Manualshelf

Trojan 24-GEL Specifications

ManualsBrandsTrojan Battery ManualsWind and Solar EnergyTrojan 24-GEL 12 Volt 77 Amp-hour Deep Cycle Gel Battery
12
24-GEL DATA SHEET
MODEL: 24-GEL
VOLTAGE: 12
DIMENSIONS: Inches (mm)
BATTERY: VRLA GEL
COLOR: Maroon (case) Grey (cover)
MATERIAL: Polypropylene
WATERING SYSTEM: N/A
PRODUCT SPECIFICATIONS
A. The number of minutes a battery can deliver when discharged at a constant rate at 80°F (27°C) and maintain a voltage above 1.75 V/cell. Capacities are based on peak performance.
B. The amount of amp-hours (AH) a battery can deliver when discharged at a constant rate at 80°F (27°C) and 86°F (30°C) for the 5-Hour rate and maintain a voltage above 1.75 V/cell. Capacities are based on peak
performance.
C. Dimensions are based on nominal size. Dimensions may vary depending on type of handle or terminal.
D. Dimensions taken from bottom of the battery to the highest point on the battery. Heights may vary depending on type of terminal.
E. Terminal images are representative only.
Trojan’s battery testing procedures adhere to both BCI and IEC test standards.
BCI
GROUP
SIZE
TYPE
CAPACITY
A
Minutes
CAPACITY
B
Amp-Hours (AH)
ENERGY
(kWh)
TERMINAL
Type
E
DIMENSIONS
C
Inches (mm)
WEIGHT lbs.
(kg)
@25 Amps 5-Hr Rate 10-Hr Rate 20-Hr Rate 100-Hr Rate 100-Hr Rate Length Width
Height
D
12 VOLT DEEP CYCLE GEL BATTERY
24 24-GEL 147 66 72 77 85 1.02 6 10.92 (277) 6.61 (168) 9.26 (235) 52 (24)
CHARGING INSTRUCTIONS
CHARGER VOLTAGE SETTINGS (AT 77°F/25°C)
System Voltage 12V 24V 36V 48V
Absorption Charge 14.1 – 14.4 28.2 – 28.8 42.3 – 43.2 56.4 – 57.6
Float Charge 13.5 27 40.5 54
Do not install or charge batteries in a sealed or non-ventilated compartment. Constant
under or overcharging will damage the battery and shorten its life as with any battery.
CHARGING TEMPERATURE COMPENSATION
.028 VPC for every 10°F (5.55°C) above or below 77°F (25°C) (add .028 VPC for every
10°F (5.55°C) below 77°F and subtract .028 VPC for every 10°C above 77°F).
OPERATIONAL DATA
Operating Temperature Self Discharge
-4°F to 113°F (-20°C to +45°C). At temperatures
below 32°F (0°C) maintain a state of charge
greater than 60%.
Less than 3% per month depending
on storage temperature conditions.
TERMINAL CONFIGURATIONS
6 DT Automotive Post & Stud Terminal
Terminal Height Inches (mm)
.79 (20)
Torque Values in-lb (Nm)
Stud: 95 –105 (11 – 12)
AP: 50 – 70 (6 – 8)
ST: 120 – 180 (14 – 20)
Bolt Size
5/16"
Batteries may be utilized at higher temperatures with the understanding that battery life will
be reduced by 50% for every 10° C (18° F) increase in operating temperatures over 68° F (20° C).
TRJN_24-GEL_DS_0315

Summary of content (2 pages)