Owner's manual

Page 10 ;&(%$*4.8"4,7%<'*#$"&8#=%/7*,#*%4,77%>?@@@?@AA?BCDC1 Item 63749 56861
EF;6GH IJ6KFGLIM NFLMG6MFMO6EJ6OL;LOFGLIME
;"7$*(%S*8#%K*/7,4*5*8$
1. Squeeze the Lens Holder (F) latches inside the
Helmet at the base of the Lens Holder together
and pull the bottom of the Lens Holder towards the
inside of the Helmet to remove. Refer to Figure G.
2. To remove Auto-Darkening Filter (D) Lens
from Lens Holder (F):
a. Pull on top center of front of Lens Holder and,
b. Lift top of Filter Lens out.
PFKMLMQY%%GI%JK6!6MG%E6KLI\E%LM_\KH%
FMT%RSLMTM6EE-%
K*/7,4*%$.*%2"7$*(%7*8#%IMSH%)"$.%,8%*b,4$%
(*/7,4*5*8$1%%I$.*(%7*8#*#%5,U%8&$%/(&$*4$%
/(&/*(7U%2(&5%)*79"83%7"3.$=%&(%5,U%8&$%2"$%.*75*$%
47&#*7U%*8&'3.%$&%+7&4V%,77%7"3.$%,$%$.*%*93*#1
3. Remove any protective film from
both sides of the new Lens.
4. Install new Filter Lens into the Lens Holder
and replace Lens Holder into Shell.
R,$$*(U%L8#$,77,$"&8%&(%K*/7,4*5*8$
To install Battery before first use or when
the LOW BATTERY LED begins to turn red,
indicating Battery needs replacement:
a. Remove the Auto-Darkening Filter (D)
from the Lens Holder (F) as described
in Filter Lens Replacement.
b. Slide the Battery Holder out of the
Auto-Darkening Filter. Remove the
used battery (if applicable).
c. Place a new CR2450 Lithium Battery inside
the Battery Holder and put the Battery Holder
back into the Auto-Darkening Filter. Make
sure the new Battery is installed correctly.
d. Replace the Auto-Darkening Filter into the Lens
Holder and replace Lens Holder into Shell.
O&55&8%J(&+7*5#%,89%K*5*9"*#
1. L((*3'7,(%T,(V*8"83%I(%T"55"83
a. Headband has been set unevenly on
both sides of helmet (unequal distances
from the eyes to filter’s lens).
b. Reset Headband to reduce difference
in distances to filter, if necessary.
2. F'$&?T,(V*8"83%;"7$*(%T&*#%
M&$%T,(V*8%I(%;7"4V*(#
a. Front Lens Cover is soiled or
damaged (change the cover).
b. Sensors are soiled (clean surface of the sensors).
c. Welding current is too low (turn
Sensitivity Adjustment Knob to the
“HI” position, if necessary).
3. E7&)%K*#/&8#*
Operating temperature is too low (do not
use at temperatures below 14° F).
4. J&&(%!"#"&8
a. Front/Inside Lens Cover and/
or Filter soiled (change it).
b. Insufficient ambient light.
c. Shade number is incorrectly set
(reset shade number).
5. P*79"83%Z*75*$%E7"/#
Headband is not adjusted properly
(must be lowered).
E$&/%'#"83%$.*%Z*75*$%"55*9",$*7U%"2%,8U%
&2%$.*#*%/(&+7*5#%4,88&$%+*%4&((*4$*91
;"3'(*%L-%%K*5&X"83%;"7$*(%S*8#
F'$&?
T,(V*8"83%
;"7$*(%`Ta
S*8#%
Z&79*(%`;a
,1%/'77%.*(*
+1%7"2$%$&/%&2%
;"7$*(%S*8#%&'$
+
BATTERY
Be sure Positive (+) side
of Battery faces up.
R,$$*(U
R,$$*(U%
Z&79*(
S&)%R,$$*(U%
S6T
;"3'(*%_-%%R,$$*(U%L8#$,77,$"&8