L 10A GAUGE1 W 30A D. C.
* 1 : Automatic A/C * 2 : TMC Made * 3 : TMMK Made Illumination System<10–3> B–W 91 3B W Brake CRUISE SRS VSC VSC OFF Malfunction Slip Washer Level W P–L W SRS System <16–2> R–L W–B BR W–B W–B B2 Brake Fluid Level Warning SW Cruise Control System<5–14><6–15> Engine Control System<5–14><6–14> VSC System <13–9> W1 Washer Level Sensor P–L O1 Oil Pressure SW Y–B SB BR Illumination System <10–3> Clock<26–3> Engine Control Module<5–19><6–19> Engine Control Module<5–18><6–17> Seat Be
4 A Turn LH 2 A P 5 A R 22 A N 23 A D 24 A 3 2 L 22 B 9 30 CAMRY (Cont’ d) Electronically Controlled Transmission and A/T Indicator System<7–6><7–7><7–8><8–6><8–7><8–8> 30 A 3 A Turn RH 6 A Turn Signal and Hazard Warning Light System <11–3> 25 A 10 C o m bina tio n M ete r 11 12 M OVERALL ELECTRICAL WIRING DIAGRAM O/D OFF 2005 CAMRY (EWD586U) Electronically Controlled Transmission and A/T Indicator System <7–7><8–7>
31 CAMRY B–R L W–B W–L (*2) G–W (*1) G–W G–W (*1) W–L (*2) R–L (*1) L Engine Control Module <5–14> P2 Pressure SW Engine Control Module<6–15> W3 Water Temp. SW No. 1 R1 Radiator Fan Motor A2 A/C Condenser Fan Motor W–L (*2) W–B W–B (*1) R W–B W–B W–B (*1) MG CLT Relay <32–3><33–3><34–3><35–3> Engine Control Module (*1)<5–15> A/C Control Assembly (*2 Automatic A/C)<33–8> A/C Amplifier (*2 Manual A/C)<35–8> W–B R 3 EA2 W4 Water Temp. SW No.
W 7 2F 6 2M L–B R 10A ECU–B 30A D. C.
32 CAMRY (Cont’ d) A uto m atic A ir C o nd ition in g (1 M Z – F E ) 5 8 7 6 E 7(B), E 8(C) Engine Control Module THE ACLD 32 B 33 B A/CS HP LCKI 1 B 31 B 23 C W–L BR P–L B Y–B 1 A3 A/C Lock Sensor 129 3B 118 3B 2 BR W 16 IL2 SG 4 1 5 36 AC1 37 TW 38 A/CI 39 A/CS 33 LP BR RDEF 4 W–B 30 L–B SW1 L–B 34 2 IF2 P–L SPD P–L 18 3 IJ1 B TAM B 17 Y–G AMH Y–G 13 8 IJ1 Y–B AMC Y–B 14 Rear Window Defogger System<20–3> TP Turn Signal and Hazard Warning L
W 7 2F 6 2M L–B R 10A ECU–B 30A D. C. C B–G 2005 CAMRY (EWD586U) 1 50A HTR B–G II Left Fender L–O W–B B–G L–W L–O W–B W–B B–G Instrument Panel Reinforcement RH L–B W–B W–B W–B 5A AM1 IN L–B EC W–R SG–TE 20 A A39(A), A40(B) A/C Control Assembly B 10 B W–R IG LG–B 9 B 1 2 A16 A/C Thermistor HR 36 3A TE 5 A L–W 15 B 39 3A 66 3A SG–TR 19 A 2 1 LG–B BLW 3 3 1L 69 3A TR 4 A B 12 B 1 1 9 1J 3 5 A14 A/C Room Temp.
33 CAMRY (Cont’ d) A uto m atic A ir C o nd ition in g (2 A Z – F E ) 5 S5 TP MC MH 3 4 5 TW 18 B ACT 6 B IGN 19 B LP 16 B MGCR 4 B LOCK 5 B SG–LOCK 4 W–B 8 B 2 IF2 L–B AC1 L–B 13 B 7 IL1 BR RDFG B 14 B 9 IL1 W–L SW1 W–L 17 B 4 IF2 B SPD 1 2 B 2 B B–O TAMG B–O 11 B Y–R AMH Y–R 18 A 9 IJ1 Y–G AMC Y–G 17 A Y–B TP Y–B 8 A Rear Window Defogger System<20–3> 11 A SG–TP S5–TP Turn Signal and Hazard Warning Light System<11–4> 2 A 1 IJ1 V–W AIF 10 IJ1
34 CAMRY W R 10A ECU–B 30A D. C. C B–G 2005 CAMRY (EWD586U) 1 50A HTR 1 B–G 5A AM1 Cowl Side Panel LH II Left Fender L 2 II2 L–B B–G B–G L–O L L–W W–B W–B M1 5 B 1 9 IF3 2 1 1 A/CB 4 A H10(A), H11(B) Heater Control SW LO 3 B L–W M2 6 B 3 IF3 L–W L–B HI 2 II3 4 3 A3 A/C Magnetic Clutch L–B 7 B L–O 1 II3 2 L B–W(*1) G (* 2) 36 3A 39 3A 69 3A 2 A IG+ 1 A +B W–R E L–B 4 II3 3 3 1L Diode (A/C No.
34 CAMRY (Cont’ d) M an ua l A ir C on d itio n in g (1 M Z – F E , 3M Z – F E ) 5 A 8 7 6 SB E 7(B), E 8(C), E10(E) Engine Control Module L–W E2 28 E LCKI 23 C HP 1 B L–B THE 32 B W–L ACLD 33 B BR A/CS 31 B B L–B P–L B BR–Y 2 IF2 7 IL1 4 W–B E DEF FDEF HEAT B/L FACE MC MH SS SG 1 2 3 5 6 4 5 1 2 14 3A SB W–B Turn Signal and Hazard Warning Light System<11–4> Rear Window Defogger System<20–3> Multiplex Communication System<1–14> B P–L 3 IJ1 64 3A 8 IJ1 L
35 CAMRY W R 10A ECU–B 30A D. C. C B–G 2005 CAMRY (EWD586U) 1 50A HTR 1 B–G 5A AM1 Cowl Side Panel LH II Left Fender L 2 II2 L–B B–G B–G L–O L L–W W–B W–B M1 5 B 1 9 IF3 2 1 1 A/CB 4 A H10(A), H11(B) Heater Control SW LO 3 B L–W M2 6 B 3 IF3 L–W L–B HI 2 II3 4 3 A3 A/C Magnetic Clutch L–B 7 B L–O 1 II3 2 L B–W(*1) G (* 2) 36 3A 39 3A 69 3A 2 A IG+ 1 A +B W–R E L–B 4 II3 3 3 1L L–W Diode (A/C No.
35 CAMRY (Cont’ d) M an ua l A ir C on d itio n in g (2 A Z – F E ) 5 A 8 7 6 SB * 1 : TMC Made * 2 : TMMK Made A38 A/C Amplifier B L–W PRSW C L–B A/C 2 8 LED 10 TE SG 9 13 LOCK ACT AC1 IGN 14 7 1 4 MGC 12 GND 5 W–B B B–O Y–B R W–L Y–G W–L(*1) L–W(*2) Y–B W L–W 9 IL1 4 IF2 W–L B Diode (A/C No.