User's Manual Part 1

Chapter 3 Installation
Contents
3 Installation ................................................................................ 3-1
3.1 Introduction............................................................................................ 3-1
3.2 Components/Sub-Assemblies Installed at the Factory............................ 3-1
3.3 Components/Sub-Assemblies Installed On-Site...................................... 3-3
3.4 Required Tools ........................................................................................ 3-4
3.5 Installation Overview.............................................................................. 3-5
3.6 Repeater Setup ....................................................................................... 3-6
3.6.1 Moving the Repeater Cabinet ............................................................ 3-6
3.6.2 Installation Surface ......................................................................... 3-7
3.6.3 Repeater Cabinet Positioning............................................................. 3-7
3.6.4 Unpacking...................................................................................... 3-9
3.7 Electronics Compartment Components.................................................... 3-9
3.7.1 BMS 12 VDC Rectifier Module...........................................................3-12
3.7.2 High Band Exciter (HBE)..................................................................3-13
3.7.3 Low Band Exciter (LBE)...................................................................3-14
3.7.4 Terrestrial Repeater Monitoring System (TRMS)..................................3-15
3.7.5 Dial-up Modem ..............................................................................3-15
3.8 HPA Compartment Components ............................................................ 3-15
3.8.1 Combined DRU Pre-installation.........................................................3-18
3.8.2 Independent DRU Pre-installation .....................................................3-20
3.8.3 DR Filter Box .................................................................................3-21
3.8.4 High Power Amplifier (HPA) .............................................................3-24
3.8.5 Finalize DR Filter Box and HPA Installation .........................................3-27
3.8.6 HPA PSU 30 VDC Rectifier Module.....................................................3-27
3.9 Internal Wire/Cable Connections.......................................................... 3-29
3.9.1 Ground and AC Connections.............................................................3-30
3.9.2 High Band Exciter (HBE)..................................................................3-31
3.9.3 Low Band Exciter (LBE)...................................................................3-32
3.9.4 Terrestrial Repeater Monitoring System (TRMS)..................................3-34
3.9.5 Dial-up Modem ..............................................................................3-35
3.10 External Input Signal Interfaces ........................................................... 3-36
3.10.1 S-Band Antenna.............................................................................3-37
3.10.2 Ku-Band Antenna ...........................................................................3-37
3.10.3 GPS Antenna .................................................................................3-37
3.11 Communications Interfaces .................................................................. 3-38
3.11.1 PSTN Phone Line ............................................................................3-38
3.12 Shelter/Room Alarm Connections ......................................................... 3-40
3.13 RF Output Interfaces............................................................................. 3-42
3.14 AC Power............................................................................................... 3-44
3.14.1 General Requirements.....................................................................3-44
3.14.2 Repeater Cabinet Ground Connection ................................................3-44
3.14.3 Repeater Cabinet AC Power Connection .............................................3-46
SX03-10000-01-M01 3-1