Viking Use/Installation Guide Outdoor Built-In TruSearTM Infrared Griller Viking Range Corporation 111 Front Street Greenwood, Mississippi 38930 USA
IMPORTANT: PLEASE READ AND FOLLOW DANGER * Before beginning, please read these instructions completely and carefully. • Do not remove permanently affixed labels, warnings, or plates from product. This may void the warranty • Please observe all local and national codes and ordinances. • The installer should leave these instructions with the consumer who should retain for local inspector’s use and for future reference If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3.
BASIC SPECIFICATIONS Description Overall Width Overall Depth To end of landing ledge To end of knobs Overall Height Cutout Width Cutout Depth Cutout Height Gas Requirements Infrared Burner Rating Approximate Shipping Weight VGIB242T 26 1/4” (66.7 cm) VGIB151T 15-5/16” (38.9 cm) 31-9/16” (80.2 cm) 32-5/8” (82.9 cm) 10 1/2” (26.3 cm) 14” (35.6 cm) Natural: LP/Propane: 55 lbs. (24.8 kg) 24 3/4” (62.9 cm) 27-1/2” (69.9 cm) 10-1/4” (26.0 cm) standard residential 1/2” (1.3 cm) ID gas service line.
NATURAL FIXED PIPING CONNECTION Connection: Operating Pressure: Supply Pressure: Standard Residential 1/2” ID gas service line - 1/2” NPT male with 1/2” flare adapter. 4.0” W.C.P. Nat. 6” to 14” W.C.P. Nat. If in excess of 14” W.C.P., a step-down regulator is required. Check with your local gas utility company or with local codes for instructions on installing gas supply lines. Be sure to check on type and size of run and how deep to bury the lines.
LP/PROPANE FIXED PIPING CONNECTION Connection: Operating Pressure: Supply Pressure: Standard Residential 1/2” ID gas service line - 1/2” NPT male with 3/8” flare adapter. 10.0” W.C.P. LP/Propane 11” to 14” W.C.P. LP/Propane If in excess of 14” W.C.P., a step-down regulator is required. Check with your local gas utility company or with local codes for instructions on installing gas supply lines. Be sure to check on type and size of run and how deep to bury the lines.
LP/PROPANE TANK CONNECTION Outdoor side burners orificed for use with LP/Propane gas come equipped with a high capacity hose/regulator assembly for connection to a standard 20 lb. LP/Propane cylinder equipped with a Type 1, QCC-1 connector. Hose assembly must comply with Elastomeric Composite Hose and Couplings for Conducting Propane and Natural Gas, CAN/CGA-8.1 standard or the Theromplastic Hose and Hose Couplings for Conducting Propane and Natural Gas CAN1-8.
LEAK TESTING Although all gas connections on the grill are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation due to possible mishandling in shipment or excessive pressure unknowingly being applied to the unit. Periodically check the whole system for leaks, or immediately check if the smell of gas is detected. 1. Do not smoke while leak testing. Extinguish all flames. 2. Never leak test with an open flame. 3.
INSTALLATION PROCEDURES FOR BUILT-IN INSTALLATION 1. A minimum of 6” (15.2 cm) from the sides must be maintained from the side of the burner above the cooking surface to adjacent vertical combustible surfaces. The unit is not to be located under overhead unprotected combustible surfaces. 2. It is desirable to allow at least 6” side clearance to non-combustible surfaces above the cooking surface for counter space. 3.
BUILT-IN CLEARANCE DIMENSIONS 15” W. FRONT VIEW 24” W. FRONT VIEW Min. 6” Min. 6” (15.2 cm) to combustible surfaces (15.2 cm) to combustible surfaces 15 5/16” (38.9 cm) 26 1/4”” (66.7 cm) SIDE VIEW 11 3/8” (28.9 cm) PERFORMANCE CHECKLIST A qualified installer should carry out the following checks: • All internal packaging removed. • Specified clearances maintained to combustible materials. • Pressure regulator connected and set. • Manual shut-off valve installed and accessible.
BEFORE LIGHTING YOUR TRUSEARTM INFRARED GRILLER CAUTION Prior to turning the gas on, inspect the gas supply tubing or hose. Look for evidence of abrasion, cuts, wear and tear, or other damage which could require replacement prior to use. Make sure all burner control knobs are off. Do not attempt to light the burner if the smell of gas is present. Check the connection with a soap and water solution after attaching the hose. Make sure there is gas in the tank and the tank is upright.
TruSear Infrared Grilling tips Infrared grilling produces intense heat which quickly sears the meat. Searing locks in flavor and juices while allowing the outer surface to absorb smoke and food aroma that is produced as grease and drippings are vaporized by the burner. The result is a crisp, flavorful outside with a tender, juicy inside. As a general rule, foods will cook in about 1/2 the time they would take on an ordinary grill. •Preheat the grill.
CLEANING AND MAINTENANCE Any piece of equipment works better and lasts longer when maintained properly and kept clean. Grilling equipment is no exception. Your TruSearTM Infrared Burner must be kept clean and maintained properly. TruSear Infrared Grill Burner When finished cooking, turn the control knob to the “HI” setting and allow the burner to burn for Five Minutes.
SERVICE INFORMATION If service is required: 1. Call your dealer or authorized service agency. The name of the authorized service agency can be obtained from the dealer or distributor in your area. 2. Have the following information readily available: a. Model number b. Serial number c. Date purchased d. Name of dealer from whom purchased 3. Clearly describe the problem that you are having.
PROFESSIONAL SERIES OUTDOOR BUILT-IN TruSearTM INFRARED GRILLER WARRANTY ONE YEAR FULL WARRANTY Built-in outdoor TruSear Infrared Grillers and all of their component parts, except as detailed below*, are warranted to be free from defective materials or workmanship in normal household use for a period of twelve (12) months from the date of original retail purchase.
VIKING RANGE CORPORATION 111 Front Street Greenwood, Mississippi 38930 USA (662) 455-1200 For more product information, call 1-888-VIKING1 (845-4641) or visit the Viking Web site at vikingrange.