OWNER’S MANUAL MARINE KETTLE 3® GAS GRILL A10-207-3 • A10-217-3 • A10-207-3-CSA • A10-217-3-CSA A10-207-3-CE-2 • A10-217-3-CE-2 ® For questions regarding performance, assembly, operation, parts, or returns, contact the experts at MAGMA by calling (562) 627-0500 7:00 a.m. — 5:00 p.m. Pacific Time Monday thru Friday or e-mail us at mail@MagmaProducts.com. IMPORTANT, Read These Instructions Carefully Before Use. Familiarize Yourself With the Appliance Before Connecting It to Its Gas Container.
THIS PAGE INTENTIONALLY LEFT BLANK
IMPORTANT SAFETY WARNINGS FOR US & CSA GRILL MODELS READ ALL INSTRUCTIONS BEFORE OPERATING. • USE OUTDOORS ONLY. • DO NOT USE THIS APPLIANCE INSIDE THE BOAT OR ANY ENCLOSED SPACE. • GRILLS RADIATE HEAT. CLEARANCE FROM COMBUSTIBLES, 24" SIDES AND BACK. NEVER USE UNDER AWNINGS, PATIO COVERS, ETC. • USE PROPANE GAS ONLY. FUEL STORAGE SHOULD BE IN COMPLIANCE WITH THE AMERICAN BOAT AND YACHT COUNCIL (ABYC) STANDARDS A-1 (9), MARINE LIQUIFIED PETROLEUM GAS (LPG) SYSTEMS.
IMPORTANT SAFETY WARNINGS FOR CE-2 GRILL MODELS READ ALL INSTRUCTIONS BEFORE OPERATING. • USE OUTDOORS ONLY. • DO NOT USE THIS APPLIANCE INSIDE THE BOAT OR ANY ENCLOSED SPACE. • GRILL RADIATES HEAT, CLEARANCE FROM COMBUSTIBLES, 24" (61 CM) SIDE AND BACK, NEVER USE UNDER AWNINGS, PATIO COVERS, ETC. • CAUTION: ACCESSIBLE PARTS MAY BECOME VERY HOT. KEEP YOUNG CHILDREN AWAY FROM THE APPLIANCE. • NEVER LEAVE HOT GRILL UNATTENDED. • USE GLOVE OR HOT PAD WHEN HANDLING HOT GRILL.
CONTENTS Tool Needed Grill Grate For US & CSA Models Control Valve/ Regulator-Type 1 For CE-2 Models Control Valve/ Regulator-Type 2 Grill Body Dome Indexing “L” Bracket & Clamp Assembly Match Light Holder Included with CSA Models Only 9/16" Wrench Turbo Venturi Tube Assembly Not Included Radiant Plate Each Magma® Gas Grill is individually fire tested before it leaves the factory. For this reason, the burner on your grill may be slightly discolored. SETTING UP YOUR GRILL Mounts sold separately.
SETTING UP YOUR GRILL Grease Tray Pins Threaded Burner Pipe Grease Tray 5. 5b 5a 5c 5d 5. With grill body tightly attached to L-Bracket and taking care not to damage electrode, unthread burner 3 full revolutions only. CAUTION: DO NOT UNTHREAD MORE THEN 3 REVOLUTIONS, AS GRILL MAY FALL OVERBOARD. • Lift entire grill up to disengage from grease tray positioning pins (5a & 5b) and rotate so lid operates freely in desired position (5c).
CONNECTING FUEL SOURCE US & CSA — CONTROL VALVE REGULATOR A10-207-3 • A10-217-3 • Uses standard 1-lb. disposable propane canisters (DOT-39 NRC). • Prior to installing valve, become familiar with the valve function and graphics on valve knob. Never force the knob. Always turn or push gently. • Turn control valve to “LOCK” and install gas canister being careful not to cross the threads. Check for leaks prior to use, by brushing soapy water solution around threads and orifice hole checking for bubbles.
USING GRILL WITH ON-BOARD LPG (PROPANE) SYSTEMS Gently insert valve stem into venturi tube upside down until fully inserted and rotate as shown. Typical Boat and R.V.
