Use and Care Manual
MATERIAL SAFETY DATA SHEET
MATERIAL SAFETY DATA SHEET: MCA TREATED WOOD
SECTION I
M
SDS NUMBER:
2
54-osm
M
SDS CODE:
O
SM
S
YNONYMS:
N
/A
MANUFACTURED BY: Licensees/Customers of Osmose, Inc.
D
IVISION:
W
PD
E
PA REGISTRATION NUMBER:
N
/A
EMERGENCY PHONE: 800-424-9300
OTHER CALLS: 334-585-2291 Monday through Friday 8 am to 5 pm CST
A
DDRESS:
1
100 US Highway 431 North, Abbeville, Alabama 36310
MSDS PREPARED BY: Kevin Savoy / Jerry Wright
D
ATE PREPARED:
J
une 17, 2008
DATE LAST REVISED: N/A
Micronized Copper Azole Treated Wood
I
MPORTANT INFORMATION
• Do Not Burn Preserved Wood
• Do Not Use Preserved Wood As Mulch
• Treated Or Untreated Wood Dust May Cause Eye, Skin & Respiratory Irritation
•
Some Untreated Wood Species May Cause Allergic Skin Or Respiratory Effects In Sensitized Individuals
• Wear Dust Mask & Goggles When Cutting Or Sanding Wood
•
Wear Gloves When Working With Wood
•
Prolonged Contact with Treated Wood During Construction or Use May Cause Skin Irritation
• Some Preservative May Migrate Into The Soil/Water Or Dislodge From Wood
• For Additional Information Visit www.osmosewood.com
SECTION II - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
TRADE NAME: Micronized Copper Azole
INGREDIENT NAME:
CAS OSHA PEL/TWA ACGIH TLV/TWA %
Wood/Wood Dust (This represents the maximum amount of
wood dust that could be generated if the wood was completely
machined. Exposure limits are for all species except western red
cedar, which has a TLV of 0.5 mg/m3)
N/A 15 mg/m3 (Total Dust)
5 mg/m3 (Respirable dust)
1 mg/m3 (Inhalable) > 90%
Copper Carbonate expressed as elemental copper 12069-69-1 0.1 mg/m3 TWA (Cu fume) 0.2 mg/m3 TWA (Cu
fume)
< 1.0%
Tebuconazole 107534-96-3 None Established None Established < 0.05%
Depending on the additives applied to the treating solution, this wood may also contain < 1% of a mold inhibitor, <1% of a non-hazardous
wax emulsion and/or <1% of a colorant. None of these ingredients are classified as carcinogens.
PERCENTAGE OF ACTIVE INGREDIENTS PER RETENTION LEVEL
0.06 pcf 0.15 pcf 0.23 pcf
Copper carbonate expressed as Elemental Copper 0.15% - 0.25% 0.35% - 0.65% 0.55% - 0.95%
Tebuconazole 0.006% - 0.01% 0.01% - 0.03% 0.02% - 0.05%
SECTION III - CHEMICAL CHARACTERISTICS
BOILING POINT MELTING POINT FREEZING POINT
SPECIFIC GRAVITY
(H
2
O = 1)
PERCENT VOLATILE
BY VOLUME
THEORETICAL VOC
CONTENT
(PERCENT OF WEIGHT)
Not Applicable Not Applicable Not Applicable Not Available Not Applicable Not Applicable
WEIGHT PER
GALLON
Not Applicable
pH:
Not Applicable
VAPOR PRESSURE
Not Applicable
VAPOR DENSITY
Not Applicable
DENSITY
Not Available
EVAPORATION RATE
BASIS (N-BUAC) = 1
Not Applicable
SOLUBILITY IN WATER: Not Applicable REACTIVITY IN WATER: Not Applicable
APPEARANCE AND ODOR: Solid Wood, appearance may vary. No odor.
Micronized Copper Azole Treated Wood
Page 1 of 4