SDS

Safety Data Sheet
1. Product and Company Identification
Product Identifier: Rust Vanish Rust Remover
General Use: Designed to remove rust from metals surfaces.
Product Description: Bluish-Green liquid
Manufacturer: Emergency Telephone
Clift Industries, Inc. CHEMTREC
PO Box 471578 800-424-9300
Charlotte, NC 28247
704-752-0031
2. Hazards Identification
Classification:
Acute toxicity, Oral, Dermal, Inhalation Category 5
Eye Irritation, Category 2B
Signal Word:
Warning!
Hazard Statement:
H303+H313
+H333
H320
Maybe harmful if swallowed, in contact with
skin or if inhaled.
Causes eye irritation.
Precautionary
Statements Prevention:
P264
Wash hands thoroughly after handling.
Precautionary
Statements Response:
P301+330+
331
P303+352
P305+351+
338
IF SWALLOWED: Rinse mouth. Do NOT
induce vomiting.
IF ON SKIN: Wash with plenty of soap and
water.
IF IN EYES: Rinse cautiously with water for
several minutes. Remove contact lenses, if
present and easy to do. Continue Rinsing.
3. Composition/Information on Ingredients
Ingredients
CAS No.
Weight %
Aqua
7732-18-5
70-90
Decyl Glucoside
68515-73-1
2
Lauryl Glucoside
110615-47-9
2
Trisodium Salt
164462-16-2
1
Enzymes
9001-92-7
1
4. First Aid Measures
Eye Contact:
Flush eyes for fifteen minutes with water. If irritation persists, contact a
physician.
Skin Contact:
Wash with soap and water. If irritation persists, contact a physician.
Inhalation:
Not normally required. Move to fresh air. If symptoms persist, get
medical attention.
Ingestion:
Not normally required. Contact a physician if ingested.
5. Fire Fighting Measures
Extinguishing Media: Unused form: Water spray, dry chemical or carbon dioxide.
Used form: That which is compatible to liquid (s) absorbed.
Special Fire Fighting Procedures: None required.
Hazardous Combustion Products: Carbon monoxide and/or carbon dioxide.
Unusual Hazards: None expected. Refer to absorbed liquid(s) MSDS(s). Extreme heat
may cause pressure to build up inside drum.
6. Accidental Release Measures
Spill or Leak Procedures: If material is unused, collect and recover for reuse. Wear
protective equipment. Not a listed hazardous waste.
7. Handling and Storage
Handling Precautions: Avoid contact with skin and eyes. Do not swallow. Wash hands
thoroughly after handling.
Storage Precautions: Store in cool, dry area. Prevent product from freezing. Keep out of
the reach of children. Shelf life: 3 years as long as the product is kept in a clean, dry
environment away from direct sunlight and/or excessive heat.
General: Refer to absorbed liquid(s) MSDS(s). Follow label directions carefully. Make
sure all containers are labeled properly. The container can be hazardous when empty.
Follow label cautions even after the container is empty. Do not re-use empty containers for
food, clothing or products for human or animal consumption, or where skin contact can
occur.
8. Exposure Controls/Personal Protection
Engineering Controls: Use adequate ventilation to keep airborne concentrations low.
PERSONAL PROTECTION
Eyes: Safety goggles or glass with side shields
Respirator: NIOSH/MSHA approved respirator when ventilation is inadequate.
Gloves: Impervious gloves.
Other: Maintain eyewash and safety shower in work area.
OSHA HAZARDOUS COMPONENTS
(29 CFR 1910.1200):
EXPOSURE LIMIT 8 hrs. TWA (ppm)
OSHA PEL ACGIH TLV
None
9. Physical/Chemical Characteristics
Appearance: Bluish-Green liquid
Odor: Bland
pH: 7.0
Melting Point/Freezing Point: 32º F (0º C)
Initial Boiling Point and Range: 212º F (100º C)
Flash Point: None Method: Not available.
Evaporation Rate: Not established.
Flammable Limits: Not applicable.
Conditions of Flammability: Non-flammable.
Explosive Properties: Not established.
Vapor Pressure: Not available.
Vapor Density: Not established.
Relative Density (H
2
O =1): 1.079
Solubility in Water: Soluble
VOC (g/L): 0
10. Stability and Reactivity Data
General: This is a stable material
Conditions of Reactivity: Reacts with sodium hypochlorite or calcium
hypochlorite.
Incompatible Materials: Strong oxidants
Conditions to Avoid: Excessive heat or flame.
Hazardous Decomposition: Not established.
Hazardous Polymerization: Will not occur.
11. Toxicological Data
LD50: Not established.
LC50: Not established.
Carcinogenicity: IRAC: None
National Toxicology Program: None
OSHA: None
California Prop 65: No listed ingredient
Reproduction Toxicity: Not available
Teratogenicity: Not available
Mutagenicity: Not available
Synergistic Products: Not available
12. Ecological Data
No data available
13. Disposal Considerations
Waste Disposal Method: Observe all federal, state and local regulations.
14. Transport Information
D.O.T. (Department of Transportation):
Proper Shipping Name: Non-hazardous liquid
Hazard Class: Not regulated
Identification Number: Not applicable
15. Regulatory Information
CERCLA (Comprehensive Environmental Response Compensation and Liability
Act): No Reportable Quantity
OSHA Hazard Communication Standard, 28 CFR 1910.1200: No hazardous
ingredient.
SARA Title III (Superfund Amendments and Reauthorization Act): No listed
ingredient.
TSCA (Toxic Substances Control Act): All ingredients are listed.
16. OTHER INFORMATION:
NFPA Hazard Rating: Health – 1
None  Extreme Fire – 0
0  4 Reactivity – 0
PPE – B
Reason for Issue: GHS changes to Sections 2 & 3.
Prepared by: J. Pickett
Approved by: C. Matthews
Approval Date of Issue: 1/4/2017
Approval Date: 1/4/2017
The information provided in this MSDS is believed to be reliable and accurate. However,
the information is provided without any warranty or guarantee, express or implied,
regarding its correctness. We do not assume responsibility and expressly disclaim liability
for loss, damage or expense arising out of the use of this information. The buyer assumes
all responsibility of using and handling the product in accordance with the federal, state
and local regulations.