Service manual

Group 170 Preventive Maintenance
Preventive Maintenance
Basic Service
Including Lubrication and Oil Change
Date: Model: Reg. No.:
Time: Vehicle Identification Number: Engine:
Dealer Code: Transmission
Name: Rear Axle:
X = Corrected without comment
√ = Correction not needed
N = Not relevant or applicable
Lubrication, Oil and Fluid Level Check
1 Chassis Lubrication
2 Cab Lubrication
3 Change Engine Oil and Filters
4 Check Oil Level in Manual Transmission
5 Check Oil Level in Automatic Transmission
6 Check Oil Level in PTO (Power Take-Off)
7 Check Oil Level in Retarder
8 Check Oil Level in Transfer Case
9 Check Oil Level in Front Drive Axle
10 Check Oil Level in Rear Drive Axle
11 Check Oil Level in Hydraulic Axle Lift
12 Check Oil Level in Power Steering
13 Check Oil Level in Hubs for Oil Lubricated Wheel
Bearings
14 Check Oil Level in Cab Tilt Pump (If equipped)
15 Check Fluid Level in Clutch Fluid Reservoir
16 Check Coolant Freeze Protection and Coolant
Level (Check SCA Level)
17 Check Fluid Levels in Windshield Wiper and
Headlamp Wiper Reservoirs
18 Check Air Dryer
Cab Checks
19 Check Warning and Control Lamps
20 Check for Fault Codes in the Vehicle Electronic
Control Unit
Cab Checks
21 Check for Fault Codes in the Engine Electronic
Control Unit
22 Check for Fault Codes in the ABS, anti-lock
brakes
23 Check for Fault Codes in Transmission
24 Function Check of Parking Heater
25 Check Retarder Control
26 Check Sealing on Main Brake Circuit (Service)
27 Check Gear Shift and Clutch Pedal
External Checks
28 Function Check of External Lamps
29 Check Mirrors and Reflectors
30 Function Check of Wipers and Washers
31 Check Battery Mounting, Connections and Fluid
Levels
32 Check Fuel Tank, Hoses, Pipes, and Mounting
Straps
33 Check Fuel Tank Ventilation Filter
34 Check Water Seperator for Fuel System
35 Check Tire Wear
31