Product Manual

4 Security
14 100_0202_si_0006.fm
4.8 General safety instructions - Combustion engines
The following notes must be observed:
 Before starting work, check the engine to ensure there are no leaks and/or cracks in the fuel lines,
tank, and fuel cap.
 Do not operate a defective engine. Replace damaged parts immediately.
 The pre-set engine speed may not be adjusted. This could lead to engine damage.
 Make sure that the exhaust system of the engine is free of debris. Fire hazard!
 Switch off before refueling the engine.
 Use the correct fuel type. The fuel may not be mixed with other liquids.
 Use clean filling aids for refueling. Do not spill fuel. Immediately wipe up any spilled fuel.
 The engine may not be started near spilled fuel. Explosion hazard!
 For operation in partially closed spaces, sufficient ventilation and aeration must be ensured. Do not
inhale exhaust fumes. Risk of poisoning!
 The engine surface and exhaust system can quickly become extremely hot. Risk of burns!
4.9 General safety instructions – fuel, lubricants and coolants
The following notes must be observed:
 Always wear safety glasses and protective gloves when handling fuel, lubricants, and coolants. If
hydraulic oil, fuel, oil, or coolant gets into your eyes, see a doctor immediately.
 Avoid direct skin contact with fuel, lubricants and coolants. Immediately rinse skin with soap and
water.
 Do not eat or drink while working with fuel, lubricants and coolants
 Contaminated hydraulic oil or fuel from dirt or water can lead to premature wear or failure of the
machine.
 Dispose of spilled fuel, lubricants and coolants according to the applicable provisions for
environmental protection.
 If fuel, lubricants and coolants escape from the machine, do not operate the machine any longer and
have it repaired immediately by the Wacker Neuson contact partner.
4.10 General safety instructions – starter batteries
The following notes must be observed:
 When disconnecting the starter battery, always disconnect the negative terminal first!
 When connecting the starter battery, always connect the positive terminal first! Fasten battery
terminal cover!
 Flames, sparks, and smoking are prohibited when handling starter batteries.
 Starter batteries contain corrosive acid. Wear acid-proof protective gloves and safety glasses when
handling starter batteries.
 Prevent incorrect connection of the starter battery or bridging of the terminals with tools. Risk of short
circuit!
NOTICE
This machine is outfitted with an EPA-certified engine.
Adjusting the revolutions per minute (RPM) impacts the EPA-certification and the
emissions. Settings for this engine may only be changed by a professional.
For more information, contact the manufacturer or your Wacker Neuson contact partner.
NOTICE
Never add acid or distilled water.
Observe the battery manufacturer's instructions for charging.
Never open the battery to remove the aeration.