Owners Maintenance

1996 Volvo 850
Your car is equipped with a KEYLOCK system. When the engine is switched off, the gear selector must
be in the ( P )ark position before the starting key can be removed from the ignition switch.
5. Select desired gear. The gear engages after a slight delay (automatic transmission) which is especially
noticeable when selecting R.
CAUTION: (Automatic transmission only) The engine should be idling; never accelerate until after
you feel the gear engage! Too rapid acceleration immediately after selecting a gear will cause harsh
engagement and premature transmission wear.
NOTE: Selecting P or N (automatic transmission) when idling at a standstill for prolonged periods of
time will help prevent overheating of transmission oil.
WARNING! Always place the gear selector (automatic transmission) in Park and apply the parking
brake before leaving the vehicle. Never leave the car unattended with the engine running.
Always open the garage doors fully before starting the engine inside a garage to ensure adequate
ventilation. The exhaust gases contain carbon monoxide, which is invisible and odorless but very
poisonous.
TURBO CAUTION:
Never race the engine immediately after starting. Oil flow may not reach some lubricating points fast
enough to prevent engine damage.
Do not race the engine just prior to switching off!
Hydraulic valve lifters
This engine features hydraulic valve lifters which means that valve clearance is adjusted automatically.
It is possible that the valve lifters will produce a ticking sound for the first few seconds after the engine
is started, while the oil pressure is increasing.
If the car has not been used for a long period of time, this ticking sound may last for up to 15 minutes.
This is entirely normal.
Do not exceed 300 rpm until the ticking sound disappears.
file:///K|/ownersdocs/1996/1996_850/96850_401.htm (7 of 8)12/30/2006 9:59:32 AM
Classic Cars & Cycles www.ClassicCycles.org