75L / 6.1 cu. ft.
TABLE OF CONTENTS 03 07 08 09 11 14 15 16 18 20 20 21 21 Back Important safety notes Installation Parts list DC power connection Operation Cleaning Energy saving tips Troubleshooting Parts diagram and list Appliance information Notes Contact us Limited warranty Technical specifications
IMPORTANT SAFETY NOTES IMPORTANT: After transit where the freezer has been on its side or back, ensure that the freezer is in a level, upright position for 12 hours to allow compressor fluids to redistribute evenly before use. Congratulations! You have purchased one of the most efficient refrigeration products available on the market today. The Unique 175L UF solar powered DC freezer is designed to provide years of troublefree operation.
IMPORTANT SAFETY NOTES continued • To allow the interior to cool down properly, run the freezer for at least 4 hours empty before adding food. • This freezer is designed to operate on 12 or 24 volts DC ONLY. DO NOT CONNECT THIS FREEZER DIRECTLY TO AN AC (alternating current) POWER SOURCE UNLESS IT”S THE SUPPLIED UNIQUE AC/DC PLUG. • This freezer is designed for domestic use only! It is intended for the storage of edible/consumable food and drinks. It is not intended for commercial or industrial use.
IMPORTANT SAFETY NOTES continued These warnings are provided in the interest of your safety. Please ensure that you understand them all before installing or using this freezer. Your safety is of paramount importance. If you are unsure about any of these meanings or warnings, contact your local product dealer or Unique Off-Grid Appliances for assistance. PRIOR TO INSTALLATION: At delivery, please check that the freezer is complete and has not been damaged during transport.
IMPORTANT SAFETY NOTES continued supply cable. Also, be sure the electrical cable is not squeezed or bent when the appliance is being installed or moved. • Installation work and adjustments on the appliance must be carried out by qualified personnel only. Work performed by persons with inadequate technical knowledge may adversely effect the performance of the appliance, causing damage to the equipment, and void the warranty. • It is dangerous to make alterations or attempt to modify this product in any way.
INSTALLATION UNPACKING AND CLEANING Remove all packaging and securing tapes from the appliance. To avoid injury and causing damage to the appliance, be extremely cautious when using sharp or pointed tools to complete this task. Keep children away from the packaging material - DANGER OF SUFFOCATION! Wash the inside and outside of the appliance with luke warm water and a mild soap or detergent.
PARTS LIST PARTS LIST 1: Storage drawers 2: Thermostat 3: Door 4: Adjustable feet 5: Ice tray 6: Power cable 7: AC/DC Plug (sold seperatly for 110V application) 2 1 5 6 7 AC/DC plug (sold seperatly for 110V application) 4 8 3
DC POWER CONNECTION THIS FREEZER MUST NEVER BE CONNECTED DIRECTLY TO ANY AC (alternating current) POWER SOURCE! THE FREEZER MUST ONLY BE CONNECTED TO A 12V OR 24V DC POWER SOURCE, SUCH AS A SOLAR BATTERY SYSTEM OR CHARGE CONTROLLER. THE FREEZER WILL AUTOMATICALLY OPERATE ON EITHER 12V OR 24V DC. THE USER DOES NOT NEED TO MAKE ANY ADJUSTMENT. ATTENTION: Polarity is important in wiring this DC appliance.
DC POWER CONNECTION continued IN-LINE FUSE A 15A in-line fuse is provided with this freezer in order to protect the wiring. For 12V/24V operation, use a 15A fuse. A standard automobile fuse is recommended and the fuse should be wired to the positive (“+”) side of the system close to the positive battery terminal. A 15A fuse is provided with this freezer.
OPERATION Your Unique freezer, like any battery-powered refrigerating appliance, requires different care than appliances plugged into an electric utility. Prudent operation is the key to extended service. STARTING THE FREEZER After the freezer has been properly connected to the 12 or 24 V DC power source, the compressor will automatically turn on and the cabinet will begin cooling. Allow the cabinet to cool for at least 4 hours prior to adding foodstuff.
OPERATION continued ADJUSTMENTS As the ambient temperature changes with the season, it may be necessary to adjust the thermostat to achieve the proper internal temperature. If the room/ambient temperature approaches the appliance’s internal operating temperature, the appliance will not function as it should. The appliance will tend to run colder during these conditions and it may be necessary to turn the thermostat to a warmer setting (lower number).
