UNIQUE UGP 6F CHEST FREEZER Installation and Owner’s Manual WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to this manual. For assistance or additional information consult a qualified installer, service agency or the gas supplier. !SAVE THESE INSTRUCTIONS! FOR YOUR SAFETY IF YOU SMELL GAS Open windows. Do not touch electrical switches.
MANUFACTURED AND CERTIFIED BY Unique Gas Products Ltd ““PPeerrssoonnaall SSeerrvviiccee & & KKnnoow maakkeess uuss U wlleeddggee m Unniiqquuee”” 2245 Wyecroft Road #5 Oakville, Ontario Canada L6L 5L7 Ph: 905-827-6154 Toll Free: 1-877-427-2266 Fax: 905-827-2027 www.UniqueOffGrid.com E-mail: info@UniqueOffGrid.
Table of Contents Chapters Welcome, Safety and Warnings 1 Appliances Installation/ Operating Instructions 2 Maintenance & Service 3 Troubleshooting & Suggested Spares 4 Food Storage & Cleaning 5 Wiring Diagram 6 Carbon Monoxide Instructions (CM Model) 7 Parts & Warranty 8
U N I Q U E U G P 1 Chapter 6 F Welcome & Congratulations C ongratulations on your purchase of a UNIQUE Freezer!. We are very proud of our product and we are completely committed to providing you with the best service possible. Your satisfaction is our #1 priority. Please read this manual very carefully. It contains valuable information on how to properly maintain your new gas freezer. We know you will enjoy your new freezer and Thank You for choosing one of our Unique Gas Products.
U N I Q U E U G P 6 F Safety and Warnings If you smell gas Open Windows Don’t touch electrical switches Extinguish any open flame Immediately call your gas supplier For your Safety Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this unit or any other appliance Warning Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to this manual.
U N I Q U E U G P 2 Chapter 6 F Installation and Operating Instructions Installation For best performance at high ambient temperatures, there must be free air circulation over the cooling unit at the rear of the freezer. Ensure that there is a free air space above the freezer and that the flue (chimney) on top of the cabinet is not covered in any way. Do not place the freezer in a space where air circulation is restricted. Follow “clearance” instructions.
U N I Q U E U G P 6 F Clearances Minimum clearances to combustible materials are: Top 27”, Sides 2”, Rear 4” Note: DO NOT install the appliance directly on carpeting. Carpeting must be removed or protected by a metal or wood panel beneath the appliance, which extends at least the full width and depth of the appliance. Keep appliance area clear and free from combustible materials, gasoline and other liquids with flammable vapors.
U N I Q U E U G P 6 F Make sure the freezer and any other high BTU appliances on your line are turned on when checking the gas pressure. The appliance and its individual shut-off valve must be disconnected from the gas supply piping system during any pressure testing of that system at pressures in excess of ½” psig. If detailed instructions on the installation and connection of the gas supply are required, contact your dealer or distributor.
U N I Q U E U G P 6 F evaporator tubing. This will slow the circulation of hydrogen and ammonia gas, or in severe cases, completely block it, resulting in a loss of cooling. Warranty will not cover recharge/rebuild if caused by not running the freezer level. This freezer operates LP Gas (Propane), 110V (Electricity) Note: After changing an LP tank, or after a long shut off period, the gas line is likely to be filled with air.
U N I Q U E U G P 6 F 110V Operation 1. Ensure the electrical cord is plugged into a grounded outlet 2. Turn the selector switch G to AC position, AC power indicator F will illuminate 3. Turn the thermostat knob E to maximum setting, #4. 4. Adjust the thermostat knob to desired temperature setting after 8 or more hours of operation. Figure#1 CONTROLS – See Fig 1.
U N I Q U E U G P 6 F appliance drops below 60F (15.5 C) the freezer will get colder inside and could freeze the product inside. How to Use the Freezer FROZEN FOOD STORAGE COMPARTMENT This compartment is not designed for deep or quick freezing of food. Meat or fish, whether raw or prepared, can be stored in the frozen food storage compartment provided they are pre-cooled in the freezer. To prevent food from drying out, keep it in covered dishes, containers, plastic bags or wrapped in aluminum foil.
U N I Q U E U G P 3 Chapter 6 F Maintenance & Service The user should be aware of service that must be done on a regular schedule to keep the freezer operating properly. Installation must be by a licensed gas fitter in accordance with local codes or must comply with Propane Installation Code B149.2 (latest edition) Keep appliance area clear and free from combustible materials, gasoline and other liquids with flammable vapors.