OPERATING PROCEDURES WARNING: Do not overheat grill. Magma grills do not require pre-heating. Stainless Steel loses anti-corrosive characteristics when subjected to extreme heat. Most grilling is done on low temperature with the lid closed. If medium or high heat is required, grill with lid open. • • • • • • • • LIGHTING INSTRUCTIONS Open lid during lighting. • Depress knob & rotate counter-clockwise to the “HIGH” position. Push Electronic Pulse Igniter. • Visually confirm ignition.
USING THE MARINE KETTLE AS A STOVE Magma’s patented, unique design of the Marine Kettle allows it to be used as a conventional stove. This permits you to fry, saute, boil, wok, etc. • Remove the grill grate. • Remove the radiant dome • Adjust flame to proper cooking temperature. • For smaller pots/pans, place the cookware directly on the three tongs of the radiant plate. • For larger pots/pans, including woks, invert the radiant plate and place the cookware directly on the radiant plate.
REPLACEMENT PARTS A10-207-3, A10-207-3-CSA — “Original” Size A10-217-3, A10-217-3-CSA — “Party” Size A10-207-3-CE-2 — “Original” Size A10-217-3-CE-2 — “Party” Size Cooking Grill Radiant Plate Burner Fire Pan Complete Handle Assembly & Fasteners Lid w/hinge & fasteners (no handle) Bowl Electronic Pulse Igniter Igniter Case Grease Tray “L” Bracket & Clamp Assembly Turbo Venturi Tube For CE-2 Models A10-207-3 & A10-217-3 Control Valve/Regulator Type 2 Low-Output For US & CSA Models A10-207-3 & A10-217-
TROUBLESHOOTING GUIDE PROBLEM POSSIBLE CAUSE POSSIBLE SOLUTION Electrode covered with grease or residue • Clean electrode • Clean, adjust & reconnect wire between igniter & electrode, (See “Complete Disassembly”, Page 10) • Replace Igniter, Electrode & Wire (See Page 11) • • Adjust electrode until proper spark appears Unscrew igniter push button, remove/inspect “AAA” battery, replace “AAA” alkaline battery if necessary, reinstall and re-assemble push button Replace Igniter, Electrode & Wire (See
ACCESSORIES Magma® Marine Kettle® Grill Cover/Tote Bag Original & Party Size Stores in less than 1/2 cubic foot Fully “Nesting,” 7 & 10 piece, 18-10 Stainless Steel Cookware Sets with Stainless Steel or Ceramica Non-Stick Interiors Stainless Steel, Cobalt Blue, Jet Black, or Magma Red Enamel exteriors and Induction compatible models available. Luggage Quality Padded Grill & Accessory Carry/Storage Case Fits grills up to 17" dia.
LIMITED WARRANTY Magma Products, Inc. guarantees this product to be free from defects in materials or workmanship to the original consumer. This guarantee is for the periods herein specified when used under normal and reasonable conditions, one (l) year from the date of original purchase. This warranty does not include the cost of property damage or any inconvenience due to the failure of the product.
ADDENDUM FOR GAS GRILL MODELS A10-207-3AU-1, A10-217-3AU-1 SOLD IN AUSTRALIA CAUTION: Accessible parts may be very hot. Keep young children away. ONLY USE IN WELL-VENTILATED AREAS. • CARBON MONOXIDE HAZARD-THIS APPLIANCE CAN PRODUCE CARBON MONOXIDE WHICH HAS NO ODOUR. DO NOT USE IN ENCLOSED AREAS, (FOR EXAMPLE: CAR, TENT, CARAVAN, MOBILE HOME) MAY CAUSE DEATH.
CYLINDERS: If there is a leak on your appliance (smell of gas), immediately attempt to turn off cylinder valve. Turn off appliance control valve. Remove appliance to a well-ventilated location away from any ignition source. STORAGE: NEVER LEAVE GAS CYLINDERS CONNECTED WHEN NOT IN USE! CYLINDERS: When you have finished using this appliance, turn gas cylinder off; wait for the flame to go out and turn the appliance control valve off.