OPERATION continued DEFROSTING Before cleaning or repositioning the freezer, you must DISCONNECT the appliance from the electrical power supply. DEFROSTING THE UNIT As solar freezers do not have automatic defrost the freezer compartment will become progressively covered with frost. This should be removed periodically with a plastic scraper. However, when the ice becomes very thick on the interior walls, complete defrosting should be carried out.
OPERATION continued LED Light Remove 4 screws from grates to access 15A fuse NOTE: When freezer is connected to a power adaptor or to a battery, light indicator will not light up. CLEANING Internal Cleaning Wash the inside of the appliance with luke warm water and a mild soap. Never use abrasive or corrosive cleaning agents, steel wool, scouring sponges, chemical cleaning agents, or highly perfumed cleaning products to clean the interior as these will damage the surface and leave behind a strong odor.
ENERGY SAVING TIPS • Do not install the freezer close to sources of heat, such as a stove, boiler, heater, chimney, etc, and avoid exposure of the appliance to direct sunlight. • Locate the appliance in a cool well-ventilated room and make sure that the air vents of the compressor housing cover are not obstructed. Also allow adequate spacing around the cabinet for air circulation (3” or 7.5cm) • Avoid unnecessary frosting in the cabinet by packing all food and liquids in airtight packages or containers.
TROUBLESHOOTING Before contacting a service technician, your local product dealer or Unique Off-Grid Appliances, please check the following points. If you contact a technician to repair a fault listed below, or to repair a fault caused by misuse, abuse, or faulty installation, a charge will be made even if the appliance is under warranty. PROBLEM SOLUTION Appliance is connected to power, but does not operate • Check if 12V or 24V DC is present at the appliance.
TROUBLESHOOTING continued Excessive frost and ice has built up • Is the weather hot and humid? If so, this will increase the rate of frost build-up in the cabinet. • Ensure that stored food is properly packaged. • Check that the door is closed and has a good seal, and that nothing is preventing the door from closing properly. • Large quantities of food have recently been placed in the freezer, and/or the door is frequently opened.
UGP-175L UF PARTS DIAGRAM AND LIST 18
PARTS DIAGRAM AND LIST continued ITEM # PART # DESCRIPTION 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 UGP-175L-3 UGP-175L-4 UGP-175L-5 UGP-175L-6 UGP-175L-7 UGP-175L-8 UGP-175L-9 UGP-175L-10 UGP-175L-11 UGP-175L-12 UGP-175L-13 UGP-175L-14 UGP-175L-15 UGP-175L-16 UGP-175L-17 UGP-175L-18 UGP-175L-19 UGP-175L-20 UGP-175L-21 UGP-175L-22 UGP-175L-23 UGP-175L-24 UGP-175L-25 UGP-175L-26 UGP-175L-27 UGP-175L-28 UGP-175L-29 UGP-175L-30 UGP-175L-31 UGP-175L-32 UGP-
APPLIANCE INFORMATION (manual copy - keep with your records) To make care and servicing of your solar powered DC freezer easy and efficient, please record the following information for future reference: Model: Serial Number: Purchased From: Date Purchased: NOTES 20
CONTACT US For questions related to the operation, safety or the purchase of your freezer, please contact your dealer for more information. For general information, contact our customer service department: • Toll-free: 1-877-427-2266 or 1-905-827-6154 (available during regular business hours, 8:30 am to 4:30 pm, EST. • Email: info@UniqueOffGrid.com Website: www.uniqueoffgrid.com • Address: Unique Gas Products Ltd.
TECHNICAL SPECIFICATIONS MODEL UGP-175L UF SIZE total: 6.1 cu/ft, 175 litres OPERATION •12V/24V DIMENSIONS (unboxed) H 56.7” x W 21.6” x D 24” H 144 cm x W 55 cm x D 61.5 cm WEIGHT 102.5 lbs./46.5 kg DC POWER 12V/24V TOTAL WATT HR. PULL DOWN (24 DC) 695 Wh/24hrs (set to -13˚C freezer TOTAL WATT HR. STABLE RUNNING (24 DC) 532 Wh/24hrs (set to -13˚C freezer POWER CONSUMPTION 12V/24V 58.8 W AV. RUN CURRENT 4.9A on 12V - 2.5A on 24V FREEZER TEMP.