Ultra Boiler Manual

  

START-UP DATA
Boiler Model CO
2
High re % CO
2
Low re %
Fuel Natural ____ LP ____ CO High re ppm CO Low re ppm
Was orice changed? ______________________________________ Was gas valve throttle adjusted (Ultra-399) for propane? __________________
Natural gas input rate measured _________________________ Btuh
U-CONTROL SET-UP DATA
Boiler Model WWSD Temp °F Add’l Heat Demand
Type
1___ 2___ 3___ 4___
High Altitude yes ____ no _____ Adjust Outdoor °F Add’l Heat Demand
Time
minutes
Manual Reset Temp °F
PRIORITY 1 Settings PRIORITY 2 Settings PRIORITY 3 Settings
System Type System Type System Type
Max Supply °F Max Supply °F Max Supply °F
Min Supply °F Min Supply °F Min Supply °F
Max OD Reset °F Max OD Reset °F Max OD Reset °F
Min OD Reset °F Min OD Reset °F Min OD Reset °F
Modulate On Diff °F Modulate On Diff °F Modulate On Diff °F
Modulate Off Diff °F Modulate Off Diff °F Modulate Off Diff °F
Max On Time minutes Max On Time minutes Max On Time —
Min On Time — Min On Time minutes Min On Time minutes
Boost Interval minutes Boost Interval minutes Boost Interval minutes
Pre-pump Time: seconds Pre-pump Time: seconds Pre-pump Time: seconds
Post-pump Time: seconds Post-pump Time: seconds Post-pump Time: seconds
Circulator 1 on-off Circulator 1 on-off Circulator 1 on-off
Circulator 2 on-off Circulator 2 on-off Circulator 2 on-off
Circulator 3 on-off Circulator 3 on-off Circulator 3 on-off
Maximum Rate %Rate Maximum Rate %Rate Maximum Rate %Rate
Minimum Rate %Rate Minimum Rate %Rate Minimum Rate %Rate
Circulator Exercising Freeze Protection Circulators
Circulator 1 on _______ off _______ Circulator 1 on _______ off _______
Circulator 2 on _______ off _______ Circulator 2 on _______ off _______
Circulator 3 on _______ off _______ Circulator 3 on _______ off _______
Boiler Model Series CP Number Date Installed
BTU Input  Installation instructions have been followed.
 Check-out sequence has been performed.
 Above information is certied to be correct.
 Information received and le with owner/maintenance person.
Installer


(Company) (Address) (Phone) (Installer's Signature)