#55826 YOU MUST READ THIS OWNERS GUIDE BEFORE OPERATING YOUR GASGRILL A_ DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3. Open lid 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. Leaking gas may cause a fire or explosion which can cause serious bodily injury or death, or damage to property. A_ WARNING 1. Do not store spare liquid propane cylinder within 10 feet (3m) of this appliance. 2.
DANGERS ANDWARNINGS ............................................................ 3 WARRANTY ......................................................................... 4 GENERAL INSTRUCTIONS ............................................................. 5 For installation in Canada...................................................................................................... 5 Operating ..............................................................................................................
Failure to follow the Dangers, Warnings and Cautions contained in this Owner's Manual may result in serious I bodily injury or death, or in a fire or an explosion causing A_DANGER damage to property. A_WARNINGS A_ Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. A_ Improper assembly may be dangerous. Please follow the assembly instructions carefully.
Weber-Stephen Products Co.
Your Weber egasbarbecue isaportable outdoor cooking appliance. Withthe Weber ¢gasbarbecue youcangrill,barbecue, roast andbake withresults thataredifficult toduplicate withindoor kitchen appliances. Theclosed lid andFlavorizer ¢Barsproduce that"outdoor" flavor inthefood. TheWeber ¢gasbarbecue isportable soyoucaneasily change itslocation inyouryardoronyourpatio. Portability means youcantakeyourWeber ¢ gasbarbecue with,ifyoumove.
COOKING /k WARNING: Do not move the Weber ® gas barbecue when operating or while barbecue is hot. You can adjust the FRONT and BACK burners as desired. The control settings: High (H), Medium (M), Low (L), or Off (O) are described in your Weber e cookbook. The cookbook uses these notations to describe the settings of the FRONT and BACK burners. For example, to sear steaks, you would set all burners at H (high). Then to complete cooking, you would set FRONT and BACK at M (medium).
IMPORTANT LP CYLINDER INFORMATION Failure to follow these DANGER statements exactly may result in a fire causing death or serious injury. The proper filling methods for the filling of your cylinder are by weight or volume, as described in NFPA 58. Please make sure your filling station fills your LP cylinder by weight or volume. Ask your filling station to read purging and filling instructions on the LP cylinder before attempting to fill.
/k WARNING: Do not use a wrench to tighten the connection. Using a wrench could damage the regulator coupling and could cause a leak. 5) 6) 7) Mix soap and water. Turn on the cylinder valve. Check for leaks by wetting the fitting with the soap and water solution and watching for bubbles. If bubbles form, or if a bubble grows, there is a leak. iiiiiiiiii!iiiiiiiiiiiiiiiiiiii@ !!!i ii If there is a leak, turn off the gas and tighten the fitting.
CHECK FOR GAS LEAKS A_DANGER Do not use an open flame to check for gas leaks. Be sure there are no sparks or open flames in the area while you check for leaks. Sparks or open flames will result in a fire or explosion, which can cause serious bodily injury or death and damage to property. A_ WARNING: You should check for gas leaks every time you disconnect and reconnect a gas fitting. Note - All factory-made connections have been thoroughly checked for gas leaks. The burners have been flame-tested.
Check: 1) Hose to manifold connection. :21 A_ WARNING: If there is a leak at connection (1), retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tightening the fitting, turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com_. 2) 3) 4) Regulator to cylinder connection. Manifold to side burner hose connection.
SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS • • • • Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP gas is a gas at regular temperatures and pressures. Under moderate pressure, inside a cylinder, LP gas is a liquid. As the pressure is released, the liquid readily vaporizes and becomes gas. LP gas has an odor similar to natural gas. You should be aware of this odor. LP gas is heavier than air. Leaking LP gas may collect in low areas and prevent dispersion.
LIGHTING Summary lighting instructions Crossover _ Ignition System Note - The Crossove_ ignition system ignites the Front burner with a spark from the igniter electrode inside the Gas CatcheF Mignition chamber. You generate the energy for the spark by pushing the Crossover _ ignition button until it clicks. are on the control panel.
MAIN BURNER LIGHTING MANUAL LIGHTING A_DANGER Failure to open the lid while igniting the barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. 1) 2) SILVER A & B Open the lid. Make sure all burner control knobs are turned OFF. (Push each knob down and turn clockwise to ensure they are in the off position.
LIGHTING THE SIDE BURNER LIGHTING WITH IGNITER /k DANGER Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flame-up which can cause serious bodily injury or death. Lighting only the side burner. 1) Open the side burner lid. 2) Check that the side burner valve is turned OFF. (Push each knob down and turn clockwise to ensure they are in the off position.
PROBLEM CHECK CURE Burners burn with a yellow or orange flame, in conjunction with the smell of gas. Inspect Spider / Insect Screens for possible obstructions. (Blockage of holes.) Clean Spider / Insect Screens. (See Section "Annual Maintenance") Burners do not light. -or- Burners have a small flickering flame in the HIGH position. -orBarbecue temperature only reaches 250 ° to 300 ° in the HIGH position.
PROBLEM CHECK Side Burner does not light. CURE Is gas supply off? Turn supply on. The excess flow safety device, which is part of the barbecue to cylinder connection, may have activated. To reset the excess flow safety device turn all burner control knobs and the cylinder valve OFF. Disconnect the regulator from the cylinder. Turn burner control knobs to HIGH. Wait at least 1 minute. Turn burner control knobs OFE Reconnect the regulator to the cylinder. Turn cylinder valve on slowly.
WEBER®SPIDER/INSECT SCREENS Your Weber ¢ gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section(I) of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the air shutter. This could result in a fire in and around the air shutters, under the control panel, causing serious damage to your barbecue.
MAIN BURNER FLAHE PATTERN The Weber e gas barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown. 1) Burner tube 2) Tips occasionally flicker yellow 3) Light blue 4) Dark blue If the flames do not appear to be uniform throughout the burner tube, follow the burner cleaning procedures. (2) (3) (4) MAIN BURNER CLEANING PROCEDURE Turn off the gas supply, Remove the manifold. Look inside each burner with a flashlight.
5) 6) 7) Slide the burner assembly out from under the guide screw and washer(I) in the corners of the cooking box. Lift and twist the burner assembly slightly, to separate the crossover tube(l) from the burners. Remove the burners from the cooking box. To reinstall the burners, reverse 3) through 7). /k CAUTION: The burner openings(I) properly over the valve orifices(2). (1) must be positioned Check proper assembly before fastening manifold in place.
WEBER-STEPHEN PRODUCTS CO. www.weber.com _ ©2003 The following trademarks are registered in the name of Weber-Stephen Products Co.. an Illinois corporation, located at 200 East Daniels Road, Palatine. Illinois 60067 U.S.A. Australia; Smokey Joe, Weber, Kettle Silbouette_., Genesis. Austria Kettle SilhouettefL, Smokey Joe. Weber. Benelux; Kettle Silhouette_. Smokey Joe, Weber, Compact Grill Configuration, Botswana; Weber. Canada Smokey Joe, Genesis, China; Kettle Silhouettett..