U N I Q U E U G P 6 F Check all connectors in the complete freezer LP gas system for gas leaks. The LP gas supply must be turned on. Apply a non-corrosive bubble solution to all LP connections. The appearance of bubbles indicates a leak and should be repaired immediately by a qualified serviceman. WARNING – DO NOT USE FLAME TO CHECK FOR GAS LEAKS PROCEDURE FOR CLEANING THE COOLING SYSTEM FLUE WARNING: Carbon Monoxide can be hazardous to your health.
U N I Q U E U G P 6 F 3. Check that the spark is created by pressing the electronic ignition button on the control panel. 4. Before removing burner orifice, clean burner area of any soot, scale or dirt Remove the orifice and soak it in alcohol (isopropyl alcohol or thinners) and blow it out with compressed air. Do not use thin objects to either clean or unblock the injector. Re-install and tighten burner orifice. 5.
U N I Q U E U G P 6 F WARNING – Button (D) Fig#1, page 7, must be manually depressed to allow gas pressure to flow to the burner orifice. Be sure to apply the leak check solution before depressing this button. DO NOT allow any open flame, sparks, smoking, etc. in the area of the test. DO NOT depress (D) for over 30 seconds.
U N I Q U E U G P 4 Chapter 6 F TROUBLESHOOTING INSTRUCTIONS & SUGGESTED SPARE PARTS TO KEEP ON HAND FREEZER DOES NOT COOL, CHECK LIKELY CAUSES: 1. Burner orifice clogged. Clean. See section MAINTENANCE & SERVICE, CHAPTER 3 2. Check to ensure freezer is level – (left to right and front to back) 3. Restriction on air flow across cooling unit. 4. Heavy frost build up on inside of freezer. Defrost. 5. Flue baffle not inserted properly in flue tube. 6. Improperly set thermostat.
U N I Q U E U G P 6 F Suggested Spare Parts The following is a list of commonly used parts which are available: Burner orifice Electronic ignition lead wire Thermocouple Contact your dealer or an authorized service center for parts and repairs as needed. Quote Model & Serial # - See CSA rating/serial plate at the side of your freezer.
U N I Q U E U G P 5 Chapter 6 F Food Storage Ideas & Cleaning FROZEN FOOD STORAGE The freezer compartment should be kept at 8.6°F (-13°C) at a 77°F (25°C) room ambient A freezer operates most efficiently when it is slowly loaded to 2/3 full. PACKAGING FOODS FOR FREEZING To minimize dehydration and quality deterioration, use aluminium foil, freezer wrap, freezer bags or airtight containers. Force as much air out of the packages as possible and seal them tightly.
U N I Q U E U G P 6 F brushes, abrasive cleaners or strong alkaline solutions on any surface. Do not wash any removable parts in a dishwasher. NOTES: Do not use razor blades or other sharp instruments, which can scratch the appliance surface when removing adhesive labels. Any glue left from tape or labels can be removed with a mixture of warm water and mild detergent, or, touch the glue residue with the sticky side of tape you have already removed. Do not remove the certification/serial plate.
U N I Q U E U G P 6 Chapter 6 F Wiring Diagram 17
U N I Q U E U G P 7 Chapter 6 F Instructions for Model UGP-6F CM OWNER’S MANUAL Model 9RV-SSO Carbon Monoxide Alarm for Appliance Safety Shutoff ATTENTION: PLEASE READ, FOLLOW AND SAVE! (See Additional Instruction Sheet for Safety Shutoff Connection) Dear New COSTAR 9RV-SSO Owner, Congratulations as you have taken steps to help insure the health and life safety of you and your family.
U N I Q U E U G P 6 F tasteless gas. It is a cumulative poison.
U N I Q U E U G P 6 F For Users in the United States, follow the protocol in steps 1 through 4 below: 1 2 3 4 Operate reset/silence button; Call your emergency services (____ - ______) [fire department or 911]; Immediately move to fresh air – outdoors or by an open door/window. Do a head count to check that all persons are accounted for.
U N I Q U E 3.0 U G P 6 F DEVELOPING YOUR OWN CO SAFETY PLAN This CO alarm can quickly alert you to the presence of CO — it cannot prevent toxic CO emissions. Please note that there are hazards against which CO detection may not be effective, such as gas leaks or explosions. The ultimate responsibility for protection against toxic CO fumes rests solely on you. Installing CO detectors is just the first step in protecting your family from toxic CO poisoning.
