- Hayward Pool Products, Inc. OWNER'S MANUAL pump SP3207X10,SP3007EEAZ,SP3007X10AZ,SP3207EE,SP3210X15,SP3010EEAZ,SP3010X15AZ,SP3210EE,SP3215X20,SP3015EEAZ,SP3015X20AZ,SP3207X10,SP3007EEAZ,SP3007X10AZ,SP3207EE,SP3210X15,SP3010EEAZ,SP3010X15AZ,SP3210EE,SP3215X20,SP3015EEAZ,SP3015X20AZ,

ManualsBrandsTriStar ManualsHeat PumpSP3207X10

WWW.HAYWARDPOOL.COM USE ONLY HAYWARD GENUINE REPLACEMENT PARTS

P/N: IS3200

Rev. D

__________________________________________________________________________________________

OWNER’S MANUAL

INSTALLATION, OPERATION, & PARTS

*50HZ Models are not UL Listed.

TriStar

™

Pump Series

The Hayward TriStar Pump is specifically engineered for the demanding requirements of today’s in-ground swimming pool/spa that is

equipped with large capacity filters, heaters, and pool cleaning equipment. The TriStar is a self-priming pump that includes an

improved seal and impeller design that will provide many years of efficient, dependable, corrosion-free service. The advanced design

provides superior performance while reducing maintenance requirements. NOTE - To prevent potential injury and to avoid

unnecessary service calls, read this manual carefully and completely.

SAVE THIS INSTRUCTION MANUAL

HAYWARD POOL PRODUCTS, INC.

620 DIVISION STREET ELIZABETH, NJ 07207 (908) 351-5400

WWW.HAYWARDPOOL.COM

TriStar Pump Replacement Guide

TriStar

TriStar Super II Super II

Model No. Model No. Model No. Model No.

Full Rated Max Rated Full Rated Max Rated

--- SP3207X10 SP3007EEAZ SP3007X10AZ

SP3207EE SP3210X15 SP3010EEAZ SP3010X15AZ

SP3210EE SP3215X20 SP3015EEAZ SP3015X20AZ

SP3215EE SP3220X25 SP3020EEAZ SP3020X25AZ

SP3220EE SP3225X30 SP3025EEAZ SP3025X30AZ

SP3230EE --- --- ---

IMPORTANT – READ CAREFULLY

NOTE - The TriStar is a high performance, high

efficiency pump. When replacing most existing

pumps, you can use a TriStar pump with a lower

horsepower rating than the existing pump.

Required: 2” plumbing minimum

Recommended: 2 ½” plumbing or larger

Summary of content (15 pages)

