265L / 9.3 cu. ft.
TABLE OF CONTENTS 03 07 08 09 11 14 15 15 16 18 19 19 20 20 Back Important safety notes Installation Parts list DC power connection Operation Error codes Cleaning Energy saving tips Troubleshooting Parts diagram and list Appliance information Notes Contact us Limited warranty Technical specifications
IMPORTANT SAFETY NOTES IMPORTANT: After transit where the freezer has been on its side or back, ensure that the freezer is in a level, upright position for 12 hours to allow compressor fluids to redistribute evenly before use. Congratulations! You have purchased one of the most efficient freezers available on the market today. The Unique 265L1 solar powered DC chest freezer is designed to provide years of trouble-free operation.
IMPORTANT SAFETY NOTES continued • To allow the interior to cool down properly, run the freezer for at least 4 hours empty before adding food. • This freezer is designed to operate on 12 or 24 volts DC ONLY. DO NOT CONNECT THIS FREEZER TO AN AC (alternating current) POWER SOURCE (UNLESS USING AN AC/DC CONVERTER SOLD SEPARATELY) • This freezer is designed for domestic use only! It is intended for the storage of edible/consumable food and drinks. It is not intended for commercial or industrial use.
IMPORTANT SAFETY NOTES continued These warnings are provided in the interest of your safety. Please ensure that you understand them all before installing or using this freezer. Your safety is of paramount importance. If you are unsure about any of these meanings or warnings, contact your local product dealer or Unique Off-Grid Appliances for assistance. PRIOR TO INSTALLATION: At delivery, please check that the freezer is complete and has not been damaged during transport.
IMPORTANT SAFETY NOTES continued supply cable. Also, be sure the electrical cable is not squeezed or bent when the appliance is being installed or moved. • Installation work and adjustments on the appliance must be carried out by qualified personnel only. Work performed by persons with inadequate technical knowledge may adversely effect the performance of the appliance, causing damage to the equipment, and void the warranty. • It is dangerous to make alterations or attempt to modify this product in any way.
INSTALLATION UNPACKING AND CLEANING Remove all packaging and securing tapes from the appliance. To avoid injury and causing damage to the appliance, be extremely cautious when using sharp or pointed tools to complete this task. There is a protective film on the lid of the unit which can be removed. Keep children away from the packaging material - DANGER OF SUFFOCATION! Wash the inside and outside of the appliance with luke warm water and a mild soap or detergent.
PARTS LIST PARTS LIST 1: Lid 2: Handle 3: Lock 4: Keys 5: LED light 6: Drain 4 7: Wheels 8: Glass sliders 9: Control panel 10: Left hinge 11: Right hinge 12: Basket 3 13: Ice tray 14: DC Power Cable 15: Ice scraper 16: AC/DC Plug (optional for on-grid use) 12 2 x Storage Baskets 2 13 5 14 1 10 8 11 15 16 6 7 INSTALLING THE HANDLE 1. Place the handle over the screw holes located on the lid. 2. Screw in the two screws & place the caps over to cover (provided).
DC POWER CONNECTION THIS FREEZER MUST NEVER BE CONNECTED DIRECTLY TO ANY AC (alternating current) POWER SOURCE! THE FREEZER MUST ONLY BE CONNECTED TO A 12V OR 24V DC POWER SOURCE, SUCH AS A SOLAR BATTERY SYSTEM OR CHARGE CONTROLLER. THE FREEZER WILL AUTOMATICALLY OPERATE ON EITHER 12V OR 24V DC. THE USER DOES NOT NEED TO MAKE ANY ADJUSTMENT. ATTENTION: Polarity is important in wiring this DC appliance.
DC POWER CONNECTION continued REPLACING THE FUSE Remove 3 screws from grates to access the 15A fuse. OPERATING FUSE VOLTAGE 12 V / 24 V 15 A ATTENTION If a longer connection cable is necessary, the cable cross section (or gauge) must be equal to or greater than the cable sizes recommended on the following table. Be careful that the input voltage at the appliance does not drop below the cut-out voltage of the compressor. CABLE SIZE AREA AWG 12V CABLE LENGTH mm /inch Gauge m ft m ft 2.
OPERATION Your Unique freezer, like any battery-powered refrigerating appliance, requires different care than appliances plugged into an electric utility. Prudent operation is the key to extended service. STARTING THE FREEZER After the freezer has been properly connected to the 12 or 24 V DC power source or the AC/DC adaptor (sold separately), the compressor will automatically turn on and the cabinet will begin cooling. Allow the cabinet to cool for at least 4 hours prior to adding food.
