INSTALLATION & OPERATION MANUAL SCALEBLOCKERTM WATER FILTRATION SYSTEM MODEL PART NO. SPS600V SPS620V 854893-1 854893-2 For additional information on Vulcan-Hart or to locate an authorized parts and service provider in your area, visit our website at www.vulcanhart.com VULCAN-HART DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC WWW.VULCANHART.COM P.O. BOX 696, LOUISVILLE, KY 40201-0696 TEL. (502) 778-2791 FORM 31228 Rev. A (Sept.
Installation, Operation and Care of SCALEBLOCKER TM WATER FILTRATION SYSTEM MODELS SPS600V & SPS620V SAVE THESE INSTRUCTIONS GENERAL Vulcan water filters are produced with quality workmanship and material. Proper installation, usage and maintenance of your water filter will result in many years of satisfactory performance. It is suggested that you thoroughly read this entire manual and carefully follow all of the instructions provided.
INSTALLATION REQUIREMENTS WATER PARAMETERS 6 to 9 0 to 250 ppm 0 to 4 ppm 0 to 300 ppm The model SPS600V and SPS620V water filters are designed to be p H installed in the cold water line only. Installation of the water filter in Alkalinity a hot water line can seriously damage the filter housing. The filter Chlorine must be in contact with water at all times after installation. Installation Hardness must comply with any existing state or local plumbing codes.
OPERATION WATER FILTER + BATTERIES The proper water filter cartridge should already be installed in the filter housing. Make sure the filter housing is firmly screwed into the filter mounting head. Use the supplied wrench if necessary. + COVER 1234567 123 1234 1234567 1234 Turn on the filter water supply valve. Press the red pressure relief button on top of the filter mounting head until all air is purged from the filter. DISPLAY Digital Flow Meter RESET DIGITAL FLOW METER Installing Batteries (Fig.
MAINTENANCE ORDERING PREVENTIVE MAINTENANCE KITS FILTER CARTRIDGE REPLACEMENT (PM) KITS To order the Preventive Maintenance Kit for your filtration system, contact your Vulcan representative, the Vulcan-Hart Service Department (at the address or phone number on the cover of this document) or visit Vulcan online at www.vulcanhart.com and click on Service.
USING SCALEBLOCKER RELEASETM Do not use alcohol-based cleaners. Clean the inside of the filter housing with a mild soap. Inspect the O-Rings for damage and replace if necessary. Wipe the large black O-Ring clean with a rag, press it down into the groove and then apply a very light coating of white petroleum jelly (Vaseline). Make sure the O-Ring fits in the groove and is properly seated each time the filter is reassembled, otherwise a water leak could occur.
TROUBLESHOOTING SYMPTOM POSSIBLE CAUSE SUGGESTED CORRECTIVE ACTION Short filter life. Filter clogs due to excessive particles in water. Low incoming water pressure. Excessively hard water or water quality beyond specification. Filtered water not going to boiler feed line. A leaking Fill Valve on the steamer equipment will deplete the filter quickly. An additional filter may be needed. Check water source. Additional water treatment may be needed before filter. Check plumbing lines.
Model SPS620V, Part No. 854893-2 Part No. Name 854306-1 854893-7 854306-3 854893-8 854893-24 854893-12 FP-069-02 FP-081-25 854306-9 FP-041-54 FP-054-29 854893-25 854893-26 854893-23 854306-19 854893-3 854893-29 854893-21 Backplate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Clear Housing, 20" . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . U-Bracket, Large . . . . . . . . . .