VCW-04 Commercial Cleaner User Guide v5.qxd:UG COMMERCIAL 27/1/09 16:52 Page 1 Vax Careline 0870 1129 145 (UK only) VCW-04 Vax model number: VCW-04 vaxcommercial.co.uk instruction manual Commercial carpet cleaner Please read carefully before using this cleaner. Always fully extend the mains cable before use. Retain for future reference.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 2 vaxcommercial.co.uk 1. Diagram VCW-04 1 24 2 13 2 24 3 22 16 17 15 18 4 14 19 13 5 6 12 18 11 10 21 7 9 20 8 Fig.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 3 Vax Commercial Careline 0870 1129 145 2. Safety Information NOTE: Carpets should be dry vacuumed thoroughly before washing. FOR COMMERCIAL USE ONLY. NOTE: The unit must be unplugged from the mains socket outlet after use, and before cleaning, servicing or maintaining the unit. When using the vacuum cleaner, basic safety precautions should always be observed, including the following: 1.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 4 vaxcommercial.co.uk 3. Assembly Attach upper handle Remove clean solution tank (upper tank) (Fig.3/1). Fig.3/7 Fig.3/4 When handle sections are completely together, squeeze trigger and depress Clean Surge button on upper handle.You will hear a “snap” when the trigger rod is in place (Fig.3/5). Fig.3/1 With cord hook to back of carpet cleaning machine, push upper handle down onto lower handle (Fig.3/2).
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 5 Vax Commercial Careline 0870 1129 145 Tool holder A Solution tube Converter Fig.3/10 Fig.3/7 Replace clean solution tank (upper tank) by positioning bottom first. Wrap hose around hook on upper handle . Press hose into clips on upper hose holder (fig3/11). Press on tank handle to snap top of tank into place (Fig 3/8). Upper handle Upper hose holder Upper hose holder Fig.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 6 vaxcommercial.co.uk Wash tool ! To store wash tool, open tool door, place nozzle in bracket and fit it securely into position. To remove, reverse this ! procedure (Fig3/14). 4.! Operation ! IMPORTANT: Operate carpet cleaning machine only at voltage specified on data plate on back of cleaner. On/Off Pedal Wash tool Step on pedal A to turn carpet cleaner on. Step on pedal again to turn carpet cleaner off.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 7 Vax Commercial Careline 0870 1129 145 Automatic “shut off” When the dirty water tank (lower tank) is full the automatic shutoff mechanism will shut off the carpet cleaner suction A (suction will be noticeably reduced). At that time the yellow float disk will rise to the top of the dirty water tank lid. The carpet cleaner will no longer pick up dirty solution and the motor sound will become noticeably higher in pitch.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 8 vaxcommercial.co.uk Carry tank to a sink. Rotate tank cap counterclockwise and lift up to remove cap (Fig4/9). Pour detergent into tank. Fill tank to fill line (4L approx) with hot tap water. To assure proper performance, use only Vax cleaning detergent (Fig4/11). Fill line Fig.4/1 Fig.4/9 Turn cap upside down to serve as a measuring cup (Fig4/10). Fig.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 9 Vax Commercial Careline 0870 1129 145 Position bottom of tank into unit and press on tank handle to snap tank into place (Fig4/14). Rear of tank Fig.4/16 The lid replaces in a hinge-like manner. Position the front of lid under tabs on front of tank. Rotate lid down onto tank. Fig.4/14 Dirty water tank (lower tank) The dirty water tank holds the dirty solution that is picked up from the carpet.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 10 vaxcommercial.co.uk 5. Cleaning Before you begin cleaning Vacuum thoroughly - For carpet, use a vacuum cleaner with a brushbar for best results. Vacuum upholstery with a vacuum cleaner with cleaning tool attachments. Empty tanks, rinse with clear water and let air dry. Rinse the solution tank cap and dirty water tank lid and let air dry. Remove debris from dirty water tank filter and rinse with clean water (Fig.5/1).
