Material Safety Data Sheet

UTILITY MANUFACTURING CO., INC.
700 MAIN STREET, WESTBURY, NY 11590
[phone] - FAX # [phone]
DO-ALL+PLUS FURNACE/REFRACTORY/RETORT CEMENT
Page 1 30-1030
MATERIAL SAFETY DATA SHEET
FOR CHEMICAL EMERGENCY: Spill, Leak, Fire, Exposure, or Accident - Call CHEMTREC - Day or Night: 1-800-424-9300
THIS MSDS COMPLIES WITH 29 CFR 1910.1200 (HAZARD COMMUNICATION STANDARD) IMPORTANT: Read this MSDS
before handling & disposing of this product. Pass this information on to employees, customers and users of this product.
PRODUCT IDENTIFICATION
DOT Shipping name: CLEANING COMPOUNDS, NOI CAS NO.: MIXTURE
Chemical Family: SILICATES UN/NA#: N/R
DOT Hazard Class: N/R DATE OF ISSUE: 4/08
SECTION I - HAZARDOUS INGREDIENTS/EXPOSURE LIMITS
Hazardous Ingredients: CAS # TLV/PEL AGENCY TYPE SARA-313(% Range)
NONE
SECTION II - EMERGENCY AND FIRST AID PROCEDURES
EYE CONTACT: Move person away from exposure and into fresh air. If irritation or redness develops, flush eyes with clean water and
seek medical attention. For direct contact hold eyelids apart for at least 15 minutes. Seek medical attention.
SKIN CONTACT: Remove contaminated shoes and clothing and cleanse affected areas thoroughly by washing with mild soap and water.
If irritation persists seek medical attention.
INHALATION: (breathing) Not expected to be a hazard under normal operating conditions..
INGESTION: (swallowing) If swallowed, seek emergency medical attention. Do not give anything by mouth. .
SECTION III - HEALTH HAZARDS / ROUTES OF ENTRY
EYE CONTACT: One or more components of this material may be an eye irritant.
SKIN CONTACT: Continuous contact with this material may cause drying of skin. Chemical itself is an irritant or sensitizer.
SKIN ABSORPTION: Symptoms of toxicity are anticipated by this route .
INHALATION: (breathing) Not expected to be a hazard under normal operating conditions.
INGESTION: (swallowing) Ingestion of large quantities may cause the following: Irritation of digestive tract, signs of nervous system
depression, such as headache, drowsiness, dizziness, loss of coordination, fatigue, and nausea.
SECTION IV - SPECIAL PROTECTION INFORMATION
VENTILATION: If current ventilation practices are not adequate to maintain airborne concentrations below established exposure limits
(see section I), additional ventilation or exhaust systems may be required.
RESPIRATORY PROTECTION: The use of respiratory protection is advised when concentrates exceed the established exposure limits
(see Section I). Depending on the airborne concentration use a respirator or gas mask with appropriate cartridges or canisters
(NIOSH approved) or supplied air.
PROTECTIVE GLOVES: The use of gloves impermeable to the specific material handled is advised to prevent possible irritation.
EYE PROTECTION: Approved eye protection to safeguard against potential eye contact, irritation or injury is recommended.
SECTION V - REACTIVITY DATA
STABILITY: Stable
INCOMPATIBILITY: (materials to avoid) This product is incompatible with: Oxidizing agents, strong acids and bases
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition in the presence of air may yield carbon monoxide, carbon
dioxide.
HAZARDOUS POLYMERIZATION: Will not occur
SECTION VI - SPILL OR LEAK PROCEDURES
PRECAUTIONS IN CASE OF LEAK OR SPILL: Keep all sources of ignition and hot metal surfaces away from spill/release. Stay
upwind and away from spill/release. Isolate hazard area and limit entry to emergency crew only. Stop spill/release if it can be done
without risk. Wear appropriate protective equipment including respiratory protection as conditions warrant (see Section IV). Prevent
spilled material from entering sewers, storm drains, and natural waterways. Dike far ahead of spill for later recovery and disposal. Spilled
material may be absorbed by an appropriate absorbent. Notify fire authorities and appropriate federal, state, and local agencies. If
spill/release is excess of EPA reportable quantity, immediately notify the National Response Center. Phone [phone]
WASTE DISPOSAL METHOD: Dispose of product in accordance with local, county, state, and federal regulations.