ULIN_016357_30179.
ULIN_016357_30179.fm Page 2 Thursday, February 1, 2007 1:24 PM 1 Introduction Congratulations on your purchase of a U-Line refrigeration product. A pioneer in the field for more than 40 years, U-Line Corporation is the world’s number one manufacturer of built-in, under-counter, specialty refrigeration and ice making products. U-Line dedicates 100% of its research and development to these products.
ULIN_016357_30179.fm Page 3 Thursday, February 1, 2007 1:24 PM 2 Table of Contents Introduction ...............................................................................................................................2 Warranty Registration .......................................................................................................2 Please Record Your Model Information ...........................................................................2 Table of Contents ...........................
ULIN_016357_30179.
ULIN_016357_30179.fm Page 5 Thursday, February 1, 2007 1:24 PM WARNING 3 Safety Precautions • PLEASE READ all instructions completely before attempting to install, operate, or service your unit. • Proper installation procedures must be followed if this unit is being initially installed, or is moved to a new location after being in service.
ULIN_016357_30179.fm Page 6 Thursday, February 1, 2007 1:24 PM • Stainless models feature a stainless steel wrap and sculpted stainless handles. 4 Product Features • Wood overlay units feature the ability to match cabinetry. Handles are not included with overlay units. Échelon Wine Captain Your U-Line Wine Captain is the industry’s only built-in under the counter two drawer wine storage unit with dual zone temperature control and up to 43 bottle (750 mL size) capacity.
ULIN_016357_30179.fm Page 7 Thursday, February 1, 2007 1:24 PM Interior Lighting 5 Operation The interior of the cabinet can be illuminated whenever a drawer is opened (default mode) or illuminated for a four-hour period. The LIGHT icon (Figure 3, 5) on the control panel is used to change the lighting functions. To illuminate the interior of the cabinet for a four-hour period: ULIN_0080_A Figure 2 IMPORTANT Proper air flow (Figure 2) is required for your unit to operate at its highest efficiently.
ULIN_016357_30179.fm Page 8 Thursday, February 1, 2007 1:24 PM Electronic Control Panel Checking Product Temperature Your Wine Captain has been designed to provide two temperature zones within the cabinets so the specific storage requirements of your finest wines can be satisfied. NOTE: These are product temperatures, not air temperatures. 1 2 3 4 5 ULIN_0184_A Figure 4 The electronic control with digital display (Figure 4) is configured to show a single temperature continuously.
ULIN_016357_30179.fm Page 9 Thursday, February 1, 2007 1:24 PM To adjust the set-point temperature: Wine Stocking Recommendations 1. Press and release the WARMER icon. The top of the F in °F (Figure 7, 1) of the top drawer will begin to flash. This will allow you to adjust the temperature of the top drawer. In 10 seconds of inactivity, the bottom bar of the F in °F (Figure 7, 2) will begin to flash; this will allow you to adjust the temperature of the bottom drawer.
ULIN_016357_30179.fm Page 10 Thursday, February 1, 2007 1:24 PM Storage, Vacation, Moving Wine Caddy If the unit will not be used for an extended period, or otherwise stored, follow these steps completely: WARNING Electrical Shock Hazard. Disconnect power before servicing. Before operating, replace all panels. Failure to do so may result in death or electrical shock. 1. Remove all consumable contents from the unit. 2.
ULIN_016357_30179.fm Page 11 Thursday, February 1, 2007 1:24 PM Suggestions for Matching Food and Wine 6 Wine Guide Wine Selections Suggestions Selecting the right wine for the right occasion can sometimes be a seemingly awkward or difficult task for the beginning wine enthusiast. We would therefore like to present you with a few suggestions which may provide a little more confidence and enjoyment when choosing and serving your wines.
ULIN_016357_30179.
ULIN_016357_30179.fm Page 13 Thursday, February 1, 2007 1:24 PM 7 Cleaning and Maintenance General Cleaning Exterior Cleaning (As Required) • Stainless steel surfaces and components can discolor when exposed to chlorine gas, pool chemicals, salt water or cleaners with bleach. • Keep your stainless steel unit looking new by cleaning with a good quality all-in-one stainless steel cleaner/ polish on a monthly basis.
