Owner Manual

ManualsBrandsWatts Premier ManualsHome Improvement3-Stage Under-sink Filtration System

INSTALLATION, OPERATION AND MAINTENANCE MANUAL

Refer to enclosed warranty for operating parameters to ensure proper use with your water supply.

Watts Premier, Inc. 8716 W Ludlow Drive Suite #1 Peoria, AZ 85381

Phone: 800-752-5582 www.premierH2o.com Fax: 623-866-5666

Manual #: 199334 Manual Date:8/06/05

Warning

Please read carefully before proceeding with installation. Your failure to follow any attached instructions or

operating parameters may lead to the product’s failure and possible damage to property.

System Tested and certied by NSF International against ANSI/NSF

Standard 53 for the reduction of claims specied on the performance

data sheet.

MODEL

Ultra-UV-R

Summary of content (10 pages)

PAGE 1
INSTALLATION, OPERATION AND MAINTENANCE MANUAL Warning Please read carefully before proceeding with installation. Your failure to follow any attached instructions or operating parameters may lead to the product’s failure and possible damage to property. MODEL Ultra-UV-R System Tested and certified by NSF International against ANSI/NSF Standard 53 for the reduction of claims specified on the performance data sheet.
PAGE 2
Service Record Table of Contents Mainteance Record ..................................................................................................... 3 Operational Parameters .............................................................................................. 3 Contents of Ultra UV-R System .................................................................................... 3 Tools Recommended For Installation .........................................................................
PAGE 3
Operational Parameters Do not use with water that is microbiologically unsafe or of unknown quality, without adequate disinfection before or after the system. Installation needs to comply with state and local plumbing regulations. Operational Temperature Operating Pressure pH Parameters Flow Rate Maximum Minimum 100°F (37.8°C) 40°F (4.4°C) 100 psig (7.43 g/cm²) 20 psig (1.406 kg/cm²) 10 5 0.
PAGE 4
A. Remove faucet kit from plastic bag and locate each of the following parts (as shown in Figure A) Note: Remove plastic tubing from faucet body before inserting long reach spout into faucet body. Figure A: Faucet tube connection Note: If using existing hole (sprayer or soap dispenser) go to Step G. A. Determine desired location for the faucet on your sink surface. B. Place a piece of masking tape or duct tape on location where the hole is to be drilled. Mark the center of the hole on the tape.
PAGE 5
Step 3. Installation of Upgraded Adapta Valve#134007 For 3/8” Plumbing For ½” Plumbing Hot water supply line Cold water supply line Step 1 Turn off the cold water supply to the faucet by turning the angle stop valve off. Step 2 Attach the Adapta Valve as illustrated in the photo above. When attaching to straight pipe threads, use Teflon tape on the threads.
PAGE 6
Step 4 Lift black faucet handle up on faucet to start flow of water through unit. Run 7 gallons of water through unit. Close faucet. Note: You may hear some noise as air is being purged from the unit and the first few glasses of water through the unit may be dark in color due to carbon fines. B. Check for leaks. If you have any leaks, shut-off water supply to system, repair and restart unit. C. Connect plastic electrical connector from UV unit to the plastic electrical connector from AC adapter. D.
PAGE 7
Figure E: UV Tube Assembly & Exploded View It em P art # Des c ript ion It em 1 134008 Easy Tap Adapter 17 2 131017 Insert Brass 114" 18 P art # Des c ript ion Faucet Body 116032 L/R Spout 3 131012 Sleeve Delrin 114" 19 137046 UV- Bracket 4 131002 Nut Brass 114"C 20 146001 #10-3/4" Philip Pan Head Screws (6) 5 140007 Tubing 114"Green (4ft) 21 146004 # 10-1" Philip Pan Head Screw (2) 6 125034 Elbow 90° 1I4"Cx 1/4" MPT (6) 22 164004 Single Mounting Clip 104015 CTG-10" 5 Micron Sed
PAGE 8
Watts Premier, Inc. 8716 W Ludlow Drive Suite #1 Peoria, AZ 85381 – USA Performance Data Sheet for specific claims to NSF Std-53. CT-1, UC-1, UC-2 & Ultra-UV-R GENERAL USE CONDITIONS: 1: System to be used with municipal or well water sources treated and tested on regular basis to insure bacteriological safe quality. DO NOT use with water that is microbiologically unsafe or unknown quality without adequate disinfection before and after the system.
PAGE 9
8716 W Ludlow Drive Suite #1 • Peoria, AZ 85381 Limited Warranty What your Warranty Covers: If any part of your WATTS PREMIER Ultra UV-R is defective in workmanship (excluding replaceable filters, and uv-bulbs), return unit after obtaining a return authorization (see below), within 3 year of original retail purchase, WATTS PREMIER will repair or, at WATTS PREMIER’S option, replace the system at no charge.
PAGE 10
Watts Premier, Inc. Phone: 800-752-5582 8716 W Ludlow Drive Suite #1 www.premierH2o.