User guide

ManualsBrandsWEATHER GUARD ManualsFor the car524-3-02 through 662-0-02

INSTALLATION MANUAL

Aluminum & Steel Underbed Boxes

Model 524-3-02 through 662-0-02

ATTENTION: PLEASE READ AND UNDERSTAND ALL INSTRUCTIONS AND WARNINGS

BEFORE ASSEMBLING, INSTALLING OR USING THIS PRODUCT.

Danger of explosion. Do not use this product for storing or transporting flammables, explosives, hazardous materials, or hazardous waste,

such as containers of gasoline, solvents, gun powder, dynamite, propane tanks, acetylene tanks and cutting torches. Failure to heed this

warning will result in death or serious injury.

This product is only intended and safe for use in storing and transporting small tools, equipment and other similar materials. This product

can reduce the driver's ability to clearly see road-ways, vehicular or pedestrian traffic and other objects through the rear and side windows of

the vehicle, which may cause an accident. Extra precautions should be taken when driving a vehicle with this product. Make all adjustments

necessary to ensure maximum visibility, including but not limited to, changing mirror and seating positions. State and local laws may prohibit

obstruction of windows in a moving vehicle.

These instructions are to be followed using the parts and fasteners supplied for proper installation. Any modifications or improper installation

of this product will create a hazardous condition that could result in death, serious personal injury and/or property damage. All floor mounting

bolts near the fuel tank area should be installed from the underside of the vehicle, to guard against the fuel tank being punctured in the event

of a collision. This would mean not using Blind Fasteners in this area. Holes in this area should be 5/16". Ensure ample space in roof ribs and

sidewall ribs for mounting screws so as not to puncture exterior roof or wall.

Do not install this product where it could interfere with deployment of air bags. Failure to comply could result in death or serious body injury.

WARNING

DANGER

WWW.WEATHERGUARD.COM

TRUCK STORAGE SOLUTIONS

– NOTICE –

Any modification or unintended use of this product shall immediately void all manufacturers warranties. Manufacturer disclaims all liability for

injuries to persons or property resulting from any modification to, or unintended use of this product.

CAUTION

Prior to drilling, so as not to cut electric wires, fuel lines, brake lines, etc., check behind and underneath drilling and mounting locations. To

keep debris out of your eyes when checking the underside of the vehicle, or when drilling, always wear protective eye wear. Failure to heed

this warning may result in moderate injury.

SECURING YOUR REPUTATION

Part No. 24-0187 REV. B ECN 5305 04/13

PRODUCT REGISTRATION

Model# ________________ Serial#__________________

Purchased Date:

______________________

Place of purchase:

______________________

Key Code:

______________________

For your convenience,

place product

registration tear-off

sticker here.

24-0187

Summary of content (9 pages)

PAGE 1
INSTALLATION MANUAL Aluminum & Steel Underbed Boxes TRUCK STORAGE SOLUTIONS SECURING YOUR REPUTATION Model 524-3-02 through 662-0-02 WWW.WEATHERGUARD.COM ® ATTENTION: PLEASE READ AND UNDERSTAND ALL INSTRUCTIONS AND WARNINGS BEFORE ASSEMBLING, INSTALLING OR USING THIS PRODUCT. PRODUCT REGISTRATION Model# ________________ Serial#__________________ For your convenience, place product registration tear-off sticker here.
PAGE 2
INSTALLATION INSTRUCTIONS All steel and aluminum boxes must be mounted with either Type "A" or Type "B" brackets Under Body Mountings The box must be mounted as shown or structural damage will occur to the box. Stake Bed Top Mounting The box must be mounted with the bottom fully supported or structural damage will occur to the box.
PAGE 3
KNAACK LLC LIMITED LIFETIME WARRANTY FOR WEATHER GUARD® PRODUCTS WEATHER GUARD® Products — Limited Lifetime Warranty (Purchased on or after 1/1/2009) Knaack LLC (the “Manufacturer”) warrants to the original purchaser only that WEATHER GUARD® Truck and Van Products (the “WEATHER GUARD® Product”) will be free from defects in material and workmanship from the date of purchase and continuing for the expected lifetime of the WEATHER GUARD® Product.
PAGE 4
MANUAL DE INSTALACIÓN TRUCK STORAGE SOLUTIONS SECURING YOUR REPUTATION Cajas de aluminio y acero para colocar debajo de la plataforma Modelos 524-3-02 hasta 662-0-02 WWW.WEATHERGUARD.COM ® ATENCIÓN: ASEGÚRESE DE LEER Y COMPRENDER TODAS LAS INSTRUCCIONES Y ADVERTENCIAS ANTES DE MONTAR, INSTALAR O UTILIZAR ESTE PRODUCTO.
PAGE 5
INSTRUCCIONES DE INSTALACIÓN Todas las cajas de acero y aluminio deben montarse con soportes tipo “A” o tipo “B” Montajes bajo la carrocería La caja debe montarse como se muestra o la estructura de la caja podría dañarse. Montaje superior en la plataforma de estaca La caja debe montarse con la parte inferior totalmente apoyada para evitar que la estructura de la caja se dañe. En las cajas para colocar debajo de la plataforma de 24" de profundidad debe usarse un soporte tipo “A”.
PAGE 6
GARANTÍA LIMITADA DE POR VIDA DE KNAACK LLC PARA PRODUCTOS WEATHER GUARD® Productos WEATHER GUARD®: Garantía limitada de por vida (Comprados a partir del 1/1/2009) Knaack LLC (el “Fabricante”) garantiza únicamente al comprador original que los productos WEATHER GUARD® para vans y camionetas (el “producto WEATHER GUARD®”) estarán libres de defectos en materiales y mano de obra a partir de la fecha de compra y continuarán así durante la vida útil esperada del producto WEATHER GUARD®.
PAGE 7
MANUEL D’INSTALLATION Caisses en aluminium et en acier à installer sous les camionnettes Modèles 524-3-02 jusqu’à 662-0-02 TRUCK STORAGE SOLUTIONS WWW.WEATHERGUARD.COM SECURING YOUR REPUTATION ® ATTENTION : LIRE ET S’ASSURER DE COMPRENDRE L’ENSEMBLE DES DIRECTIVES ET DES AVERTISSEMENTS AVANT D’ASSEMBLER, D’INSTALLER OU D’UTILISER CE PRODUIT.
PAGE 8
DIRECTIVES D’INSTALLATION Toutes les caisses en aluminium et en acier doivent être montées avec des fixations de type A ou de type B Fixations sous la carrosserie La caisse doit être fixée tel qu’indiqué pour éviter de causer des dommages structurels à la caisse. Camionnette à plateforme Installez la caisse de manière à supporter entièrement son fond pour éviter de causer des dommages structurels à la caisse.
PAGE 9
GARANTIE À VIE LIMITÉE DE KNAACK LLC POUR LES PRODUITS WEATHER GUARD® Produits WEATHER GUARD® — Garantie limitée à vie (achetés le ou après le 01/01/2009) Knaack LLC (le « Fabricant ») garantit à l'acheteur d'origine uniquement que les produits WEATHER GUARD® pour fourgonnettes et camions (les « Produits WEATHER GUARD® ») seront exempts de vices de matériaux et de fabrication à compter de la date d'achat et pendant toute la durée de vie anticipée du produit WEATHER GUARD®.