Installation Sheet

ManualsBrandsWAYNE ManualsSump PumpsWAYNE 12V Battery Powered Thermoplastic Submersible Sump Pump Backup with Automatic Switch

12-Volt Back-

Sump Pump

Description

The ESP25 is a battery operated back-up sump pump. It

does not replace a regular pump. It is designed to provide

protection in the event household electrical power fails.

Unpacking

Inspect this unit before it is used. Occasionally, products

are damaged during shipment. If the pump or components

are damaged, return the unit to the place of purchase for

replacement. Failure to do so could result in serious injury or

death.

Safety Guidelines

This manual contains information that is very important

to know and understand. This information is provided for

SAFETY and to PREVENT EQUIPMENT PROBLEMS.

To help recognize this information, observe the following

symbols.

Danger indicates an imminently

hazardous situation which, if NOT

avoided, WILL result in death or serious injury.

Warning indicates a potentially

hazardous situation which, if NOT

avoided, COULD result in death or serious injury.

Caution indicates a potentially

hazardous situation which, if NOT

avoided, MAY result in minor or moderate injury.

Notice indicates important

information, that if NOT followed, MAY

cause damage to equipment.

General Safety Information

Do NOT use to pump

 ammableorexplosiveuids

such as gasoline, fuel oil, kerosene, etc. Do NOT

useinaammableand/orexplosiveatmosphere.

pumpSHOULDonlybeusedtopumpclearwater.

Fatalinjuryand/orpropertydamageCOULDresult.

 Ifthebasementhas

water or moisture on the

oor,doNOTwalkonwetareauntilallpoweris

turnedoff.Iftheshutoffboxisinthebasement,

call an electrician. Remove pump and either repair

or replace. Failure to follow this warning COULD

result in fatal electric shock.

 Allwiringmustbeperformedbya

 qualiedelectrician.

Do NOTexposebatteryto

 sparksorameasan

explosionorreCOULDresult.

Battery acid is corrosive

Avoid spilling on skin or clothing. Eye

protectionMUSTbewornwhenhandlingthebattery.

 AcheckvalveMUSTbeusedonthe

primary sump pump discharge.

A ground fault circuit interrupter

(GFCI) is required.

This pump MUST onlybeusedtopump

clear water only. This pump is not

designedtohandleeuent,saltwater,brine,laundrydischarge,

oranyotherapplicationwhichmaycausecausticchemicalsand/

or foreign materials. Pump damage MAY occur if used in these

applications and WILL void the warranty.

Battery Information

The system is designed to operate most efficiently with sealed

lead acid (SLA) batteries. Sealed lead acid batteries cost

slightly more, but they can last longer. The oversize battery

case (included) will accommodate a 12-volt SLA battery (up to

a 27-frame size).

Be certain that the area around the batteries is well ventilated.

Before servicing the batteries, blow away gasses by waving a

piece of cardboard near the batteries.

Dangerous hydrogen gas CAN

 bereleasedfromthebatterieswhile

charging. Sparks CAN ignite the gas in an enclosed space. Wear

safetlygoggleswhenconnectingbatteries.Batteryconnections

SHOULDbemadeinawellventilatedarea.

Working in the vicinity of lead acid

 batteriesCANbedangerous.Before

makingtheconnectionsorservicingthebatteries,readand

followinstructionsonallapplicableinstructionmanuals.To

reducetheriskofbatteryexplosion,followtheinstructionsin

thismanualandthosepublishedbythebatterymanufacturer,

as well as those of any other equipment used in the surrounding

area.

An assistant should be present or close enough to come to

your aid in the event of an emergency. Have a reliable source

of fresh water and soap nearby in case batttery acid contacts

skin or eyes.

Pleasereadandsavetheseinstructions.Readcarefullybeforeattemptingtoassemble,install,operateormaintain

theproductdescribed.Protectyourselfandothersbyobservingallsafetyinformation.Failuretocomplywith

instructionscouldresultinpersonalinjuryand/orpropertydamage!Retaininstructionsforfuturereference.

For parts, product & service information

visit www.waynepumps.com

REMINDER: Keep your dated proof of purchase for warranty purposes! Attach it to this manual or file it for safekeeping.

352208-001 10/16

Operating Instructions & Parts Manual ESP25

Summary of content (16 pages)

