Full Product Manual

32
TM
CHECKING FOR GAS LEAKS
WARNlNG:
Your grill must be leak tested outdoors in a well-ventilated area,
away from ignition sources such as gas-red or electrical appliances.
During the leak test, keep your grill away from open ames or sparks.
Do not smoke when checking for gas leaks. Do not use an open ame
to check for gas leaks.
1. Make a soap solution by mixing one part liquid detergent and one part water.
CAUTlON:
Do not use household cleaning agents. Damage to gas assembly
components can result.
WARNlNG:
A strong gas smell, or the hissing sound of gas indicates a serious
problem with your grill or the propane gas tank. Failure to immediately
follow the steps listed below could result in a re or explosion that
could cause serious bodily injury, death, or property damage.
- Shut o the gas supply to the grill.
- Turn the control knobs to the OFF position.
- Put out any ame with a re extinguisher.
- Open the grill lid.
- Get away from the LP gas tank.
- Do not try to x the problem yourself.
- lf odor continues or you have a re you cannot extinguish, call
your re department. Do not call near the propane tank because
your telephone is an electrical device and could create a spark
resulting in re and/or explosion.
NOTE: The normal ow of gas through
the regulator and hose assembly can
create a humming noise. A low volume
of noise is perfectly normal and will
not interfere with operation of the
grill. lf the humming noise is loud and
excessive you may need to purge air
from the gas line or reset the regulator
excess gas ow device. This purging
procedure should be done every time
a new propane gas tank is connected
to your grill. For help call the Customer
Service Helpline for assistance.
Before rst use, at the beginning of each season, or every time
your propane tank is changed, you must check for gas leaks.
2. Turn the grill control knobs OFF.
3. Turn the gas on at the propane tank.
4. Apply the soap solution to all gas connections. lf bubbles appear in the soap solution the connections are not
properly sealed. Check each tting and tighten or repair as necessary.
lf you have a gas leak that you cannot repair, turn o the gas at the source, disconnect the fuel line from your grill,
and call the TYTUS Customer Support at 855-969-5185, or your gas supplier for repair assistance.
5. Brush soapy solution onto propane tank in the areas indicated by the arrows, and look for growing bubbles on your
propane tank.