U N I Q U E U G P 6 F 4.3 This CO alarm may not provide early warning for occupants if it is placed outside of the house, such as on outside porches. 4.4 When properly located, installed, and maintained, this CO alarm is designed to provide early warning of developing poisonous CO conditions at a reasonable cost. This alarm monitors the air, and when it senses CO, it activates its built-in alarm.
U N I Q U E U G P 6 F In very cold or very hot environments or in unheated buildings or outdoor rooms where the temperature can go below or above the operating range of the alarm. Temperature limits for proper operation are -20° F to 120° F ( 29° C to 49° C); Operating Humidity is 10 – 95% RH. Good ventilation is recommended when household cleaning supplies or similar contaminants are used. 5.4 CONDITIONS WHICH CAN RESULT IN TEMPORARY CO SITUATIONS: 5.4.
U N I Q U E U G P 6 F plate and twisting the alarm in the direction indicated by the "OFF" arrow on the alarm cover. Step A: Wall Alignment Step B: Alarm Activation Step C: Removal and Installation Figure 2: Installation Instructions 6.3 To insure aesthetic alignment of the alarm with the hallway or wall, the UP ↑ arrow on the mounting plate must be vertical when wall mounting: (See Step A in Figure 2) 6.4 As described in Figure 2, attach the mounting plate on the wall.
U N I Q U E U G P 6 F alarm cover (see step C) until it locks in place. 6.7 To make your carbon monoxide alarm tamper resistant, a locking pin has been provided in the bag with the screws and anchors. Using this pin will deter children and others from removing the alarm from the mounting plate. To use the pin insert it into the hole in the side of the alarm after the alarm has been installed on the mounting plate (See Figure 3).
U N I Q U E 8.0 U G P 6 F MAINTENANCE CLEANING YOUR ALARM: 8.1. Keep your CO alarms clean – use a damp (water only) cloth or vacuum. 8.2 To clean your alarm, remove it from the mounting bracket as outlined in Figure 2 Step C: Installation/Removal. IF TAMPER RESISTANT PIN HAS BEEN USED, REFER TO STEP 6.7 UNDER INSTALLATION INSTRUCTIONS FOR REMOVAL INSTRUCTIONS. (See Figure 3) 8.
U N I Q U E 9.3 U G P 6 F USE ONLY THE FOLLOWING 9 VOLT BATTERY FOR CO ALARM REPLACEMENT: Alkaline type: DURACELL: MN1604 WARNING: USE ONLY THE BATTERY SPECIFIED. USE OF DIFFERENT BATTERIES MAY HAVE A DETRIMENTAL EFFECT ON THE CO ALARM. THE CONSTANT EXPOSURES TO HIGH OR LOW TEMPERATURES OR HIGH HUMIDITY MAY REDUCE BATTERY LIFE. CHECK THE BATTERY MANUFACTURERS SPECIFICATIONS FOR PROPER OPERATING CONDITIONS. Note: Most batteries are not rated below -20°C or above 54°C 10.
U N I Q U E U G P 8 Chapter 6 F Parts Diagram and List UNIQUE UGP‐6F EXPLODED DIAGRAM 28
U N I Q U E U G P 6 F UNIQUE UGP 6F – Parts List No.
U N I Q U E No.
U N I Q U E No.
U N I Q U E U G P 6 F UNIQUE UGP-6F 3 YEAR LIMITED WARRANTY* Unique Gas Products Ltd. warrants that this UNIQUE freezer is free from defects in material and workmanship under normal usage and service under the following terms: 1. This Warranty is made only to the first purchaser (”original purchaser”) who acquires this freezer for his/her own use and will be honored by Unique Gas Products Ltd. and by the Seller. 2. Any part of this freezer returned to the Seller or Unique Gas Products Ltd.
U N I Q U E U G P 6 F LIMITED WARRANTY UNIQUE Model 9RV-SSO UNIQUE GAS PRODUCTS LTD offers you this limited warranty on your new carbon monoxide alarm, including all of its component parts except the battery. This limited warranty extends solely to the original enduser purchaser of this product, provided your purchase was made from an authorized vendor. Transfer or resale of this product will automatically terminate warranty coverage. UNIQUE GAS PRODUCTS LTD.