OPERATION continued ADJUSTMENTS As the ambient temperature changes with the season, it may be necessary to adjust the thermostat to achieve the proper internal temperature. If the room/ambient temperature approaches the appliance’s internal operating temperature, the appliance will not function as it should. The appliance will tend to run colder during these conditions and it may be necessary to turn the thermostat to a warmer setting (lower number).
OPERATION continued DEFROSTING Before cleaning or repositioning the freezer, you must DISCONNECT the appliance from the electrical power supply. DEFROSTING THE UNIT As solar freezers do not have automatic defrost the freezer compartment could become progressively covered with frost. When 5mm of frost forms in the freezer, this should be removed with the supplied plastic scraper. However, when the ice becomes very thick on the interior walls, complete defrosting should be carried out.
ERROR CODES on control panel display 14 Error Code Error type can be read out on the control display Err 9 Thermostat failure (if the thermostat is not connected) Err 5 Over heating of compressor Err 4 Compressor speed error Err 3 Compressor start error Err 2 Over-current on cooling fan Err 1 Battery protection change to lower voltage on UVP Err 0 Thermostat failure (if the thermostat short circuits)
CLEANING Internal Cleaning Wash the inside of the appliance with luke warm water and a mild soap. Never use abrasive or corrosive cleaning agents, steel wool, scouring sponges, chemical cleaning agents, or highly perfumed cleaning products to clean the interior as these will damage the surface and leave behind a strong odor. A sponge, towel, or soft brush is recommended. Wash with a mixture of two tablespoons (30ml) of baking soda to 1 quart (1.14L) warm water.
TROUBLESHOOTING Before contacting a service technician, your local product dealer or Unique Off-Grid Appliances, please check the following points. If you contact a technician to repair a fault listed below, or to repair a fault caused by misuse, abuse, or faulty installation, a charge will be made even if the appliance is under warranty. PROBLEM SOLUTION Appliance is connected to power, but does not operate • Check if 12V or 24V DC is present at the appliance.
TROUBLESHOOTING continued Excessive frost and ice has built up • Is the weather hot and humid? If so, this will increase the rate of frost build-up in the cabinet. Glass sliders will help prevent build up. • Ensure that stored food is properly packaged. • Check that the lid is closed and has a good seal, and that nothing is preventing the lid from closing properly. • Large quantities of food have recently been placed in the freezer, and/or the lid is frequently opened.
UGP-265L1 PARTS DIAGRAM AND LIST 24 18 ITEM # 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 PART # UGP-265L 1 UGP-265L 2 UGP-265L 3 UGP-265L 4 UGP-265L 5 UGP-265L 6 UGP-265L 7 UGP-265L 8 UGP-265L 9 UGP-265L 10 UGP-265L 11 UGP-265L 12 UGP-265L 13 UGP-265L 14 UGP-265L 15 UGP-265L 16 UGP-265L 17 UGP-265L 18 UGP-265L 19 UGP-265L 20 UGP-265L 21 UGP-265L 22 UGP-265L 23 UGP-265L 24 DESCRIPTION Door Door handle LED light Door Seal Freeze Cabinet Hinge Hinge Cover Glass lid Wire Basket Wire Spl
APPLIANCE INFORMATION (manual copy - keep with your records) To make care and servicing of your solar powered DC freezer easy and efficient, please record the following information for future reference: Model: Serial Number: Purchased From: Date Purchased: NOTES 19
CONTACT US For questions related to the operation, safety or the purchase of your freezer, please contact your dealer for more information. For general information, contact our customer service department: • Toll-free: 1-877-427-2266 or 1-905-827-6154 (available during regular business hours, 8:30 am to 4:30 pm, EST. • Email: info@UniqueOffGrid.com Website: www.uniqueoffgrid.com • Address: Unique Gas Products Ltd.
TECHNICAL SPECIFICATIONS MODEL UGP-265L1 SIZE total: 9.3 cu/ft, 265 litres OPERATION •12V/24V DIMENSIONS (unboxed) H 45.7” x W 26.2” x D 33.5” H 116.1 cm x W 66.5 cm x D 85 cm WEIGHT 119 lbs./54 kg DC POWER 12V/24V TOTAL WATT HR. DRAW (24 DC) 627 Wh/24hrs (set to -16˚C freezer performance in a +25˚C ambient) TOTAL AMP HR. DRAW (24 DC) 22.7 Wh/24hrs (set to -16˚C freezer performance in a +25˚C ambient) POWER CONSUMPTION 12V/24V 69 W AV. RUN CURRENT 5.75A on 12V - 2.