CMD 50 176 MITTEL DRIVE, WOOD DALE, IL 60191 CARAMEL CORN MIXER MODEL CMD 50 120/208 Volt, Single Phase, 60 Hz 120/240 Volt, Single Phase, 60 Hz 230 Volt, Single Phase, 50 Hz 400 Volt, Three Phase, 50 Hz READ and UNDERSTAND these operating and safety instructions before operating this popcorn machine 1 3/02
CMD 50 Table of Contents I. Safety Alert Symbol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 II. Safety First . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 III. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 IV. Purpose of Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 V. Product Identification . . . . . . . . . . . . . . . . . . . . . .
CMD 50 I. SAFETY ALERT SYMBOL The symbol shown is used to call your attention to instructions concerning your personal safety and the safety of others. Watch for this symbol. It points out important safety precautions. It means ATTENTION! Become Alert! Your personal safety is involved! Read the message that follows and be alert to the risk of personal injury or death. II. SAFETY FIRST The information in this manual is essential for the safe installation and operation of your Cretors machine.
CMD 50 IV. PURPOSE OF MANUAL This instruction manual is intended to familiarize owners with the operation and safety procedures associated with your Cretors machine. It is important that this manual be kept available to operating personnel. A person who has not read and understood all operating and safety instructions is not qualified to operate the machine. V. PRODUCT IDENTIFICATION CRETORS POPCORN MACHINE CARAMEL CORN MIXER – CMD 50 VI. CONTROL SWITCHES KETTLE HEAT -Turns the kettle heat On/Off.
CMD 50 on the mixer switch (leave on) and add up to 2 measuring can (approximately 1 lb, 10oz.) of popped corn. 6. When the corn is well coated, spray with Non-Stick to separate. 7. Corn must be sprayed with Non-Stick in order for the individual kernels to separate. 8. When the corn appears to be separated and free in the mixer, dump the batch. Never run the mixer longer than necessary as this will break up the corn. 9. Turn the mixer motor off and dump the mixer by lifting up on the handle.
CMD 50 VIII. SANITATION INSTRUCTIONS Be certain the machine is turned off and power is unplugged before sanitizing this machine unless a specific cleaning procedure requires power to the machine. Failure to do so could result in injury or death. Do not clean heated surfaces until they have been given sufficient time to cool. Failure to do so may result in serious burns or scalds. The mixer should be thoroughly cleaned daily with warm water.
CMD 50 If you have any questions, contact your local distributor and if there are any additional questions, feel free to contact the Customer Service Department at C. Cretors and Company. Additional copies of this manual can be obtained from C. Cretors and Company at the address listed below. Please provide model and serial number when requesting additional copies of this manual. There will be a nominal charge for additional copies.
CMD 50 176 MITTEL DRIVE, WOOD DALE, IL 60191 CARAMEL CORN MIXER MODEL CMD 50 W/ TIMER 120/208 Volt, Single Phase, 60 Hz 120/240 Volt, Single Phase, 60 Hz 230 Volt, Single Phase, 50 Hz 400 Volt, Three Phase, 50 Hz READ and UNDERSTAND these operating and safety instructions before operating this popcorn machine 1 3/02
CMD 50 Table of Contents I. Safety Alert Symbol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 II. Safety First . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 III. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 IV. Purpose of Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 V. Product Identification . . . . . . . . . . . . . . . . . . . . . .
CMD 50 I. SAFETY ALERT SYMBOL The symbol shown is used to call your attention to instructions concerning your personal safety and the safety of others. Watch for this symbol. It points out important safety precautions. It means ATTENTION! Become Alert! Your personal safety is involved! Read the message that follows and be alert to the risk of personal injury or death. II. SAFETY FIRST The information in this manual is essential for the safe installation and operation of your Cretors machine.
CMD 50 IV. PURPOSE OF MANUAL This instruction manual is intended to familiarize owners with the operation and safety procedures associated with your Cretors machine. It is important that this manual be kept available to operating personnel. A person who has not read and understood all operating and safety instructions is not qualified to operate the machine. V. PRODUCT IDENTIFICATION CRETORS POPCORN MACHINE CARAMEL CORN MIXER – CMD 50 WITH TIMER VI.
CMD 50 4. Set the Temperature Controller on the side of the cabinet to 325°F. It may be necessary to adjust the temperature higher or lower to get the color and flavor you desire. 5. When the mix reaches the set point, the heat will automatically turn off which will also turn out the pilot light and sound the buzzer. At this time turn off the heat switch, turn on the mixer switch and add 2 measuring can (approximately 2.25 lbs.) of popped corn. 6.
CMD 50 VIII. SANITATION INSTRUCTIONS Be certain the machine is turned off and power is unplugged before sanitizing this machine unless a specific cleaning procedure requires power to the machine. Failure to do so could result in injury or death. Do not clean heated surfaces until they have been given sufficient time to cool. Failure to do so may result in serious burns or scalds. The mixer should be thoroughly cleaned daily with warm water.
