Gas Heater User Manual
– 9 –
OPERATION
WARNING: THE OVEN AND ITS PARTS ARE HOT. USE CARE WHEN OPERATING, CLEANING,
OR PERFORMING ANY MAINTENANCE.
CONTROLS — Models SG4D and SG6D (Fig. 4)
Master Switch • Turns oven control circuits ON or
OFF. • OVEN COOL allows the fan motor to run with the
doors ajar to speed oven cooling.
On Light (Amber) • Lit when Master Switch is ON.
Heat Light (White) • Comes on and goes off when the burner
cycles on and off.
No Ignition Light (Red) • Comes on if burner fails to ignite.
When lighting the oven, the No Ignition Light flashes.
Thermostat • Controls oven temperature during cooking
operation.
Power Level Light • When ON, indicates the power level
control is operating in the range between the high and low
settings.
Power Level Control • Selects the % heat input between OFF
and 100%. Power Level Control must be on for oven to work.
Dial Setting Percent of Full Input
10 100%
9 77%
8 73%
7 68%
6 60%
5 53%
4 45%
3 37%
2 28%
1 22%
OFF 0%
Timer (1 Hr. or 5 Hr.) • Selects the cooking cycle time. Buzzer
sounds continuously when elapsed time counts down to 0;
oven does not turn off. Turn timer dial OFF to silence buzzer.
When oven is not in use, keep timer at OFF position.
Two-Speed Fan Switch • Adjusts air velocity in the oven.
Light Switch • Turns lights in the oven on or off.
BEFORE FIRST USE
Before using the oven for the first time, it must be "burned in" to release any odors that might result from
heating the new surfaces in the chamber.
1. Using a clean damp cloth, wipe the inside of the oven, including the racks.
2. Close the oven doors, push the Master Switch ON, turn the Thermostat to 300°F
(149°C), and allow
the oven to cycle for 6 to 8 hours before pushing the Master Switch OFF.
Fig. 4
225
250
475
450
500
PL-52683
MASTER SWITCH
OFF
HEAT
ON
POWER LEVEL
1
2
3
4
5
6
7
8
9
10
OFF
IGNITION
THERMOSTAT
OVEN
COOL
ON
300
275
350
375
400
425
325
OFF
45
50
55
60
40
35
30
25
20
15
10
5
0
TIMER
FAN SPEED
HI ON
LOW
LIGHTING INSTRUCTIONS
TURN GAS "ON", PUSH MASTER SWITCH "ON"
IF BURNER FAILS TO LIGHT TURN GAS "OFF"
WAIT 5 MINUTES FOR RETRIAL
SHUTDOWN INSTRUCTIONS
TURN MASTER SWITCH OFF
OFF
LIGHTS
MASTER SWITCH
ON LIGHT
HEAT LIGHT
NO IGNITION LIGHT
POWER LEVEL LIGHT
POWER LEVEL
CONTROL
TIMER
LIGHT SWITCH
TWO SPEED
FAN SWITCH
THERMOSTAT
150