Owner’s Manual GLASSLINED PUMP TANK 6DIHW\ ,QVWUXFWLRQV ,QVWDOODWLRQ 2SHUDWLRQ :DUUDQW\ ANSI/NSF 61 Annex G Thank You for purchasing a pump tank. Properly installed and maintained, it should give you years of trouble free service. If you should decide that you want the new water tank professionally installed, contact a local professional installer. ALL TECHNICAL AND WARRANTY QUESTIONS: SHOULD BE DIRECTED TO THE LOCAL DEALER FROM WHOM THE PUMP TANK WAS PURCHASED.
TABLE OF CONTENTS TABLE OF CONTENTS.................................................................................................................................................................................................. 2 SAFETY PRECAUTIONS............................................................................................................................................................................................... 2 SAFE INSTALLATION USE AND SERVICE...................................
SAFE INSTALLATION USE AND SERVICE The proper installation, use and servicing of this well tank is extremely important to your safety and the safety of others. Many safety-related messages and instructions have been provided in this manual and on your own well tank to warn you and others of a potential injury hazard. Read and obey all safety messages and instructions throughout this manual.
PREPARING FOR NEW INSTALLATION 5. The pump tank must be located in an area not subject to freezing. Failure to do so voids the warranty. 1. Read the “Safety Precautions” section, page 3 of this manual $ % safety rules, the pump tank will not operate properly. It could cause death, serious bodily injury or property damage.
LOCATING THE NEW PUMP TANK Facts to Consider About the Location to blow-up and result in death, serious bodily injury or property damage. Whether replacing an old pump tank or putting the pump tank in a new location, the following critical points must be observed. 3. This pump tank, as all pump tanks, will eventually leak. Do not install without adequate drainage provisions where water 1.
SUBMERSIBLE PUMP TYPICAL INSTALLATION FIGURE 2 OPTIONAL INSTALLATION (Shallow or Deep Well) RECOMMENDED FOR NEW INSTALLATIONS FIGURE 3 NOTES: ** OPTIONAL…MUST BE INSTALLED IF PUMP DOES NOT HAVE A PRESSURE SWITCH. ***OPTIONAL…MUST BE INSTALLED IF PUMP DOES NOT HAVE A CHECK VALVE.
Pressure Relief Valve " pressure relief valve, and the discharge pipe. " WARNING This pump tank is designed and intended for cold (ambient temperature) water storage at a maximum pressure of 125 PSIG, any use other than with cold water, or at a sustained or instantaneous pressure in excess of 125 PSIG is unsafe.
FIGURE 4 WATER LOGGED CONDITION 2. Connect a hose to the drain valve at the pump tank and terminate to an adequate drain. If draw-down (amount of water that comes out of the tank between ] and stops immediately when water is drawn from the pump tank, this means that the water has absorbed the air volume in the top of the tank. 3. Open a faucet near the pump tank and let the tank drain completely.
PERIODIC MAINTENANCE Pressure Relief Valve Operation by protecting the glass-lined tank from corrosion. Adverse water quality and water softening methods can increase the rate of anode rod depletion. Once the anode rod is depleted, the tank will start to corrode, eventually developing a leak. The pressure relief valve must be manually operated at least once a year. Failure to install and maintain a new properly listed pressure relief valve could result in serious personal injury, death or property damage.
!" #$%" $#& $&& "'' !" + %,$#/ REFER TO THE RATING PLATE ON THE WATER TANK. RESIDENTIAL PUMP TANK WARRANTY THIS WARRANTY IS APPLICABLE TO THE ORIGINAL OWNER ONLY. In accordance with the warranty terms and 5 YEAR LIMITED WARRANTY The “Company” warrants the pump tank in case of a " X] in the absence of a Bill of Sale verifying said date, from @ this pump tank.
% $ the owner should contact the company. 5. Replacements and/or repairs furnished under these warranties do not carry a new warranty, only the unexpired portion of the original warranty. IMPORTANT INFORMATION 6. In order to obtain service under these warranties you must promptly notify the installing contractor or dealer, giving the nature of the problem and the model and serial number of the pump tank.
