Use & Care Manual Viking Range, LLC 111 Front Street Greenwood, Mississippi 38930 USA (662) 455-1200 For product information, call 1-888-(845-4641) or visit our web site at vikingrange.com in the US or 15”W. Undercounter/Freestanding Nugget Ice Machine brigade.
Congratulations Table of Contents We hope you will enjoy and appreciate the care and attention we have put into every detail of your new, state-of-the-art ice machine. Your new appliance is designed to offer years of reliable service. This Use and Care Guide will provide you with the information you need to become familiar with your ice machine’s care and operation. Your complete satisfaction is our ultimate goal.
Important - Please read and follow • Before beginning, please read these instructions completely and carefully. • DO NOT remove permanently affixed labels, warnings, or plates from the product. This may void the warranty. • Please observe all local and national codes and ordinances. • Please ensure that this product is properly grounded. • The installer should leave these instructions with the consumer who should retain for local inspector’s use and for future reference.
Using Your Ice Machine (con’t) Using Your Ice Machine (con’t) Although the machine will function within the listed ranges, it works best at water temperatures between 50 and 60 and air temperatures between 60 and 80. Water Supply: Avoid a long run of hose or tubing exposed to the sun. Plastic water supply tubing should be rated for potable water and include UV protection. Copper tubing is recommended.
Maintenance Care and Cleaning We strongly recommend regular maintenance of this ice machine. During normal operation mineral scale that is in the water supply will gradually build up on the ice making surfaces. That build up can cause excessive loading of the ice making system, which can cause premature failure. Regular removal of the mineral scale will lengthen the product’s life.
Care and Cleaning (con’t) Care and Cleaning (con’t) How to remove scale from the ice making system. Cleaning this machine involves adding a solution of scale remover and water to the ice machine and continuing to add it as it makes ice. The scale remover must be diluted to the correct ratio. A squirt bottle will make adding the scale remover much easier when the unit is built in. If not built in, remove the top panel for reservoir access. Recommended tools: Rubber gloves, squirt bottle & scale remover. .
Care and Cleaning (con’t) Care and Cleaning (con’t) 6. Locate blue float valve on/off lever. Move lever up about half way to shut water off. 7. Locate drain plug and pull the drain plug out to drain the reservoir and evaporator. When draining is complete, return the plug to its original position. 8. Mix a solution of cleaner with water: 1.25 ounces of cleaner with 16 oz of warm water. 11. Press and HOLD both the Clean-Reset and On/Off buttons for 5 seconds. The Time to Clean light will blink on and off.
Care and Cleaning (con’t) After 40 minutes the ice machine and all the control panel lights will shut off. 13. Pull the drain plug again to drain the system, then replace it. 14. Return the reservoir cover to its original position. 15. Return the upper back wall of the bin to its original position and secure it with the original screws. Push in to snap it into place. 16. Pour a gallon of hot (95oF. – 115oF.
Service Information Warranty If service is required after checking the troubleshooting guide, call your dealer or authorized service agency. The name of the authorized service agency can be obtained from the dealer or distributor in your area.
Warranty WHAT IS NOT COVERED BY THIS WARRANTY: This warranty shall not apply to damage resulting from abuse, failure to provide reasonable and necessary maintenance, accident, delivery, negligence, natural disaster, loss of electrical power to the product for any reason, alteration, outdoor use, improper installation, improper operation, or repair or service of the product by anyone other than an authorized Viking Range, LLC service agency or representative. This warranty does not apply to commercial usage.