Datasheet

Standards
- IT / Multimedia Equipment
EN 60950-1
EN 62368-1
IEC 60950-1
IEC 62368-1
UL 60950-1
UL 62368-1
- Certification Documents
www.tracopower.com/overview/tmg30
Protection Class
Class I & II (Prepared): Reinforced Insulation
Pollution Degree
PD 2
Over Voltage Category
OVC II
Safety Specifications
EMI Emissions
- Conducted Emissions
EN 55032 class B (internal filter)
- Radiated Emissions
EN 55032 class B (internal filter)
EMS Immunity
EN 55024 (IT Equipment)
EN 55035 (Multimedia)
- Electrostatic Discharge
Air:
EN 61000-4-2, ±8 kV, perf. criteria A
Contact:
EN 61000-4-2, ±4 kV, perf. criteria A
- RF Electromagnetic Field
EN 61000-4-3, 10 V/m, perf. criteria A
- EFT (Burst) / Surge
EN 61000-4-4, ±2 kV, perf. criteria A
L to L:
EN 61000-4-5, ±1 kV, perf. criteria A
Ext. input component:
Use an external Varistor at the converter input
(in parallel). Recommendation: 14S471K
- Conducted RF Disturbances
EN 61000-4-6, 10 Vrms, perf. criteria A
- PF Magnetic Field
Continuous:
EN 61000-4-8, 30 A/m, perf. criteria A
- Voltage Dips & Interruptions
230 VAC / 50 Hz:
30%, 25 periods, perf. criteria A
>95%, 0.5 periods, perf. criteria A
115 VAC / 60 Hz:
30%, 25 periods, perf. criteria A
>95%, 0.5 periods, perf. criteria A
EMC Specifications
Relative Humidity
95% max. (non condensing)
Temperature Ranges
- Operating Temperature
–40°C to +70°C
- Storage Temperature
–40°C to +85°C
Power Derating
- High Temperature
3 %/K above 50°C (nominal input models)
3 %/K above 45°C (<115 VAC models)
- Low Input Voltage
2 %/V below 100 VAC
See application note:
www.tracopower.com/overview/tmg30
Cooling System
Natural convection (20 LFM)
Altitude During Operation
2'000 m max.
Switching Frequency
40 - 73 kHz (PWM)
Insulation System
Reinforced Insulation
Working Voltage (rated)
341 VAC
Isolation Test Voltage
- Input to Output, 60 s
3'000 VAC
Creepage
- Input to Output
5.6 mm min.
Clearance
- Input to Output
4 mm min.
Leakage Current
(at 240 VAC)
- Earth Leakage Current
250 µA max.
Reliability
- Calculated MTBF
400'000 h (MIL-HDBK-217F, ground benign)
Washing Process
Not allowed
Housing Material
Plastic resin (UL 94 V-0 rated)
Potting Material
Silicone (UL 94 V-0 rated) (Hermetical sealed
structure, dust-proof only non water-proof)
Pin Material
Brass
Pin Surface Plating
Tin (120 µm min.), matte
General Specifications
TMG 30 Series, 30 Watt
All specifications valid at nominal voltage, resistive full load and +25°C after warm-up time, unless otherwise stated.
www.tracopower.com September 27, 2023
Page 3 / 4