Pneumatic Motorcycle Lift Bench M-1000C Capacity 1,000lbs Installation, Operation & Maintenance Manual (SHOWN WITH OPTIONAL MOTORCYCLE VISE) WARNING: READ INSTRUCTIONS BEFORE OPERATING Jun 2018
READ ENTIRE MANUAL TO COMPLY WITH ALL SAFETY AND SERVICE PRECAUTIONS. DEATH, PERSONAL INJURY AND/OR PROPERTY DAMAGE MAY OCCUR UNLESS INSTRUCTIONS ARE FOLLOWED CAREFULLY. UNPACKING AND SET-UP • • • • • Open crate, then remove ramp and shipping boards. Carefully remove lift from crate. (Note: Lift is specifically shipped upside-down.) Carefully, flip lift over to normal upright orientation. Install tie-down eyelets to front corners of platform. Locate & connect foot-operated air valve to 100 psi air supply.
OPERATION & SAFETY INSTRUCTIONS Loads must be centered on platform at all times. Loads also must be firmly positioned and secured to platform at all times. 1. Only trained persons should operate lift. 2. Center load on platform, not to exceed the 1,000 lbs. maximum weight capacity. 3. Connect to 100 psi maximum shop air to quick disconnect fitting on Foot Valve. The lift may be damaged and/or personal injury may result if the pressure exceeds the maximum 100 psi rating. 4.
EXPLODED VIEW & PARTS LIST 39 4 Jun.
OPTIONAL ACCESSORIES INSTALLATION SIDE EXTENSION SET • • • • • • Insert pipes from extension panel package through holes in lift platform. Long pipe mounts to the front and the short pipe mount to the rear. Insert M8 wing bolt provided through holes on the underside platform to secure end of pipe to platform. Mount side extension panels on ends of pipe for each side of platform, with ramp mount holes to the rear of lift. Secure side extension panels to pipe extensions using the provided ring clips.
SIDE EXTENSION SET (FINAL INSTALLATION DIAGRAM) Side Extension Ramp Ramp Mount Pins Center Ramp Drop Out Panel Side Extension Panel Ring Clip Platform 13” FRONT EXTENSION (INSTALLATION DIAGRAM) 6 Jun.
LIMITED WARRANTY Structural Warranty: The following parts and structural components carry a five year warranty: Columns Legs Tracks Arms Carriages Cross Rails Uprights Overhead Beam Top Rail Beam Swivel Pins Limited One-Year Warranty: Tuxedo Distributors, LLC (Tuxedo) offers a limited one-year warranty to the original purchaser of Lifts and Wheel Service equipment in the United States and Canada.