Repair Manual

15
Copyright © 2010 ATSG
AUTOMATIC TRANSMISSION SERVICE GROUP
Technical Service Information
S F
G
AU
FA
UA
FA
VW
AG
VW
AG
GG 2
30
3
Z
8
0
20
2 683C
T0
1
9G 0
3
5
0
30
0
H
0
573 - 244
04 1
-
1
-
15
3 T
280
2 0 1
C 6
O
Z
H00
3
503
G
0
9
01 4
0
Volkswagen 09MVolkswagen 09G
09M 320 035H09G 300 035H
FS
G
AU
FA
UA
FA
VW
AG
VW
A G
8GG
Z
2 30 0 3
C 2
2
T
0 16803
0 M
2
0 H9 3
035
7 -
5 44 023
0
4 1
-
-
1
15
3 T
20
8
2 0 16C
O
Z
32
035H0
0
9M
01 4
0
14-Way Solenoid
Connector
14-Way Solenoid
Connector
8-Way Sensor
Connector
8-Way Sensor
Connector
PASS-THRU CASE CONNECTOR LOCATIONS
ELECTRONIC COMPONENTS (CONT'D)
Pass-Thru Case Connectors (Cont'd) Pass-Thru Case Connectors (Cont'd)
The connectors however are not always in the same
locations. The 09G, 09K, and Mini-Cooper will all
have the 8-way sensor connector located in the left
front location and the 14-way solenoid connector in
the left rear location, as shown in Figure 16. Notice,
also in Figure 16, that the 09M transaxle has the 8-
way sensor exiting the rear of the case and the 14-way
solenoid connector located where the 8-way
connector is usually located. The usual location for
the 14-way solenoid connector, is not used on the 09M
transaxle, as it is cast closed.
The numbers that are shown in Figure 16, are the
actual part numbers of the transaxle observed. Keep in
mind that we have not seen all of them.
The connectors also have a variety of different
configurations and case mounting brackets. The
mounting bracket is molded into the case connector as
it is manufactured.
The Mini-Cooper has an 8-way connector that turns
90 degrees in upward direction after it comes out of
the case, and the bracket bolts to case in the 9-O-
Clock position, as shown in Figure 17. The 14-way
connector is also rotated in a different configuration
than the VW models.
The Volkswagen 09K transaxle observed, has the
connector configurations shown in Figure 18.
Figure 16
Continued on Page 16
WWW.ALL-TRANS.BY