User Guide

ManualsBrandsTraulsen ManualsOtherRET232EUT

This Traulsen unit is built to our highest quality standards. We build our refrigerators, freezers and heated

cabinets this way as a matter of pride. This philosophy has made Traulsen the leader in commercial

refrigeration since 1938. We thank you for your choice and condence in Traulsen equipment and we know

you will receive many years of utility from this equipment.

All Traulsen units are placed on a permanent record le with the service department. In the event of any

future questions you may have, please refer to the model and serial number found on the name tag afxed

to the unit. Should you need service, however, call us on our toll free number, 800-825-8220 between 7:30

am and 4:30 pm CST, Monday thru Friday. It is our pleasure to help and assist you in every possible way.

OWNER’S MANUAL

Instructions for the installation, operation

and maintenance of all Traulsen:

Reach-In Even Thaw Refrigerator Models*

RET132EUT

RET232EUT

RET232NUT

*For roll-in even-thaw models please refer to form number TR35867.

INSTALLER

COMPLETE THE FOLLOWING INFORMATION PRIOR TO UNIT INSTALLATION

INITIAL START DATE: SERIAL NO.

MODEL TYPE:

COMPANY/INDIVIDUAL NAME:

INSTALLER:

FORM NUMBER TR35849 REV. 08/13 P/N 375-60214-00

Quality Refrigeration

Summary of content (16 pages)

PAGE 1
Quality Refrigeration OWNER’S MANUAL Instructions for the installation, operation and maintenance of all Traulsen: Reach-In Even Thaw Refrigerator Models* RET132EUT RET232EUT RET232NUT *For roll-in even-thaw models please refer to form number TR35867. This Traulsen unit is built to our highest quality standards. We build our refrigerators, freezers and heated cabinets this way as a matter of pride. This philosophy has made Traulsen the leader in commercial refrigeration since 1938.
PAGE 2
TABLE OF CONTENTS I. THE SERIAL TAG II. RECEIPT INSPECTION III. INSTALLATION a-Location b-Packaging c-Installing Legs or Casters d-Tray Slides e-Cord & Plug f-Power Supply g-Wiring Diagram h-Clearance IV. OPERATION a-Even-Thaw Overview b-Expected Performance c-Even-Thaw Operation d-Batch Loading e-Process Loading f-Interior Arrangements g-Adjusting The Temperature Scale h-Operator Controls, Blower Switch i-Call Service Light V.
PAGE 3
II. RECEIPT INSPECTION III. INSTALLATION (continued) All Traulsen products are factory tested for performance and are free from defects when shipped. The utmost care has been taken in crating this product to protect against damage in transit. All interior fittings have been carefully secured and the legs or casters are boxed and strapped inside to prevent damage. Door keys will be attached to the handle with a nylon strip. The handle is protected by an easily removable nylon netting. III.
PAGE 4
III. INSTALLATION (continued) IV. OPERATION III. d - TRAY SLIDES: Reach-In models are supplied with fourteen (14) pairs of #1 type tray slides on 4” centers. These are shipped installed from the factory, and are easily removable for cleaning without tools. IV. a - EVEN-THAW OVERVIEW: The “Even-Thaw” refrigerator was specially designed to thaw frozen food product under safe, temperature controlled conditions. It is not intended as a storage refrigerator.
PAGE 5
IV. OPERATION (continued) V. CARE & MAINTENANCE IV. d - BATCH LOADING: The Even-Thaw model can accommmodate any size partial load, or up to twenty eight (28) 18” x 26” pans of product. Use of aluminum pans is highly recommended. Product should be placed on pans in one layer only to allow for proper air flow. V. a - CLEANING THE CONDENSER: The most important thing you can do to insure a long, reliable service life for your Traulsen is to regularly clean the condenser coil.
PAGE 6
V. CARE & MAINTENANCE (continued) VI. OTHER VI. a - SERVICE INFORMATION: Before calling for service, please check the following: V. c - REPLACING THE GASKETS: To remove the gasket to be replaced, grasp it firmly by one corner and pull it out. Before attempting to install a new gasket, both the unit and the gasket itself must be at room temperature. Insert the four corners first by using a rubber mallet (or hammer with a block of wood).
PAGE 7
VII. GENERAL USE, OPERATION & SERVICE SUMMARY VIII. EXPECTED THAW PERFORMANCE/OPERATIONAL TROUBLESHOOTING VII. a - INTRODUCTION/OVERVIEW: The Traulsen Even Thaw is designed to be used as a thawing cabinet. While it may be utilized in a refrigeration mode, that is not its intended use. Its function is to hold the cabinet temperature in the range from 38 to 40 degrees to thaw product within the food-safe temperature zone. VIII.
PAGE 8
VIII. EXPECTED THAW PERFORMANCE/OPERATIONAL TROUBLESHOOTING (continued) VIII. e - INCOMPLETE THAWING: In operation, incomplete thawing (i.e. bags of product in which not every piece was completely thawed) has been found to usually be the result of those pkgs. respective pan level having had restricted airflow due to overloading (from stacked pkgs. or irregular shaped packages that blocks air from getting to the pkgs. closest to the cabinet interior side wall or rear).
PAGE 9
IX. TROUBLE SHOOTING GUIDE FIND YOUR PROBLEM HERE 1. Condensing unit fails to start. REMEDY a. Check if cord & plug has been disconnected. 2. Condensing unit operates for a. prolonged periods or continuously. b. c. d. Are doors closing properly? Dirty condenser or filter. Clean properly. Evaporator coil iced. Needs to defrost. Shortage of refrigerant, call service. 3. Food compartment is too warm. a. Check door(s) and gasket(s) for proper seal 4.
PAGE 10
X.
PAGE 11
XI.
PAGE 12
XI.
PAGE 13
XI.
PAGE 14
XII. WARRANTY INFORMATION STANDARD DOMESTIC WARRANTY TRAULSEN warrants new equipment to the original purchaser, when installed within the United States against defective material and workmanship for three (3) years from the date of original installation. Under this warranty, TRAULSEN will repair or replace, at its option, including service and labor, all parts found to be defective and subject to this warranty.
PAGE 15
Notes:
PAGE 16
HOURS OF OPERATION: Monday thru Friday 7:30 am - 4:30 pm CST Quality Refrigeration Traulsen 4401 Blue Mound Road Fort Worth, TX 76106 Phone: (800) 825-8220 Fax-Svce: (817) 740-6757 Website: www.traulsen.