UF-216CC water filtration system owner’s manual Manufacturing Numbers: 9700407 www.ajantunes.com P/N 1011135 Rev.
UF-216CC water Filtration system A.J. Antunes & Co. Table of contents Owner Information......................................................2 General.......................................................................2 Warranty Information..................................................2 Service/Technical Assistance.....................................3 Important Safety Information.....................................4 Specifications..............................................................
UF-216CC water filtration system A.J. Antunes & Co. Owner information (continued) Service/Technical Assistance If you experience any problems with the installation or operation of your unit, contact us at 86-512-6841-3637, or toll free in the United States at 1-800-253-2991. Fill in the information in the next column and have it handy when calling for assistance. The serial number is on the specification plate located on the unit. Purchased From: Date of Purchase: Model No.: Serial No.: Mfg. No.
UF-216CC water Filtration system A.J. Antunes & Co. Important Safety Information In addition to the warnings and cautions in this manual, use the following guidelines for safe operation of the unit: • If the supply cord is damaged, it must be replaced by the manufacturer or its service agent or a similarly qualified person. • Read all instructions before using equipment. • This equipment is to be installed to comply with the local plumbing code and any other applicable code.
UF-216CC water filtration system A.J. Antunes & Co. Specifications Dimensions Electrical Ratings A Model & Mfg. No. Voltage Watts UF-216CC 9700407 100‒240 0.8 50/60 Kit Model Number Description 0012146 DC Power Supply 100 - 240 VAC Includes the 4 plug adaptors below Euro CEE 7/16 Model & Mfg. No.
UF-216CC water Filtration system A.J. Antunes & Co. Specifications (continued) Drain Mounting Bracket Flush Button Pulse Controller Filter Housing Permeate Outlet Inlet Carbon Housing Figure 1. Components 6 P/N 1011135 Rev.
A.J. Antunes & Co. UF-216CC water filtration system Overview Overview The UF-216CC system operates in two modes: • Normal Operation Mode • Flush Mode During Normal Operation Mode, water enters the Inlet and flows through the Ultra Filter before exiting the Permeate Outlet as usable product water. During Flush Mode, the Drain Valve opens and water entering the Inlet flushes and cleans the Ultra Filter membrane by removing any debris collecting on the membrane wall.
UF-216CC water Filtration system A.J. Antunes & Co. Installation Unpacking Plumbing 1. Remove the system and all packing materials from the shipping carton. NOTE: This unit is designed to use tap water not to exceed 100°F (38°C) or 100 psig (690 kPa). 2. Remove all packing materials and protective coverings from the system The UF-216CC system uses the following connections (Figure 1): 3. Remove the information packet.
A.J. Antunes & Co. UF-216CC water filtration system Installation (continued) Mounting the System Inlet Water Plumbing The UF-216CC system comes with a Mounting Bracket to mount the system securely. When mounting the system, pay attention to the following guidelines: The Inlet water plumbing line should be 1/2 ” NPT or larger. A shutoff valve (not supplied) should be installed in the line leading to the system.
UF-216CC water Filtration system A.J. Antunes & Co. Installation (continued) Permeate Line Plumbing Secure End To ensure the highest quality and safest water, it is recommended that a check valve (to prevent backflow) be installed in the water line after the permeate connection. This will help prevent possible contamination of the filter system due to other equipment downstream. The check valve (not supplied) should be mounted close to the system outlet, and sized properly for the plumbing line.
UF-216CC water filtration system A.J. Antunes & Co. Installation (continued) Rinsing the Ultra Filter Cartridge Sanitizing the System and Lines The Ultra Filter Cartridge must be rinsed before the system is used to remove any air and protective solution. The plumbing must be sanitized to eliminate possible contamination that may have occurred during the installation process. NOTE: Ultra Filter Cartridge must be rinsed to drain before use. Rinsing to drain removes storage solution and air.
UF-216CC water Filtration system A.J. Antunes & Co. Installation (continued) Installing and Rinsing the Carbon Element The Carbon Element MUST be rinsed before using the system the first time. 1. Install the new Carbon Element into the Carbon Element Housing. 2. Screw the Carbon Element Housing (containing the Carbon Element) into place on the Carbon Element Head. The housing will come to a hard stop at the end of the thread. Use a Filter Wrench if necessary.
A.J. Antunes & Co. UF-216CC water filtration system Maintenance Replacing the Ultra Filter Cartridge 1. Open the faucet or tap closest downstream to the filtration system. End Cap 2. Close the Inlet Water Valve and allow the system to depressurize. Permeate Port Connection 3. Place a bucket under the strainer at the inlet connection to the system. Open the strainer by unscrewing the cap. Water will flow out of the strainer as the system drains. Cartridge Bracket 4.
UF-216CC water Filtration system A.J. Antunes & Co. maintenance (continued) Rinsing and Replacing the Carbon Element 1. Open the faucet or tap closest downstream to the filtration system. 2. Close the inlet water valve and allow the system to depressurize. 3. Place a bucket under the strainer at the inlet connection to the system. Open the strain by unscrewing the cap. Water will flow out of the strainer as the system drains. 4. Press the FLUSH button to help drain the system. 5.
UF-216CC water filtration system A.J. Antunes & Co. maintenance (continued) Changing the Interval Setting Caution Changing the flush interval can cause the Ultra Filter to plug prematurely and may void the warranty. Consult the factory for more information. Though not recommended, the Interval Setting on the controller can be changed. If the setting must be changed, use the chart below. Press and hold the corresponding button. After 5 seconds, the Button LED will turn on.
UF-216CC water Filtration system A.J. Antunes & Co. Troubleshooting Problem Possible Cause Corrective Action Unit does not have power. The power cord is not correctly plugged in. Plug power cord in correctly. The Control Display is blank. The power cord is not correctly plugged in. Plug power cord in correctly. Control Board is inoperable. Transformer is inoperable. Contact your maintenance person or Authorized Service agency.
UF-216CC water filtration system A.J. Antunes & Co. Replacement Parts Replacement Parts can be purchased from an authorized dealer. Contact A.J. Antunes & Co. at 1-630-754-1000 or toll free in the United States at 1-800-253-2991. 9 7 8 7 1 4 10 6 2 5 11 6 3 7 14 12 7 13 12 15 9 14 Item 1 2 3 4 5 6 7 8 Part No.
UF-216CC water Filtration system A.J. Antunes & Co. Notes 18 P/N 1011135 Rev.
A.J. Antunes & Co. UF-216CC water filtration system Notes P/N 1011135 Rev.
Limited Warranty Equipment manufactured by A.J. Antunes & Co. has been constructed of the finest materials available and manufactured to high quality standards. These units are warranted to be free from defects in materials and workmanship for a period of one year from date of purchase under normal use and service, and when installed in accordance with manufacturer’s recommendations*.
