Installation Manual

Instructions for installation and servicing ecoTEC plus 0020020828_072
1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
1.1 Notes on the documentation. . . . . . . . . . . . . . . . 3
1.1.1 Other instructions supplied with this appliance. . . 3
1.1.3 Safety instructions and symbols . . . . . . . . . . . . . 3
1.2 Validity of the manual . . . . . . . . . . . . . . . . . . . . . . 4
1.3 ecoTEC plus boilers . . . . . . . . . . . . . . . . . . . . . . . . 4
1.4 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
1.5 General information . . . . . . . . . . . . . . . . . . . . . . . 4
1.5.1 Gas category . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
1.5.2 Gas safety (installation and use) regulations . . 4
1.5.3 Gas testing and certification . . . . . . . . . . . . . . . . 4
1.5.4 Control of substances hazardous to health . . . 5
1.5.5 Insulation pads . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1.5.6 Spare parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1.5.7 Manual handling guidance . . . . . . . . . . . . . . . . . . 5
1.5.8 Gas leak or fault . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1.5.9 Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1.5.10 Sheet metal parts . . . . . . . . . . . . . . . . . . . . . . . . . 5
1.5.11 Sealed components . . . . . . . . . . . . . . . . . . . . . . . . 5
1.5.12 Electrical supply failure . . . . . . . . . . . . . . . . . . . . 5
1.5.13 Protection against freezing . . . . . . . . . . . . . . . . . 5
1.5.14 Boilers installed in a compartment or
cupboard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1.5.15 Boiler casing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
1.5.16 Condensate drain . . . . . . . . . . . . . . . . . . . . . . . . . . 6
1.5.17 Pluming from flue terminal . . . . . . . . . . . . . . . . . 6
1.5.18 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
1.5.19 Maintenance and servicing . . . . . . . . . . . . . . . . . 6
1.5.20 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
1.6 Statutory requirements . . . . . . . . . . . . . . . . . . . . 6
1.7 Regulations, rules and guidelines. . . . . . . . . . . . 6
1.8 CE label . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
1.9 Benchmark . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
1.10 Gas council numbers . . . . . . . . . . . . . . . . . . . . . . . 7
2 Boiler specifications . . . . . . . . . . . . . . . . . . . . 8
2.1 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
2.1.2 Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
2.1.3 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
3 General requirements. . . . . . . . . . . . . . . . . . . . . 10
3.1 Preliminary remarks . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
3.2 Related documents . . . . . . . . . . . . . . . . . . . . . . . . 10
3.3 Installation site . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
3.4 Gas supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
3.5 Flue options . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
3.5.1 Flue termination . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
3.5.2 Internal flue installation . . . . . . . . . . . . . . . . . . . . 13
3.6 Air supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
3.7 Cupboard or compartment ventilation . . . . . . . 13
3.8 Domestic hot water cylinder . . . . . . . . . . . . . . . . 13
3.8.1 Unvented hot water cylinder . . . . . . . . . . . . . . . . 13
3.9 Condensate drain . . . . . . . . . . . . . . . . . . . . . . . . . . 13
3.10 Heating system controls . . . . . . . . . . . . . . . . . . . . 13
3.11 Draining tap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
3.12 Safety valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
3.13 Bypass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
3.14 Pump specification . . . . . . . . . . . . . . . . . . . . . . . . 13
3.15 Cleanser and inhibitor . . . . . . . . . . . . . . . . . . . . . . 14
3.16 Water pressure loss . . . . . . . . . . . . . . . . . . . . . . . . 15
3.17 Open vented heating system . . . . . . . . . . . . . . . . 16
3.18 Sealed water systems . . . . . . . . . . . . . . . . . . . . . . 16
3.18.1 Safety valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
3.18.2 Expansion vessel . . . . . . . . . . . . . . . . . . . . . . . . . . 16
3.18.3 Pressure gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
3.18.4 Water make up . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
3.18.5 Filling a sealed water system . . . . . . . . . . . . . . . 17
4 Boiler installation sequence . . . . . . . . . . . . . . 18
4.1 Boiler location . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
4.1.1 Sheet metal parts . . . . . . . . . . . . . . . . . . . . . . . . . 18
4.1.2 Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
4.1.3 Timber frame buildings . . . . . . . . . . . . . . . . . . . . . 18
4.1.4 Contents included with delivery . . . . . . . . . . . . . 18
4.2 Flue exit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
4.2.1 Other flue options . . . . . . . . . . . . . . . . . . . . . . . . . 19
4.3 Fitting the boiler hanging bracket . . . . . . . . . . . 19
4.3.1 Boiler fixing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
4.3.2 Removing the front casing . . . . . . . . . . . . . . . . . . 19
4.3.3 Gas connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
4.3.4 Water connections . . . . . . . . . . . . . . . . . . . . . . . . . 20
4.3.5 Condensate trap and siphonic drain
connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
4.3.6 Installing the flue system . . . . . . . . . . . . . . . . . . . 21
4.4 Electrical connections . . . . . . . . . . . . . . . . . . . . . . 21
4.4.1 Connection to the main supply . . . . . . . . . . . . . . 21
4.4.2 Wiring system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
4.4.3 Electrical board layout . . . . . . . . . . . . . . . . . . . . . 23
4.4.4 Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
4.4.5 External electrical controls . . . . . . . . . . . . . . . . . 25
4.4.6 Connection details for external switches
and boiler terminal strip. . . . . . . . . . . . . . . . . . . . 26
4.4.7 Vaillant optional plug in timer
accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
4.4.8 Connection details using the VR 65
and VR 61 control centre . . . . . . . . . . . . . . . . . . . 26
5 Commissioning (Part I) . . . . . . . . . . . . . . . . . . 27
5.1 Preliminaries - all systems . . . . . . . . . . . . . . . . . . 27
5.1.1 Gas supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
5.1.2 Gas pressure statement - Natural gas . . . . . . . . 28
5.1.3 Initial Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
5.1.4 Ignition problems . . . . . . . . . . . . . . . . . . . . . . . . . . 29
5.1.5 Flue problems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
5.1.6 Testing - gas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
6 Natural gas to LPG conversion . . . . . . . . . . . 30
7 Functional checks commissioning (part II). . 31
7.1 Functional checks . . . . . . . . . . . . . . . . . . . . . . . . . 31
7.2 Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
7.3 Domestic hot water (If optional VR65,
uniSTOR cylinder and Vaillant control
are installed) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
7.4 Pump exercise programme . . . . . . . . . . . . . . . . . 31
7.5 Final flush of the heating system (hot) . . . . . . . 31
7.6 Handing over to the user . . . . . . . . . . . . . . . . . . . 32
Contents