Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden S60 Section Group Weight(Kg/Pounds) Year 3 39 Month 2001 04 S60 2001, S60 2002 © VolvoCar Corporation, 2001 Printed in Sweden 8633842 Page 1 of 21
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden © VolvoCar Corporation, 2001 Printed in Sweden 8633842 Page 2 of 21
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Required tools A0000162 A0000161 A0801178 M8802509 M3903563 © VolvoCar Corporation, 2001 Printed in Sweden 8633842 Page 3 of 21
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden M3903565 M8503983 © VolvoCar Corporation, 2001 Printed in Sweden 8633842 Page 4 of 21
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Any comments on this publication? Please contact your nearest dealer. Thank you! Publication no: MA 8633842, Issue: 2001-04 Comments:.......................................................................................................... ............................................................................................................................ ..............................
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden INTRODUCTION ● ● NOTE! Read through the entire text before carrying out any work. The front page gives the date of this edition and the edition it replaces Cars equipped with SRS/SIPS (Airbag) Warning! Extra care must be taken when working on cars equipped with SRS/SIPS air bags. This is important to prevent: 1.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden The collision sensor control module is located on the transmission tunnel in the centre console, in front of the parking brake. WARNING! The air bag inflation areas must not be obstructed. Never place any objects, such as upholstery or accessories, within these areas.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Preparations 1 ● Move the left front seat to its rearmost position ● Shift the gear selector lever to the rearmost position. Preparations 2 ● Turn the ignition key to position 0 ● Remove the key from the ignition switch (does not apply to cars with automatic gearboxes) ● Disconnect the battery negative lead.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Preparations 5 ● Applies to cars with a centrally mounted loudspeaker Remove the four screws in the loudspeaker (1) ● Lift up the loudspeaker. Disconnect the connector (2) ● Place the loudspeaker to one side. M3902614 Preparations 6 ● Pry off the panel in front of the gear selector lever. Use a weatherstrip tool as illustrated. Remove the panel in front of the gear selector lever.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Preparations 9 ● Angle the dashboard environment panel outwards so that it is possible to insert a couple of fingers between the centre console and the reverse of the dashboard environment panel ● Remove the dashboard environment panel by pulling it downward, maintaining the same angle.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Preparations 12 ● Tip the left front seat backwards ● Push the floor carpet to one side to access the air ducts (1). D8502411 Preparations 13 ● Remove the rear seat cushion (1). First pull the front edge of the seat cushion up. Pull the cushion forwards. Then lift the seat cushion out. D8503390 Preparations 14 ● Remove the sill trim panel at the left rear door.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Preparations 16 ● Remove the clip (1) at the side of the left-hand side cushion ● Pull the top edge of the left-hand front cargo compartment panel out to access the upper lock for the side cushion ● Repeat the operation on the right-hand side. M8503511 Preparations 17 M8503546 ● Remove the left-hand side cushion.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Preparations 20 ● Carefully lift the front edge of the parcel shelf panel until the clips (1) release ● Lift up the panel further until the locating pins (2) release from their holes ● Pull out the parcel shelf. Lay the parcel shelf on the folded backrests. M8503598 Preparations 21 ● Remove the cargo compartment carpet at the rear edge. First turn the two knobs (1) 90°.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Preparations 24 ● Press the centre of the clips at the lower edge of the foldable side panel on the left-hand side until they click ● Remove the two clips ● Remove the plastic nut at the front and lower edges of the side panel ● Repeat the operation on the right-hand side. M8902133 Preparations 25 M8503264 ● Turn the handle (1) on the right and left-hand sides through 90°.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Cable routing 27 ● Route the wiring (A in the kit illustration) for the display screen and the radio, and the loose cable for the display screen with the ten pin connectors (B in the kit illustration) for the radio socket between the air duct (1) and the stay (2).
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Terminals in the fuse holder 30 ● Remove the rear electronic module. First open the catch (1) on the top of the module. Fold the module forward. Lift the module from the mountings (2). M3702263 Terminals in the fuse holder 31 ● Connect the new routed red and white cable to the outer terminal (1) on the reverse of fuse socket number 10 on the fuse holder. Remove the decal (2).
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden ● the cover on the connector ● the connectors on the rear electronic module. Tighten the screw ● the rear electronic module. Installing and connecting the Global Positioning System (GPS) aerial 34 ● Install the new Global Positioning System (GPS) aerial (1) in the guide hole.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Installing the DVD reader 37 ● Take four screws, the bracket and the DVD reader from the kit. Tighten the DVD reader at the bracket. M3903564 Installing the DVD reader 38 ● Take the spring nut (1) from the kit. Press the spring nut on the panel edge on the underneath of the socket (2) in the panel.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Connecting the DVD reader 40 ● Install the bracket with the DVD reader in the rear edge of the rear wheel well using three screws (1) from the kit. Tighten the screws. Tighten to 10 Nm (7 lbf. ft) ● Clamp the blue excess connector and other wiring at the DVD reader using two tie straps.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden Installing and connecting the display screen 44 ● Applies to cars with a centrally mounted loudspeaker Connect the three cables (1) to the display screen and the centrally mounted loudspeaker ● Press the display screen and bracket into the dashboard. Tighten using the four existing screws (2) ● Press the new loudspeaker grille (from the kit) into place on the dashboard.
Installation instructions, accessories - Volvo Navigation System, widescreen Volvo Car Corporation Göteborg, Sweden ● Reinstall the side cushion ● Fold the backrest back into place ● Fold the seat cushion back into place. Finishing work 46 ● Turn the ignition key to position II ● Reconnect the battery negative lead ● Reinstall the cargo compartment carpet ● Program the software according to the service information in VIDA.