PAGE 1
ESP25 Operating Instructions & Parts Manual Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described. Protect yourself and others by observing all safety information. Failure to comply with instructions could result in personal injury and/or property damage! Retain instructions for future reference. 12-Volt Backup Sump Pump Description The ESP25 is a battery operated back-up sump pump. It does not replace a regular pump.
PAGE 2
Operating Instructions and Parts Manual Wear eye or clothing protection when working around lead acid batteries. Avoid touching your eyes when working around lead acid batteries. 5. Place the pump with the 4 ft. section of PVC pipe on a solid, level surface in the sump pit on an elevated surface. If battery acid contacts your eye(s), flush with cold running water for 10 minutes and seek immediate medical attention. If acid contacts your skin or clothing, wash immediately with soap and water. 6.
PAGE 3
ESP25 Method 2 If a separate, dedicated discharge is not possible as in Method 1, the back-up pump can be tied into the AC operated pump's discharge pipe by installing a "Y" connector. Two check valves will be required. 1. Locate the back-up pump on a solid, level surface in the sump pit. Do not place the pump on a loose or sandy surface. Small stones or sand may damage the pump resulting on potential pump failure. Floor Joist Slope Pipe Down 2. This pump has a 1-1/2 in. NPT discharge. If a 1-1/4 in.
PAGE 4
Operating Instructions and Parts Manual 4. Test pump operation by filling the sump with water while the main pump is unplugged. If the pump operates properly, plug the transformer into the GFCI protected outlet to begin charging the battery. d. Plug in transformer and main AC pump. When main AC power is out, and when pump has been running, the lights will indicate battery status. 4.
PAGE 5
ESP25 Batteries If battery acid contacts your eye(s), flush with cold running water for 10 minutes and seek immediate medical attention. If acid contacts your eyes, skin or clothing, wash immediately with soap and water. Dangerous hydrogen gas CAN be released from batteries while charging. Sparks CAN ignite the gas in an enclosed space. Wear safety goggles when connecting batteries. Battery connections SHOULD be made in a well ventilated area.
PAGE 6
Operating Instructions and Parts Manual For Replacement Parts or Technical Assistance, Call 1-800-237-0987 Please provide following information: - Model number - Serial number (if any) - Part description and number as shown in parts list Address any correspondence to: WAYNE Water Systems 101 Production Drive Harrison, OH 45030 U.S.A. 3 2 1 Reference 1 2 3 Transformer Pump Lid Assembly www.waynepumps.
PAGE 7
ESP25 Limited Warranty For two years from the date of purchase, WAYNE Pumps ("WAYNE") will repair or replace, at its option, for the original purchaser any part or parts of its Sump Pumps or Water Pumps (“Product”) found upon examination by WAYNE to be defective in materials or workmanship. Please call WAYNE (800-237-0987) for instructions or see your dealer. Be pre pared to provide the model and serial number when exercising this warranty.
PAGE 8
Operating Instructions and Parts Manual Notes www.waynepumps.
PAGE 9
ESP25 Manual de Instrucciones de Operación y Piezas Sírvase leer y conservar estas instrucciones. Léalas con cuidado antes de intentar armar, instalar, operar o efectuar mantenimiento al producto descrito. Protéjase a sí mismo y a los demás observando la información de seguridad. El no cumplir con estas instrucciones podría provocar lesiones personales y/o daños materiales. Conserve estas instrucciones para futura referencia.
PAGE 10
Manual de Instrucciones de Operación y Piezas Debe haber un asistente presente o lo suficientemente cerca para acudir en su ayuda en caso de emergencia. Tenga una fuente confiable de agua fresca y jabón cerca en caso de que el ácido de la batería entre en contacto con la vestimenta, la piel o los ojos. Use protección en sus ojos y para la vestimenta cuando trabaje cerca de baterías de plomo-ácido. Evite tocarse los ojos cuando esté trabajando cerca de baterías de plomo-ácido. 3.
PAGE 11
ESP25 Método 2 Si no es posible lograr una descarga separada y dedicada como en el Método 1, la bomba ESP25 puede conectarse a la tubería de descarga de la bomba que funciona con CA, instalando un conector "Y". Se requerirán dos válvulas de retención. Viga del piso Conector“Y” Codo de 45º 1. Coloque la ESP25 sobre una superficie sólida y nivelada en el pozo del sumidero. No coloque la bomba sobre una superficie blanda o arenosa.
PAGE 12
Manual de Instrucciones de Operación y Piezas Verde: Indica que la batería está totalmente cargada. Amarilla: Indica que la batería está parcialmente cargada, pero aún se puede operar. 4. Verifique el funcionamiento de la bomba llenando el sumidero con agua y manteniendo desconectada la bomba primaria. Si la bomba funciona correctamente, conecte el transformador en el enchufe protegido GFCI para comenzar a cargar la batería. Roja: La batería está totalmente descargada o dañada.
PAGE 13
ESP25 Trabajar en las inmediaciones de baterías de plomo-ácido puede ser peligroso. Antes de hacer conexiones o reparar las baterías, lea y siga las instrucciones en todos los manuales de instrucciones aplicables. Para reducir el riesgo de explosión de la batería, siga las instrucciones de este manual, y aquellas publicadas por el fabricante de la batería, así como también las de cualquier otro equipo que se use en los alrededores. 4.
PAGE 14
Manual de Instrucciones de Operación y Piezas Para Ordenar Repuestos, Sírvase llamer al Concesionario más Cercano a su Domicilio 1-800-237-0987 Sírvase proporcionar la siguiente información: -Número del modelo -Número de serie (de haberlo) -Descripciones y número de piezas, tal como aparecen en la lista de piezas Dirección para correspondencia sobre repuestos: WAYNE Water Systems 101 Production Drive Harrison, OH 45030 U.S.A. 3 2 1 No. de Ref.
PAGE 15
ESP25 Garantía Limitada Durante dos años a partir de la fecha de compra WAYNE reparará o reemplazará para el comprador original, según lo que decida, cualquier pieza o piezas de su, Bombas de resumideros, Bombas de agua ("Producto") que después de un examen WAYNE encuentre que tenían defectos en su material o mano de obra. Sírvase llamar a la compañía WAYNE (800-237-0987, desde EUA) para recibir instrucciones al respecto o comuníquese con el distribuidor más cercano a su domicilio.
PAGE 16
Manual de Instrucciones de Operación y Piezas Notas www.waynepumps.