Installation Instructions

Page%1%% Model:%BPT18-44A-CSBG150/200,%Menards%SKU:%611-3055%
[e-mail],%or%c a ll%(8 88 )9 30 -8528.%Please%provide%the %ba th %fa n%model%numb er%fo u n d%
on%the%front%of%this%manual%when%contacting%Customer%Support.%
GENERAL&SAFETY&INFORMATION&AND&WARNINGS&
For'your'safety'and'to'ensure'proper'performance'of'the'unit,'it'is'very'important'to'read'
these'instructions'caref ully'be for e'ins tallation.'F ailure 'to'co m p ly'w ith'the 'instr uction s'
contained'herein'could'result'in'personal'injury'or'property'damage.'We'recommend'that'
you'keep'this'booklet'for'future'reference.'All'units'should'be'installed'by'a'licensed'
electrician.'
1. Electrical%service%supply%must%be%120V%60Hz.%
2. Wires%from%the%house%power%supply%to%the%unit%should%not%be%smaller%than%size%14%AWG.%
3. Follow%all%local%safety%and%electrical%codes,%as%well%as%requirements%for%NEC%(National%Electrical%Code)%and%
OSHA%(Occupational%Safety%and%Health%Act).%
4. This%unit%must%be%properly%grounded.%
5. This%unit%is%equipped%with%a%built-in%thermal%cut-off%for%safety%and%to%prolong%the%life%of%the%motor.%
6. Always%disconnect%the%power%supply%prior%to%servicing%the%fan,%motor%or%junction%box.%
7. Do%not%bend%or%kink%the%power%wires.%
8. Do%not%install%where%the%air%temperature%will%exceed%40
◦
%C%(104
◦
%F).%
9. This%ventilating%fan%is%approved%for%use%over%a%bathtub%or%shower%when%installed%in%a%GFCI-protected%
circuit.%
10. Do%not%use%to%exhaust%hazardous%or%explosive%vapors.%
11. Do%not%install%in%a%cooking%area.%
12. Use%this%unit%in%the%manner%intended%by%the%manufacturer.%If%you%have%any%questions,%please%call%Cus tomer%
Support%at%(888)%930-8528.%
13. Installation%work%must%be%carried%out%by%qualified%person(s)%in%accordan ce%with%al l%l ocal% and%s afety%codes,%
including%the%rules%for%fire-rated%construction.%
14. Exercise%care%not%to%damage%existing%wiring%when%cutting%or%drilling%into%walls%or%ceilin gs.%
15. Fans%should%always%be%vented%to%the%exterior/outside%of%the%home.%
16. Do%not%use%this%fan%with%any%solid-state%control%device.%
17. Prior%to%servicing%or%cleaning%this%unit,%shut%off%power%supply%at%the%panel%and% lock%to%p revent%the%power%
from%being%turned%on.%If%the%panel%cannot%be%locked,%clearly%mark%the%panel%with%a%warning%tag%not%to%turn%
on%the%power.%
18. Ductwork%should%be%installed%in%as%straight%a%line%as%poss ibl e,%with%min imum%b ends.%
19. Ductwork%size%must%be%a%minimum%of%the%discharge%and%should%not%be%reduced.%
20. The%fan%is%intended%to%be%mounted%at%least%7%feet%(2.1m)%above%the%floor.%
% %