90C COMPRESSOR KIT PART NO. 00090 92C COMPRESSOR KIT PART NO. 00092 95C COMPRESSOR KIT 12V PART NO. 00095 95C COMPRESSOR KIT 24V PART NO. 02495 90C 92C 95C IMPORTANT: It is essential that you and any other operator of this product read and understand the contents of this manual before installing and using this product.
90C - 92C - 95C Air Compressor Kit IMPORTANT SAFETY INSTRUCTIONS CAUTION - To reduce risk of electrical shock or electrocution: - Do not disassemble. Do not attempt repairs or modifications. Refer to qualified service agencies for all service and repairs. - Do not use this product in an area where it can fall or be pulled into water or other liquid. - Do not reach for this product if it has fallen into liquid.
90C - 92C - 95C Air Compressor Kit MOUNTING AND WIRING 1. Disconnect ground cable from vehicle’s battery. 2. Temporarily position the air compressor in the location where it will be mounted. 3. Route ground wire to the negative post of the battery or to an appropriate grounding point and cut ground wire to length as needed. 4. Mount air compressor with the four sets of 13/64” (5 mm) bolts, nuts, washers, and locking washers provided. Use of thread sealant recommended. 5.
90C - 92C - 95C Air Compressor Kit OPERATING INSTRUCTIONS 1. IMPORTANT: Always operate the compressor at or below the MAXIMUM PRESSURE RATING of the compressor. Please refer to Application & Specifications Sections of this manual for details. 2. Always observe the MAXIMUM DUTY CYCLE of the air compressor. Refer to Compressor Applications and Specifications Sections of this manual for details. Operation exceeding maximum pressure ratings and/or duty cycle will result in damage to the air compressor. 3.
90C - 92C - 95C Air Compressor Kit SPECIFICATIONS • Part No. 00090 / 90C Air Compressor Motor Voltage: Max. Current Consumption: Motor Type: Max. Working Pressure: Max. Duty Cycle (@ 72°F & 100 PSI): Max. Ambient Temperature: Min. Ambient Temperature: Dimensions: Net Weight: 12 Volts 11 Amps Permanent Magnetic 120 PSI 9% 158°F -40°F 5.9”L x 2.1”W x 4.5H” 2.4 Lbs. • Part No. 00092 / 92C Air Compressor Motor Voltage: Max. Current Consumption: Motor Type: Max. Working Pressure: Max.
90C - 92C - 95C Air Compressor Kit COMPRESSOR APPLICATION GUIDE To ensure that you get the highest level of satisfaction from your compressor performance, refer to information below: VIAIR COMPRESSOR REFERENCE CHART COMPRESSOR SERIES DUTY CYCLE (100 PSI @ 72°F) 090 SERIES 9% 092 SERIES 9% 095 SERIES 9% 097 SERIES 10% 098 SERIES 10% 100 SERIES 15% 250 IG SERIES 100% 275 SERIES 25% 280 SERIES 30% 325 SERIES 33% 330 IG SERIES 100% 350 SERIES 100% 380 SERIES 100% *55% 400 SERIES 33% 420 SERIES 33% 444 SERIE
90C - 92C - 95C Air Compressor Kit TROUBLESHOOTING GUIDE: PROBLEM: POSSIBLE CAUSE(S) CORRECTIVE ACTION Tank pressure drops when 1. Loose drain cock compressor(s) shut off 2. Check valve leaking 3. Loose connections 1. Tighten drain cock 2. Replace check valve or compressor 3. Check all connections with soap and water solution and tighten Compressor runs continuously and air flow lower than normal 1. Excessive air usage 2. Loose connections 3. Worn piston ring or inlet valve. 4.
90C - 92C - 95C Air Compressor Kit AMERICAN WIRE GAUGE GUIDE 12-VOLT: AMERICAN WIRE GAUGE GUIDE 24-VOLT: Amp Draw Length of wire from battery to compressor (in feet) Amp Draw 5 10 15 20 25 30 40 50 60 5 16 16 16 14 14 12 12 10 10 5 10 15 20 25 30 40 50 60 10 16 14 12 10 10 10 8 6 6 15 16 12 10 10 8 8 6 6 4 20 14 10 10 8 6 6 6 4 4 Length of wire from battery to compressor (in feet) 5 16 16 16 16 16 16 14 14 12 10 16 16 16 14 12 12 10 10 10 15 16 16 14 12 12 10 10 8 8 20 16 14 12 10 10 10