SUMMIT M425 & 450 LP Gas Barbecues Operating Guide Summit 450 LP Summit 425 LP 1 Serial Number Serial Number I'b I a "t I)t_lC_' ,,I,,l'lI_.TI.L_ ,It _ Idl I I WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be left with the owner and the owner should keep them for future FOR YOUR SAFETY 1.
WARNINGS DANGER Failure to follow the Dangers,Warnings and Cautions contained in this Owner's Manual may result in serious bodily injury or death, or a fire or an explosion causing damage to property. Do not store a spare or disconnected LP tank under or near this barbecue. Should a grease fire occur, turn off all burners and leave lid closed until fire is out. Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual.
TABLE OF CONTENTS Warnings 2 Steam-N-Chips Warranty 4 Maintenance A Word of Thanks 4 Standards and Codes Information 5 Operating Area Storage *REFER TO YOUR STEP-BY-STEP THIS TIME Lighting Crossover Ignition System To Extinguish 5 5 SECTION AT Smoker Spider Stopper Guards Inspection and Cleaning of the Spider Stopper Guards Main Burner Flame Pattern Main Burner Cleaning Procedure Replacing the Main Burners Crossover Ignition System Operations 6 Troubleshooting 6 6 Exploded Views and Repla
WARRANTY Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber Gas Barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 25 years, Cooking Grates and Flavorizer Bars, 7 years, All Remaining Parts, 5 years, when assembled and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your date of purchase.
STANDARDS AND CODES INFORMATION Your Weber Gas Barbecue is a portable outdoor cooking appliance. With the Weber Gas Barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce that "outdoor" flavor in the food. The Weber Gas Barbecue is portable so you can easily change its location in your yard or on your patio. Portability means you can take your Weber Gas Barbecue with you if you move.
LIGHTING EACH HEAT ZONE OPERATES INDEPENDENTLY. 1) Open the lid. Figure 1. Summary lighting instructions are on the control panel. 2) Check that the fuel scale reads more than "E". Note - E = empty; F = full. 3) Make sure all burner control knobs are OFF. (Push each burner control knob down and turn clockwise.
MANUAL LIGHTING EACH HEAT ZONE OPERATES INDEPENDENTLY. DANGER When the excess High Medium Low Off DANGER Failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. 1) Open the lid. Figure 2. 2) Check that fuel scale reads more than "E". Note - E = empty; F = furl. 3) Make sure all burner control knobs are turned OFF.
COOKING CLEANING The Weber Gas Barbecue should not be moved when CAUTION: Turn your Weber Gas Barbecue OFF and wait for it to cool before cleaning. operating or hot. High Medium Low Off You can adjust the LEFT and RIGHT burners as desired. The control settings High (H), Medium (M), Low (L), or Off (O) are described in your Weber cookbook. The cookbook uses these notations to describe the settings of the LEFT and RIGHT burners.
USING THE STEAM-N-CHIPS The Steam-N-Chips Smoker cooks with both Weber FireSpice Wood Chips and Chunks. For best results with faster cooking foods like steaks, burgers and chops, etc., we recommend using the FireSpice Chips because they ignite and create smoke faster. For longer cooking foods such as roasts, chicken and turkeys, etc., we recommend using FireSpice Chunks because they ignite slowly and provide smoke for a longer period of time.
MAINTENANCE Spider Stopper We recommend that you inspect the Spider Stopper Guards at least once a year. Also inspect and clean the Spider Stopper Guards if any of the following symptoms should ever occur. Guards Your Gas Barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the air shutter. Figure 5.
MAINTENANCE Main Burner Flame Pattern Replacing The Weber Gas Barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown in Figure 7. Tips occasionally Burner inside cooking box j,__" yellowish Your Weber Gas Barbecue must be OFF and cool. 2. Turn OFF gas at source. 3. Disconnect regulator. 4. To remove control panel refer to "Remove the control panel and the front panel" in the Step-By-Step Guide. 5. 6. Remove cooking grates.
MAINTENANCE 9. Unlatch the Spider Stopper Guards and remove. Figure 1? 11. Slide the burner assembly from each Heat Zone. The left and right burners are connected by the Crossover tube. Figure 14 (a). Pull out of here Cro5 Figure 12 10. Pull the manifold out of the burners. Figure 13.
MAINTENANCE 12. Lift and twist the burner assembly slightly to separate the crossover tube from the burners. Remove the 14. Reinstall the Spider Stopper Guards. Slightly rotate the Spider Stopper Guards so that the seams are in line with the Venturi fins. There should be no gaps in the seams or in the fit around the burners and valves. burners from the cooking box. Figure 15. Separate here Figure 17. /-,/\ Check fit around valve _3.
TROUBLESHOOTING Problem Check Cure Burners bum with a yellow or orange flame, in conjunction with the smell of gas. Inspect Spider Stopper Guards for possible obstructions. (Blockage of holes.) Clean Spider Stopper Guards. (See Maintenance Section.) Burners do not light. -orBurners have a small flickering flame in the HIGH position. -orBarbecue temperature only reaches 250 ° to 300 ° degrees in the HIGH position.
EXPLODED VIEW FOR THE SUMMIT 425 LP 33 34 35 3S .
REPLACEMENT 1 2 PARTS LIST FOR THE SUMMIT Lid Thermometer 55 56 1/4-20 x 1 3/4 inch bolt 1/4-20 hex nut 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 Steam-N-Chips smoker Stainless steel work surface (2) Condiment holder (2) Cooking box Crossover tube (2) Left burner (2) Right burner (2) Burner control knobs (4) Igniter (2) Igniter lock nut (2) Igniter wire (white) (2) Igniter wire (black) (2) Gas catcher ignition chamber (2) Spider stopper guard (4) Manifold assembly Manifold mounting c
EXPLODED VIEW FOR THE SUMMIT 450 LP 2 3 4 5' 3_ 4O 41 42 8 ¸ 9 10, 11 12 13-17 18 18, 20 22, 44 45 46 47 4,9 24 25 26' 27 28, 29 30 31 32 49 5O 51 49 54-57 59 83 61 3G G_ 37 38
REPLACEMENT 1 2 PARTS LIST Lid Thermometer 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 Cooking grate (2) Flavorizer bar / cooking grate (2) Flavorizer bar (7) Stainless steel work surface (2) Condiment holder (2) Cooking box Crossover tube (2) Left burner (2) Right burner (2) Burner control knob (4) Igniter (2) Igniter lock nut (2) Igniter wire (black) (2) Igniter wire (white) (2) Gas catcher ignition chamber (2) Spider stopper guard (4) Manifold assembly Manifold mounting clips
PATENTS & TRADEMARKS © 1997 Weber-Stephen Products Co. Weber, the _[ silhouette, Flavorizer and Crossover are registered U.S. trademarks; Summit, Grill Cozy, Gas Catcher, Spider Stopper, and Steam-N-Chips, are trademarks, all of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Summit Series Gas Barbecues are covered by U.S. Patent Nos. 4,677,964; 4,727,853; 4,777,927; 4,829,978; 4,860,724; 4,941,817; and 4,966,125; and, Canada patent Nos. 1,283,586 and 1,300,995.
