SDS

Notice: The information and recommendations set forth are made in good faith and are believed to be accurate at
the date of preparation. Panasonic Industrial Company makes no warranty expressed or implied.
007-15 Page 1 of 2
Panasonic Batteries
Panasonic Industrial Company
A Division of Panasonic Corporation of North America
5201 Tollview Drive, 1F-3
Rolling Meadows, IL 60008
Toll Free: 877-726-2228
Fax: [phone]
Internet: www.panasonic.com/industrial/batteries-oem
e-mail: [e-mail]
MSDS
Material Safety Data Sheets (MSDS) are a sub-requirement of the Occupational Safety and Health Administration
(OSHA) Hazard Communication Standard, 29 CFR Subpart 1910.1200. This Hazard Communication Standard does
not apply to various subcategories including anything defined by OSHA as an "article". OSHA has defined "article" as a
manufactured item other than a fluid or particle; (i) which is formed to a specific shape or design during manufacture; (ii)
which has end use function(s) dependent in whole or in part upon its shape or design during end use; and (iii) which
under normal conditions of use does not release more than very small quantities, e.g. minute or trace amounts of a
hazardous chemical, and does not pose a physical hazard or health risk to employees.
Because all of our batteries are defined as "articles", they are exempt from the requirements of the Hazard
Communication Standard; hence a MSDS is not required.
The following components are found in a Panasonic Carbon Zinc battery:
Component
Material
Formula
CAS #
Positive Electrode
Manganese Dioxide
Carbon Black
MnO
2
C
1313-13-9
1333-86-4
Negative Electrode
Zinc
Zn
7440-66-6
Electrolyte
Ammonium Chloride
Zinc Chloride
NH
4
Cl
2
ZnCl
2
12125-02-9
7646-85-7
Disposal
Since January 1992 all Panasonic Carbon Zinc batteries are manufactured with "no mercury added ". These
batteries are classified by the federal government as a non-hazardous waste and are safe for disposal in the
normal municipal waste stream. Check local your local area for recycling options.
Transportation
Carbon-Zinc batteries (sometimes referred to as “Dry cell” batteries) are not listed as dangerous goods under the
International Civil Aviation Organization (ICAO), 2013-2014 edition, International Air Transport Association (IATA),
55th edition and U.S. Department of Transportation (DOT) regulations, 49 CFR. These batteries are not subject to
the dangerous goods regulations provided they meet the requirements contained in the following Special
Provisions; Special Provision A123 in the ICAO Technical Instructions and IATA Dangerous Goods Regulations
and Special Provision 130 of the DOT. These regulations require these batteries to be packed in such a way to
prevent short circuits or generation of a dangerous quantity of heat. In addition, the ICAO and IATA regulations
require the words “Not Restricted” and “Special Provision A123” be provided on the air waybill, when an air waybill
Product Information Sheet
Product: Carbon Zinc Batteries
Applicable models/sizes: All Cylindrical
and 9-Volt
Revision: January 1, 2015
The batteries referenced herein are exempt articles and are not subject to the OSHA Hazard
Communication Standard requirement. This sheet is provided as a service to our customers.