PAGE 1
P/N: IS3200 Rev. D __________________________________________________________________________________________ OWNER’S MANUAL INSTALLATION, OPERATION, & PARTS *50HZ Models are not UL Listed. ™ TriStar Pump Series The Hayward TriStar Pump is specifically engineered for the demanding requirements of today’s in-ground swimming pool/spa that is equipped with large capacity filters, heaters, and pool cleaning equipment.
PAGE 2
TriStar™ Pump Series ____________________ _____________________________Page 2 of 15 IMPORTANT SAFETY INSTRUCTIONS Before installing or servicing this electrical equipment, turn power supply OFF. Basic safety precautions should always be followed, including the following: Failure to follow instructions may result in injury. This is the safety-alert symbol. When you see this symbol on your pump or in this manual, look for one of the following signal words and be alert to the potential for personal injury.
PAGE 3
TriStar™ Pump Series __________ _____ ________________________________Page 3 of 15 WARNING – It is required that licensed electricians do all electrical wiring. Risk of Electric Shock. Hazardous voltage can shock, burn, and cause death or serious property damage. To reduce the risk of electric shock, do NOT use an extension cord to connect unit to electric supply. Provide a properly located electrical receptacle.
PAGE 4
TriStar™ Pump Series __________ _____ ______________________________ Page 4 of 15 WARNING – Hazardous Pressure. Pool and spa water circulation systems operate under hazardous pressure during start-up, normal operation, and after pump shut-off. Stand clear of circulation system equipment during pump start-up.
PAGE 5
TriStar™ Pump Series__________ _____ ______________________________ Page 5 of 15 Product Specifications HP ½ ¾ 1 1* 1½ 1½* 2 2* 2½ 2½* 3 3 ** * ** FR “A” 13 5/8” 13 7/8” 14 3/8” 14 3/8” 14 7/8” 14 7/8” 14 7/8” 14 7/8” 17 1/8” 14 1/2” MR “A” 13 3/8” 13 7/8” 13 7/8” 14 3/8” 15 1/8” 14 7/8” 14 7/8” 14 7/8” 15 5/8” - Two-Speed Pump Three-Phase Pump Installation Instructions WARNING – This product should be installed and serviced only by a qualified professional.
PAGE 6
TriStar™ Pump Series __________ _____ _______________________________ Page 6 of 15 Pump Mounting (cont’d.) WARNING – Hazardous Pressure. Pumps, filters, and other equipment/ components of a swimming pool filtration system operate under pressure. Incorrectly installed and/or improperly tested filtration equipment and/or components may fail resulting in severe personal injury or death. Plumbing Use Teflon tape to seal threaded connections on molded plastic components.
PAGE 7
TriStar™ Pump Series __________ _____ _______________________________ Page 7 of 15 Electrical (cont’d.) Voltage Voltage at motor MUST NOT be more than 10% above or below motor name plate rated voltage, or motor may overheat, causing overload tripping and reduced component life. If voltage is less than 90% or more than 110% of rated voltage when motor is running at full load, consult power company.
PAGE 8
TriStar™ Pump Series ___________________ ______________________________Page 8 of 15 WARNING – All suction and discharge valves MUST be OPEN, as well as filter air relief valve (if available) on filter, when starting the circulating pump system. Failure to do so could result in severe personal injury. Starting/Priming the Pump: Fill strainer housing with water to suction pipe level. If water leakage occurs from anywhere on the pump or filter, DO NOT start the pump.
PAGE 9
TriStar™ Pump Series ___________________ ______________________________Page 9 of 15 Storage/Winterization WARNING – Separation Hazard. Do not purge the system with compressed air. Purging the system with compressed air can cause components to explode, with risk of severe injury or death to anyone nearby. Use only a low pressure (below 5 PSI), high volume blower when air purging the pump, filter, or piping. ATTENTION – Allowing the pump to freeze will void the warranty.
PAGE 10
TriStar™ Pump Series ___________________ ______________________________ Page 10 of 15 Removing the Impeller (See Parts Diagram on page 11 of this manual for pump component locations.) 3. Remove the motor canopy by removing the two (2) screws and pulling the canopy away from the motor. 4. To prevent motor shaft from turning, carefully place a 7/16" open-end wrench over the two (2) flats on the end of the shaft. 5.
PAGE 11
TriStar™ Pump Series ___________________ _____________________________Page 11 of 15 Replacement Parts Parts Diagram Detail of motor canopy with screws. Parts Listing Ref. No. Part No. Description Ctn. Qty. 1 SPX3200UNKIT Union Connector Kit (Includes Union Nut, Union Connector, Union Gasket - 2 ea.
PAGE 12
TriStar™ Pump Series ___________________ _________________________ Page 12 of 15 Parts Listing (cont’d.) Ref. No. Part No. 12 SPX3205C Description Ctn. Qty.
PAGE 13
TriStar™ Pump Series ____________________Page 13 of 15 Troubleshooting Motor Will NOT Start – Check For: Make sure the terminal board connections agree with the wiring diagram on motor data plate label. Be sure motor is wired for available field supply voltage (see pump operating label). 1. Improper or loose wiring connections; open switches or relays; tripped circuit breakers, GFCI’s, or blown fuses. Solution: Check all connections, circuit breakers, and fuses.
PAGE 14
TriStar™ Pump Series ___________________ ____________________________ Page 14 of 15 Low Flow – Generally, Check For: (cont’d.) 2. Undersized pool piping. Solution: Correct piping size. 3. Plugged or restricted discharge line of filter, valve partially closed (high gauge reading). Solution: Sand filters – backwash as per manufacturer’s instructions; D.E. filters – backwash as per manufacturer’s instructions; Cartridge filters – clean or replace cartridge. 4.
PAGE 15
TriStar™ Pump Series Page 15 of 15 HAYWARD® LIMITED WARRANTY This pump was inspected before shipment from our plant. To original purchasers of this pump, Hayward Pool Products, Inc., 620 Division Street, Elizabeth, New Jersey, warrants its products free from defects in materials and workmanship for a period of ONE (1) year from the date of purchase.