MODEL NUMBER: 45043- 450P-A AUTOMATIC PORTABLE COMPRESSOR IMPORTANT: It is essential that you and any other operator of the product read and understand the contents of this manual before installing and using this product.
SAFETY INSTRUCTIONS CAUTION - To reduce risk of electrical shock: • • • • Do not disassemble. Do not attempt repairs or modifications. Refer to qualified service agencies for all service and repairs. Do not use this product in an area where it can fall or be pulled into water or other liquids. Do not reach for this product if it has fallen into liquid. Use this compressor with 12-volt DC systems only. This product should never be left unattended during use.
OPERATING INSTRUCTIONS Please read and follow the operating instructions carefully to assure that you will enjoy the convenience and best use out of your air compressor. IMPORTANT: 1. Always operate the compressor AT OR BELOW THE MAXIMUM PRESSURE RATING of the compressor. Refer to Specifications section of this manual. 2. Always OBSERVE THE MAXIMUM DUTY CYCLE of the air compressor. Refer to Specifications section of this manual for details.
TIRE INFLATION & DEFLATION IMPORTANT: Before attaching air compressor power clamps to your vehicle’s battery terminals, check to make sure that the ON\/OFF switch of your compressor is in the OFF position. Attach the Positive (+) battery clamp (Red) to the Positive terminal of the battery and the Negative (-) battery clamp (Black) to the Negative terminal of the battery. Always keep your vehicle’s engine running while operating compressor to avoid draining your vehicle’s battery.
Tire Inflation Gun OPERATION INSTRUCTIONS: This air compressor comes with 1/4” quick connect stud. An extension coil hose and a tire inflation gun are also included with your compressor. Each end of the extension coil hose is equipped with a 1/4” quick connect coupler. The tire inflation gun comes with a 1/4” quick connect stud, pressure gauge, rubber hose, bleeder valve and tire chuck.
SAFETY PRECAUTIONS 1. 2. 3. 4. 5. Always inflate tires to manufacturer’s recommended tire pressures. Exercise extreme caution when driving with aired-down tires. Re-inflate tires before high-speed roadway travel. Never exceed 20 M.P.H. when driving with partiallyinflated tires. Never make sharp turns while driving with reduced tire pressure. Re-inflate tires before high speed traveling on roadways. Use heat-resistant, minimum 200 PSI-rated working pressure extension hose.
TROUBLESHOOTING CHART PROBLEM POSSIBLE CAUSE(S) Compressor will not run 1. No power, or switch in OFF position 2. Blown fuse 3. Motor overheats CORRECTIVE ACTION 1. Make sure compressor switch is ON 2. Disconnect compressor from power source, replace fuse. (Refer to Specifications section for correct fuse) 3. Let compressor cool off for about 30 minutes for thermal overload switch reset Thermal Overload Protector cuts out repeatedly 1. Lack of proper ventilation/ambient temperature too high 2.
LIMITED WARRANTY VIAIR Corporation warrants this product, when properly installed and under normal conditions of use, to be free from defects in workmanship and materials for a period of one year from provided date of purchase. To receive a replacement or for repairs, return the complete unit to retailer from whom it was purchased along with proof of purchase. Returns should be made within the time period and conditions of the retailer’s policy for exchanges.