Use and Care Manual

CMD 50
4
3/02
IV. PURPOSE OF MANUAL
This instruction manual is intended to familiarize owners with the operation
and safety procedures associated with your Cretors machine.
It is important that this manual be kept available to operating personnel.
A person who has not read and understood all operating and safety instructions is not
qualified to operate the machine.
V. PRODUCT IDENTIFICATION
CRETORS POPCORN MACHINE
CARAMEL CORN MIXER – CMD 50 WITH TIMER
VI. CONTROL SWITCHES
KETTLE HEAT -Turns the kettle heat On/Off.
MIXER -Turns the stirrer blade motor On/Off.
DIGITAL CONTROLLER -Displays and controls kettle temperature.
ON/OFF MIXER CONTROLLER –Adjust time mixer is on and off.
VII. OPERATING INSTRUCTIONS
CAUTION: This machine is supplied with an intermittent timer. The agitator
motor and blade will automatically start and stop. Serious injury can occur if
hand is in mixer when agitator turns.
A. To make a batch of Caramel Corn, proceed as follows:
1. Spray with Non-Stick the bottom, inside walls, mixing blades and stationary bars that are
on the inside walls of the mixer. This serves to keep the mixer clean and also helps the
caramel corn to separate into individual kernels after being coated.
2. Put the contents of 2 bag of Cretors Mix and 4oz. to 6oz of water into the mixer and follow
the mix instructions.
3. Turn on the switch marked HEAT. The motor will run 18 seconds on and then turn off
for 60 seconds. This cycle will repeat until the heat switch is shut off. To adjust the time
sequence, adjust the two time delay knobs to desired time on or off.