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 11 Vax Commercial Careline 0870 1129 145 Fig.5/2 Fig.5/3 To avoid walking on damp carpet, start at the end of the room farthest from the door or path to sink where tanks will be emptied and filled. Step on handle release pedal and lower handle to operating position; turn carpet cleaner ON. Picking up spills Squeeze trigger to release cleaning solution and slowly push carpet cleaner forward (equals one wet stroke).
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 12 vaxcommercial.co.uk How to attach hose NOTE: Disconnect carpet cleaner from electrical outlet. To prevent possible leaking, remove clean solution tank by pressing down on tank handle and pulling forward; set tank aside (do not set tank on furniture). Converter Remove hose from storage rack (Fig 5/7). Handle Fig.5/10 NOTE: Before connecting tube to cleaner, make sure black tabs are extended by pulling tan collar toward tube.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 13 Vax Commercial Careline 0870 1129 145 Tabs Fig.5/12 Attach tool to connector end of hose by sliding it onto connector until the tab locks it securely. Fig.5/14 Occasionally, debris may become lodged inside of the hose at the converter end. Using your thumb, push forward and up on the latch to remove tool as shown (Fig 5/13). To clean out the hose, lift bottom of converter clip with a screwdriver and remove clip.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 14 vaxcommercial.co.uk NOTE: Slide panel down until it snaps firmly in place (Fig 5/17). Pull tool slowly over carpet without pressing trigger (dry stroke) (Fig 5/19). Front panel Fig.5/17 Cleaning carpeted stairs Read “Before you begin cleaning” instructions on page 10. Place handle in upright position. NOTE: Agitator brushes will not rotate while handle is in upright position.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 15 Vax Commercial Careline 0870 1129 145 Dry hands and plug carpet cleaner into a suitable power outlet (Fig 5/20) instructions on page 10 and “After using tool” instructions on page 13. Fig.5/20 Turn carpet cleaner on. If necessary, refer to “Before using tool” section to remove air from system. Gently press the tool onto the fabric. Press the trigger and slowly pull the nozzle over the fabric.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 16 vaxcommercial.co.uk 6. Maintenance Removable brushes Your carpet cleaner is equipped with removable brushes for easy cleaning. To remove brushes Disconnect cleaner from electrical outlet. To replace brushes Align posts on both ends of brush assembly with slots (D) in cleaner housing. Make sure that square post also aligns with square hole. Turn brushes slightly until post fits easily into hole (Fig 6/4).
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 17 Vax Commercial Careline 0870 1129 145 7. Storage Before storing: Empty solution tank and rinse thoroughly with clean water. Replace empty solution tank and turn carpet cleaner ON. Squeeze trigger and push carpet cleaner forward and back several times to expel any solution remaining in the carpet cleaner’s system. (Do not use carpet cleaner on wood floors.) Empty recovery tank and rinse thoroughly with clean water.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 18 www.vaxcommercial.co.uk ! ! 9.! UK Service & Help ! Vax Commercial Careline 0870 1129 145 Monday-Friday 8.30am to 6.30pm Saturday & Sunday 9.00am to 5.00pm An answerphone is available outside of these hours. Any queries or concerns about using the Vax, please call the Vax Commercial Careline. Calls are charged at the UK national rate. Please make a note of the serial number and model number of the carpet cleaner before calling.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 19 Vax Commercial Careline 0870 1129 145 This page has been left intentionally blank.
VCW-04 Commercial Cleaner User Guide v5.qxd:UG 27/1/09 16:52 Page 20 --- COMMERCIAL EEC STATEMENT OF COMPLIANCE Manufacturer/EEC importer: Vax Limited, hereby on our own responsibility, declare that the Vax Commercial VCW-04 carpet cleaner is manufactured in compliance with the following Directives: Safety: 2006/95/EC Low Voltage Directive EMC: 2004/108/EC Electromagnetic Compatibility Directive Waste electrical products should not be disposed of with household waste.
