M1 PASSTHROUGH DISHWASHER OperatorManual
Foreword User documentation Please read this manual and keep it in a safe place for future reference. WARNING Before installation and commissioning, you must read the safety instructions and warnings carefully and all the warning labels attached to the equipment. ! ! IMPORTANT Failure to comply (even partially) with the instructions given in this manual will invalidate the product warranty and relieves the manufacturer of any responsibility.
Safety Instructions WARNING Equipment contains dangerous voltages and can be hazardous if installed or operated incorrectly. Non-compliance with Warnings or failure to follow the instructions contained in this manual can result in loss of life, severe personal injury or serious damage to property.
Installation WARNING Installer must be suitably qualified and ensure compliance with all local codes and standards including AS/NZS 3500.1. ! Failure to comply even partially with installation instructions may void the warranty. Positioning Unpack machine, check for damage and complete delivery. Install machine on sound waterproof self-draining floor and use adjustable feet to level machine. Allow room for detergent to one side of machine or in adjacent cupboard.
Operator Manual M1-3(S)
Operator Manual M1-3(S)
Installation Checklist CHECK Delivery Supplied complete Position Level and stable Water Isolator valve fitted DCVs fitted (Washtech only) Temperature Flow rate Pressure Cold water when required Hardness Power Isolating switch Supply as specified Waste Usually 40 mm Air gap on pumped drain Chemicals product name Detergent Rinse Aid Machine operation Run several cycles Confirm correct operation Operator training OK / NOTES no transit damage on sound, waterproof, self draining floor Accessible, all fittings s
Dishwashing Procedures for best results Note: these are general instructions to assist in getting the best performance from Starline dishwashers – some comments and / or illustrations may not apply to every unit. Installation Read the Operator Manual. Correct installation, including an adequate supply of water at the correct temperature and pressure is essential for effective operation of your machine. Refer installation instructions for details. Drain hose outlet height is important on some models.
Dishwashing Procedures for best results Drying Single tank commercial dishwashers do not have a drying cycle. However, the machines do rinse at high temperatures which promote fast drying particularly when drying agents are used. We recommend prompt removal of the rack from the machine - leave the rack on the bench for 2 to 3 minutes before emptying. This time will be reduced with correct use of drying agent (rinse fluid) which reduces water surface tension and allows water to drain quickly from washware.
Operating Instructions Start up Fit drain upstand, wash pump filter, scrap tray and shut door. Turn wall and machine power switches on. Power light glows red and machine fills automatically. Wash Ready light glows amber when wash tank is ready. Rinse Ready light glows amber when the machine is up to required temperature and ready to run. Operation Load rack into machine and close door to start the machine. Cycle light glows green during 2 minutes cycle of operation.
Operator Manual M1-3(S)
Warranty WASHTECH warrants that new STARLINE products are free from defects in material or workmanship for a period of one year from the date of purchase. EXTENT OF WARRANTY Washtech shall repair or, at its discretion, replace any part of the machine found to be defective. The labour for the repairing or the replacement of defective parts shall be provided during normal office hours at no cost to the user.
Notes Operator Manual M1-3(S)
