Installation Guide

ManualsBrandsUS Stove ManualsHeating, Ventilation, and Air Conditioning3,000 sq. ft. Multi-Fuel Furnace Pellet Stove

USSC 1

Please read this entire manual before installation and use of this appliance. Failure to follow

these instructions could result in property damage, bodily injury, or even death.

Contact your local building or re ofcials about restrictions and installation inspection

requirements in your area.

SAVE THESE INSTRUCTIONS.

Owner’s Manual

UNITED STATES STOVE COMPANY • 227 INDUSTRIAL PARK ROAD • SOUTH PITTSBURG, TENNESSEE 37380 • WWW.USSTOVE.COM

FOR TECHNICAL ASSISTANCE: PHONE: (800) 750-2723 FAX: (423) 837-2109

UNITED STATES STOVE COMPANY

“Keeping North America Warm Since 1869”

MULTI-FUEL FURNACE MODEL 8500

Report #: 215-S-22b-2

TESTED &

LISTED BY

PORTLAND,

OREGON, USA

Part No.: 851976

Safety tested and listed to UL

391-2010, ASTM E1509-04,

and CSA-B366.1-11

ertied for installation in a

residential or mobile home as a

stand-alone or add-on

furnace

(ductwork connection only).

Approved for

US and Canadian use.

French version is available for download from the U. S. Stove website: http://www.Breckwell.com/

Summary of content (13 pages)

PAGE 1
UNITED STATES STOVE COMPANY “Keeping North America Warm Since 1869” MULTI-FUEL FURNACE MODEL 8500 Approved for US and Canadian use. Safety tested and listed to UL 391-2010, ASTM E1509-04, and CSA-B366.1-11 Certified for installation in a residential or mobile home as a stand-alone or add-on furnace (ductwork connection only). TESTED & LISTED BY PORTLAND, OREGON, USA Report #: 215-S-22b-2 Owner’s Manual  Please read this entire manual before installation and use of this appliance.
PAGE 2
Table of Contents Safety Precautions  IMPORTANT: Read this entire manual before installing and operating this product. Failure to do so may result in property damage, bodily injury, or even death. Proper installation of this furnace is crucial for safe and efficient operation.  Contact your local building officials to obtain a permit and information on any additional installation restrictions or inspection requirements in your area.  DO NOT throw this manual away.
PAGE 3
Specifications Fuel Considerations SHELLED CORN (Dry, preferably corn with 11% or less moisture content) Heating Specifications Input BTU/Hr1 50,000 to 105,000 BTU/hr. Heating Capacity2 1,200 - 2,800 sq. ft. Fuel Burn Rate 5.0 - 13.0 lbs./hr. 3 Burn Time (lowest setting) 70 hours continuous Hopper Capacity 320 lbs BTU output will vary depending on the quality and type of fuel. Use PFI listed fuels for the best results.
PAGE 4
Installation Installation Installation Options  Read this entire manual before you install and use your Multi-Fuel Furnace. Failure to follow instructions may result in property damage, bodily injury, or even death! (See specific installation details for clearances and other installation requirements) Certified for installation in a Residentail Type home in the USA and Canada. Also may be installed into a Manufactured or Mobile Home.
PAGE 5
Installation Installation Venting requirements Vent termination clearances:  Install vent at clearances specified by the vent manufacturer. A) Minimum 4-foot (1.22m) clearance below or beside any door or window that opens.  Do not connect the pellet vent to a vent serving any other appliance or furnace. B) Minimum 1-foot (0.3m) clearance above any door or window that opens.  Do not install a flue damper in the exhaust venting system of this unit.  INSPECT EXHAUST VENTING (joints, seals, etc.
PAGE 6
Installation Installation THROUGH THE WALL INSTALLATION (Recommended installation) To vent the unit through the wall, connect the pipe adapter to the exhaust motor adapter. If the exhaust adapter is at least 24-inches above ground level, a straight section of pellet vent pipe can be used through the wall. Your furnace dealer should be able to provide you with an installation kit, which will include a wall thimble that will allow the proper clearance through a combustible wall.
PAGE 7
Component Location Operation Control Panel Turning the furnace OFF/ON, as well as adjustments for the fuel feed rate and room fan speed are performed by pressing the appropriate button(s) on the control panel which is located on the lower left-hand side of your King furnace. CLEANOUT TOOL This unit can operate in either automatic or manual mode. Automatic mode has pre-set default settings. Pressing the “ON” button on the control panel will begin the start-up sequence for the furnace.
PAGE 8
Operation LIGHTING INSTRUCTIONS CAUTION: DO NOT USE CHEMICALS OR FLUIDS TO START THE FIRE HOT WHILE IN OPERATION. KEEP CHILDREN, CLOTHING AND FURNITURE AWAY. CONTACT MAY CAUSE SKIN BURNS. Before lighting your heater for the first time, make sure that all items are out of the hopper, ash pan and firebox area. Press the “On” button and allow your heater to run for at least 4 minutes, to check for proper operation. Once your heater is started, you will notice that the draft fan starts immediately.
PAGE 9
Maintenance Parts Diagram Interior Chambers 64 6 Open the Ash Cleanouts and scrap all ash into the ash pan. Open the damper and allow the ashes to fall into the ash pan. The damper may need to be slid in and out several times to clear any ash build-up. This may need to be done daily depending on fuel consumption. Be sure the ash cleanouts located on either side of the damper are completely closed before operating.
PAGE 10
Parts List Key Part No. Description Qty. Key Wiring Diagram Amendment Part No. Description Qty.
PAGE 11
Trouble Shooting Error Codes  Disconnect the power cord before performing any maintenance! NOTE: Turning the ON/OFF Switch to ”OFF” does not disconnect all power to the electrical components of the furnace. Below is a chart describing the Error Codes that might be displayed if an error occurs with your furnace.  Never try to repair or replace any part of the furnace unless instructions for doing so are given in this manual. All other work should be done by a trained technician.
PAGE 12
CUT HERE This manual will help you obtain efficient, dependable service from your KING OR ASHLEY, and enable you to order repair parts correctly.
PAGE 13
CUT HERE " Ê Fold Here Fold Here É Place Stamp Here " 24 CUT HERE United States Stove Company P.O.