Technical data

92
1 Engine will not crank
Possible fault Remedy
Faulty or discharged battery (too
low voltage ) .
Check / recharge battery and
check engine alternator and/or
battery charger.
Fuse blown. Replace.
Loose or corroded connections
in starting circuit.
Clean and tighten connections.
Wrong engine electric mass con-
nection.
Repair.
Starter relay is not engaged due
to a voltage too low; caused by
a very long intermediate cable
from engine to control panel.
Install an auxiliary starter relay
Faulty starter-switch or faulty
starter-relay.
Check / replace.
Faulty starter-motor or pinion
does not engage.
Check / replace starter-motor.
Seized components. Repair.
Control lever not in neutral. Put operating lever in neutral.
Water in the cylinder . Check / Repair.
2 Engine cranks but will not start, no smoke from exhaust
Possible fault Remedy
(Nearly) Empty fuel tank. Rell.
Fuel stop valve closed. Open.
Fuel pre-lter clogged . Clean /replace
Fuel lter clogged with water
and/or contamination.
Check or replace.
Vent line of fuel supply tank
clogged.
Check / clean.
Faulty injector/injection pump.. Check, replace if required.
Leaking fuel supply line or fuel
injection line.
Check / replace.
Air in fuel system. Check and bleed.
Exhaust restricted. Check.
9 Troubleshooting
Fault nding table