ULIN_016357_30179.fm Page 14 Thursday, February 1, 2007 1:24 PM To defrost: 4. Clean the condenser coil (Figure 12, 2) using a soft brush with a “combing” action or vacuum cleaner. Do not touch the condenser coil. 1. Turn unit off. 2. Remove all products from the interior and open the drawer(s) (2" (5 cm) minimum). 3. Allow the frost to completely melt naturally.
ULIN_016357_30179.fm Page 15 Thursday, February 1, 2007 1:24 PM Adjust Drawers Adjusting Drawer Alignment Checking Drawer Alignment WARNING The unit’s drawers are aligned at the factory before shipment. However, their alignment could have been disturbed during shipment. SHOCK HAZARD — The unit must be unplugged from the wall outlet during drawer removal, adjustment and re-installation.
ULIN_016357_30179.fm Page 16 Thursday, February 1, 2007 1:24 PM Side-to-Side Adjustment Severe Adjustment: NOTE: The slides have extra mounting holes that may be used. Mark and Drill New Mounting Holes Not Aligned Side-to-Side Top View of Unit ULIN_0001c_A Push Slide Backward Figure 17 See Figure 17. The drawer will need a Side-to-Side Adjustment if, when viewed from the top, the drawer front is not square with the sides of the cabinet.
ULIN_016357_30179.fm Page 17 Thursday, February 1, 2007 1:24 PM Minor Adjustment: Wood Overlay NOTE: The mounting holes on the slide are slightly larger than the screws’ diameter. Frame Preparation An overlay frame covers the drawer front to give a builtin appearance. Appropriate hardware and a copy of these instructions will be included in the unit. Screws Should Be Loose IMPORTANT The thickness of the overlay frame must be 3/4". The drawer frame must not weigh more than 10 lbs.
ULIN_016357_30179.fm Page 18 Thursday, February 1, 2007 1:24 PM Light Bulb Replacement To replace the light bulb in your U-Line unit: 4 3 1 2 ULIN_0001_A Figure 25 2 1. Grasp the edges of the light housing lens (Figure 25, 1) opposite the exposed tab and gently push the lens toward the tab (Figure 25, 2). 1 ULIN_0154a_A Figure 24 3.
ULIN_016357_30179.fm Page 19 Thursday, February 1, 2007 1:24 PM 3. Press the left rack release lever (Figure 26) down, and at the same time, lift the corresponding right rack release lever up, and pull the rack out until it is free of the tracks and the cabinet. IMPORTANT Staining and final finish application: 1. Remove all screws securing wood trim to interior components, and remove the trim from the cabinet interior.
ULIN_016357_30179.fm Page 20 Thursday, February 1, 2007 1:24 PM NOTE: Your model will contain an electronic display panel (Figure 28, 3) in the wine rack attached to the bottom drawer. After removing the trim screws, and gently lifting the trim from its location, a wiring harness connector will become visible. Unplug the connector. DO NOT remove drawer from unit. 5. Remove the two screws securing the electronic control to the wood trim.
ULIN_016357_30179.fm Page 21 Thursday, February 1, 2007 1:24 PM 8 Service Before Calling for Service If your U-Line product appears to be malfunctioning, read through the OPERATION section of this guide to ensure that the function of all controls are clearly understood. If the malfunction persists, the TROUBLESHOOTING GUIDE in this guide will assist you in quickly identifying common problems, and provide information on possible causes and remedies.
ULIN_016357_30179.fm Page 22 Thursday, February 1, 2007 1:24 PM Troubleshooting Guide DANGER ELECTROCUTION HAZARD Never attempt to repair or perform maintenance on the unit until the main electrical power has been disconnected. Troubleshooting - What to check when problems occur: PROBLEM POSSIBLE CAUSE REMEDY Unit does not operate and electronic display is blank. No electrical supply Plug unit in or check circuit breaker.
ULIN_016357_30179.
ULIN_016357_30179.fm Page 24 Thursday, February 1, 2007 1:24 PM For General Inquiries: P.O. Box 245040 Milwaukee, Wisconsin 53224-9540 U.S.A. Phone (800) 779-2547 FAX (414) 354-5696 www.U-Line.com For Service and Parts Assistance: Phone (800) 779-2547 (414) 354-0300 FAX (414) 354-5696 Email: OnLineService@U-Line.com www.U-LineService.com E-mail: OnlineParts@u-line.