User Manual

ManualsBrandsVitapur ManualsKitchenDual Stage Water Filtration System with Quick Connect Filters

UNDER SINK

Single and Dual Stage Quick Connect Filtration Systems

CONSUMER: Retain this manual for future reference.

Questions, problems, missing parts? Before returning to your retailer, call our customer service department at:

1 (877)-447-4768. 8:30am-4:30pm CST, Mon - Fri or email us at customerservice@ghpgroupinc.com

www.ghpgroupinc.com

GHP Group

USA: 6440 W. Howard Street, Niles, Illinois 60714

Canada: 271 Massey Road, Guelph, Ontario, N1K 1B2

VFK-1Q

VFK-2Q

Printed in China

2017-06-20

The VFK-2Q has been tested and certiﬁed

by NSF International against NSF/ANSI

Standard 42, 53 and CSA B483.1 for

reduction of the claims speciﬁed on the

performance data sheet

The VFK-1Q has been tested and certiﬁed by

NSF International against NSF/ANSI Standard

42 and CSA B483.1 for reduction of the claims

speciﬁed on the performance data sheet

Installation, Use & Care Guide

(Customer must read this manual thoroughly before installing the system)

Summary of content (11 pages)

PAGE 1
The VFK-2Q has been tested and certified by NSF International against NSF/ANSI Standard 42, 53 and CSA B483.1 for reduction of the claims specified on the performance data sheet UNDER SINK The VFK-1Q has been tested and certified by NSF International against NSF/ANSI Standard 42 and CSA B483.
PAGE 2
Table of Contents: Safety Precautions ..................................................... 1 Conditions for Operation........................................... 1 Package Contents...................................................... 2 Tools Required for Installation ................................... 2 Installation Instructions........................................... 3 - 6 * Installing Quick Connect Filter................................ 3 * Un-installing Quick Connect Filter..........................
PAGE 3
Package Contents: VFK-1Q A. D. C. J. K. L. I. M. E. OR VFK-2Q A. B. C. G. F. N. H. R. O. P. Q.
PAGE 4
Installation Instructions: The filter(s) of VFK-1Q and VFK-2Q Systems have been pre-assembled and tested at the factory, and don’t need to dis-assemble. If you want to check or replace the filter(s). The following steps need to be implemented: Installing the Quick Connect Filter (See Figure 1): 1. Unlock the Locking Tab by sliding it from the right to the left of the slot to ‘Unlock’ Position. 2. Lift the filter top section into the Head.
PAGE 5
Installation Instructions: Figure 3. Tapping Tapping into into Cold Cold Water Water Line Line (See (See Figure Figure 3): 3): CAUTION: The water supply to your unit MUST be from the COLD WATER LINE. Hot water will severely damage your filtration system. 1. Turn off cold water supply by turning off the shut off valve under the sink. If the cold water line doesn’t have a shut off valve under the sink, turn off the main water line in the house.
PAGE 6
Installation Instructions (continued): Installingthe theFaucet Faucet(See (SeeFigure Figure5): 5): Installing 1. Guide Escutcheon Plate (J) and Rubber Gasket (K) onto the stem of Faucet (I). Slip the stem into the hole and make sure it sits flat on the top of the sink or countertop surface. 2. From underneath the sink, slide Plastic Lock Washer (L) and Star Washer (M) up along the stem, then screw Stem Nut (N) all the way up the stem until it’s flush with Star Washer.
PAGE 7
Installation Instructions (continued): Connecting 1/4” 1/4” tubing tubing from from Water Water Line Line to to System. System. (See (See Figure Figure 6): 6): Connecting 1. Determine the length of 1/4” Tubing (D) from Inlet Valve (G) to the inlet of Head Assembly (A) by holding tubing in place ensuring it’s of appropriate length. Cut the tubing square with a utility knife. CAUTION: Don’t kink tubing as this will impede water flow. 2.
PAGE 8
Start-up Instructions: 1. Turn Inlet Valve (G) to open position and the cold water sink faucet to the closed position. 2. Slowly open the cold water supply valve that you closed at the beginning of this installation. 3. Open Faucet (I) to purge air from the system. When the water runs smooth with no bubbles or spurting, close the faucet and check for leaks for all fittings. 4. Open the Faucet (I) again to rinse the system. CAUTION: Let water run 15 minutes before using.
PAGE 9
Troubleshooting: Problem Possible Cause Solution Loose connection of sump and head. Unlock the filter head assembly and re-install the housing. O-rings missed or not in right position. Open sump to check the O-rings. Tubing is not pushing in all the way. Push tubing in as far as it will go. Tubing end is not cut square. Push tubing out and recut to square. Tubing is cracked or scratched. Simply cut that portion away and reinsert tubing. Water leaks at threaded fittings Loose connection.
PAGE 10
Replacement Parts List: VFK-1Q Single Stage Water Filtration System Part Description Part # 1 Bracket YY. VFK1Q-1 2 Filter Head YY. VFK1Q-2 3 Carbon Block Cartridge VRFQ-CTO 4 6’ of 1/4" White Tubing YY. VFK1Q-4 5 Inlet Valve YY. VFK1Q-5 6 Faucet YY. VFK1Q-6 7 Quick Connect Elbow YY. VFK1Q-7 8 Head Mounting Screw YY. VFK1Q-8 9 Bracket Mounting Screw YY. VFK1Q-9 10 Filter O-ring, small YY. VFK1Q-10 11 Filter O-ring, big YY.
PAGE 11
Warranty: Limited Warranty: This limited warranty is extended to the original retail purchaser of this filtration system and warrants against any defect in material and workmanship for a period of one (1) year from the date of retail sale. GHP Group, Inc., at its option, will either provide replacement parts or replace the unit, when properly returned to the retailer where purchased or one of our service centers as directed by GHP Group, Inc., within one (1) year of retail purchase.