DOC NO.: VDL Li-Polymer Battery Product SPECIFICATION APPROVAL REV. : SHEET : PAPS-1307 A /0 1 OF 15 对 于 任 何 细 节 和 问 题 ， 请 告 诉 我 们 的 工 程 师 For Any Detail and question, Please Tell We Are Engineer ； Tel:0755-29961203,Fax:0755-29961203；投诉电话 Telephone complaints:13828848095 SPECIFICATION APPROVAL SHEEL 产品承认书 Customer Name 客户代码:...Leivaire.Inc. Customer Product Model 客户产品型号: BT305 Product Model 产品型号:...103450PL Product Cap 产品容量: 1800mAh/3.7V No.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 2 OF 15 Revision History 版本履历表 Revision Description No 内容描述 A/0 新版发行First Issue VDL CONFIDENTIAL Modify Approval 审批人 Date 日期 2013-07-15 -2- FORM No.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 3 OF 15 Contents 目录 1. Scope 概述 -------------------------------------------------------------------------------- P04 2. Product basic information 产品基本信息 ------------------------------------------------ P04 3. Battery protection characteristics 电池保护特性 ----------------------------------------- P05 4. Condition adapting characteristics 环境适应性 ------------------------------------------ P06 5.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 4 OF 15 1. Scope 概述 The specification shall be applied to Lithium-ion Polymer (Li-Po) rechargeable battery pack which is manufactured by VDL Electronics Co.,LTD. 本产品承认书描述 VDL 电子有限公司设计制造的可充电聚合物锂电池，它是产品设计、生产和检验的依据。其 作用是让客户了解产品的质量标准及正确使用方法。 Reference standard 参考标准： GB/T 18287-2000 中华人民共和国国家标准《蜂窝电话用锂离子电池总规范》 IEC/EN61960 欧盟锂电池标准 UL1642 美国锂电池安全标准 2. Product basic information 产品基本信息： No.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 5 OF 15 3．Battery protection characteristics 电池保护特性( n=1 ) No. Items 项 目 Overcharge 1 2 3 4 5 6 Parameter 参 数 condition 条件 protection detection voltage Battery voltage is greater than the (4.275±0.02)（V） protection voltage, and the delay time to 过充保护检测电压 reach, then the state of the battery into Overcharge overcharge protection.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 6 OF 15 4．Condition adapting characteristics 环境适应性（n=1） No. Items 项目 Test Method 测试方法 After the battery full charging at 20 ℃± 5℃, measure the discharging capacity with discharging 1 High/low current 0.2C5A till 3.0 (V) cut off voltage at different Temperature temperature.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 7 OF 15 5．Safety performance 安全性能（n=1） No. Items 项目 Test Method 测试方法 After the battery is fully charged, short the positive and negative terminal with 100mΩ wire resistance for 1 hour, then 1 Short protection charge with 1C5A for 5s, measure the battery open circuit 短路保护 voltage. 电池满充电后，将正负极用 100mΩ电阻短路 1H 后, 将正负极断开, 电池以 1C5A 电流瞬时充电 5s 后, 测量电池开路电压 Criteria 标准 No explosion, no fire, no smoking. OCV≥3.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 8 OF 15 6. Testing requirements 测试要求 6.1 Battery test environment 电池试验环境 Temperature 温度：20±5℃ Relative humidity 相对湿度： 45～85% RH Atmospheric pressure 大气压力： 86～106 kPa 6.2 Measuring instrumentation requirements 测量仪表要求 Voltage instrumentation requirements: Measuring the voltage meter accuracy no less than 0.5 magnitude 电压仪表要求：测量电压的仪表的精确度不低于 0.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 9 OF 15 9．Electrical Characteristics 电气特性 9.1 Battery charge/discharge 电池组充/放电 9.1.1 Full charged definition 充饱定义 With charging voltage 4.2V, current 900mAh (0.5C) continued to charge the battery pack, when charging current drops to 36mA (0.02C) charging is terminated, shall be full charged. 以充电电压4.2V，电流900mA (0.5 C) 对电池持续充电，当充电电流下降至36mA (0.02 C) 时 充电被终止，即为充饱。 9.1.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 10 OF 15 9.7 Initial capacity 初始容量 The initial capacity is after standard charge 4 hours, the capacity measured at 20±5℃ conditions with discharge current of 360mA(0.2C) till 3.0V cut-off voltage. The initial capacity ≥ 1800mAh. 电池初始容量为电池以标准充电 4Hour 后，在 20±5℃条件下以 360mA(0.2C) 电流放电至 3.0V 截止所放出 的容量，初始容量≥1800mAh. 9.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 11 OF 15 10．Battery structure diagram 电池架构图 略 11．PCB Layout PCB 布线图 12．Schematic circuit diagram 电路原理图 VDL CONFIDENTIAL - 11 - FORM No.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 12 OF 15 14．Battery Outline Drawing 电池外形尺寸图 Exposed line length 外露线长（A） 55-65mm（φ1.4） Width 宽度 （B） Max：34.5mm Length 长度 （C） Max：52.5mm 厚度 （D） Max：10.0mm 中间厚度 （E） Max：10.0mm Thickness Middle Thickness 15. Terminal wire 端子线 VDL CONFIDENTIAL - 12 - FORM No.
DOC NO.: VDL Li-Polymer Battery Product SPECIFICATION APPROVAL REV. : SHEET : PAPS-1307 A /0 13 OF 15 16. BOM 1(Bill of materials)电池物料清单 Qty (用 NO.(项次) Material Name (零件名称) Specification(规格型号) 1 cell 电芯 103450P/1800mAh/3.7V 1 2 Protection board 保护板 MM3280H01+8205 1 UL1007#24 1 UL1007#24 1 PH=1.25 红黑 UL1007#24 1 Red wire 3 红色导线 White wire 4 黑色导线 Terminal wire 5 端子线 量) 6 Yellow Tape 茶色高温胶 H*W =0.05*20mm 1 7 Yellow Tape 茶色高温胶 H*W =0.
VDL Li-Polymer Battery Product SPECIFICATION APPROVAL DOC NO.: REV. : SHEET : PAPS-1307 A /0 14 OF 15 17．Battery Precautions and Safety Instructions 电池组使用注意事项及安全说明 Please be sure to take to comply with the specifications and the following precautions to use with batteries, did not follow the specifications for the operation caused any accidents, VDL Electronics Co.,Ltd. will not accept any responsibility. 请您务必需遵守本规格书和以下使用注意事项使用电池，对于没有按照规格书进行操作所造成的任何意外事 故，VDL 电子有限公司将不承担任何责任.
DOC NO.: VDL Li-Polymer Battery Product SPECIFICATION APPROVAL REV. : SHEET : PAPS-1307 A /0 15 OF 15 Customer Inquiry 客户要求 Model 型号：VDL103450/1800mAh Version 版本：A/0 1、 IF clientele ratify specification and showpiece, please sign back specification to VDL in 1 week, or else blank out it. 如果客户认可本承认书和样品，请于 7 天内回签本承认书给 VDL 电子有限公司，过期视为无效。 2、The customer is requested to write down your information and contact VDL Electronics Co.,Ltd.
