User manual

16
WARNING
Fire and explosion hazard!
Theunitisnotpermittedtobeusedfortheextractionof
inammablegases.
Theunitmustnotbeexposedtotemperaturesabove
50°C,nakedameorcondensedsolvents.
The organisation operating the unit is responsible for the
observanceofthelegallimitsfornoxioussubstancesat
the place of work.
Theltrationsystemmayonlybeputintooperationifitis
in perfect working order.
Intended use of the soldering station/ desoldering
stationalsoincludestherequirementthatyou
 adheretotheseinstructions,
 observeallotheraccompanyingdocuments,
 complywithnationalaccidentpreventionguidelines
applicable at the place of use..
The manufacturer will not be liable for unauthorised
modicationstothedevice.
User groups
Duetodifferingdegreesofriskandpotentialhazards,sever-
alworkstepsmayonlybeperformedbytrainedexperts.
Work step User groups
Installationofcomplex
pipesystemswith
multipleextractorarms
connected
Specialist personnel with
technical training
Technical trainees under the
guidance and supervision of
atrainedexpert
Replacing electrical repla-
cement parts
Electricians
Technical trainees under the
guidance and supervision of
atrainedexpert
Specicationofmainte-
nance intervals
Safetyexpert
Operation
Filter change
Non-specialists
Operation
Notice
Theunitmayemitdustfromthemainlteraftertrans-
portation. Make sure that the unit is put into service in
a suitable room.
CAUTION
Ahighnoxiousgasconcentrationwill
cause the activated charcoal to heat up.
Toavoidoverheating,theunitshouldberunwithout
noxiousgasesforseveralminutesbeforeswitchingoff.
Put the tool into operation as described in the chapter
„Placingintooperation“.
Please adhere to the operating instructions of the
connected devices.
Checktoseeifthemainsvoltagematchestheratings
on the nameplate.
Make sure the machine is switched off before plugging
in.
Optimalgasltrationisachievedasfollows:
Temperatureofprocessairingaslter<38°C
Relativehumidity<60%
Gasmolecules>30g/mol(betterltrationresultsare
achievedwithlargermolecules)
Boilingpointofthegasmolecules>0°C
Care and maintenance
WARNING
Before doing any work on the machine, pull the
plug out of the socket.
Theunitmustnotbealteredormodiedinanyway!
Repairs must always be referred to a Weller-trained
specialist.
Useoriginalreplacementpartsonly.
Filter change
year
MIN 1x
Toensurethattheltrationsystem
functionsproperly,thecompactlter
must be replaced as follows
 atleastonceayearor
 ifthemaximumallowable
workplaceconcentrationisexceeded
or
 as per maintenance schedule
Notice
Differentuxesanduxconstituentsandtheamountof
andsizeofdustparticlesintheextractedairwillsigni
cantlyeffecttheltersworkinglife.Submicronparticles
intheextractedairincreasewhensolderingorwelding
to varnish insulated wire.
Thesuspendedmatterlterandthebroadbandgas
lterarecomplementarytooneanotherandcanbe
replacedtogetherasacompactlter.Thecompact
ltermustbechangedonceayearinordertoensure
itisfullyfunctional.Thenedustlter(ltermat)isthe
preliminarystageofthecompactlterandtherefore
mustbereplacedmorefrequently.
Itisstronglyrecommendedthatthecompactlterbe
replacedafternomorethan10nedustlterchanges.
An alarm sounds and the yellow warning light a-
shes:: Recommendedservicelifeoflterhasexpired.
(seeOperatingtimelterdisplay/Extractioncapacity
lterdisplay)
An alarm sounds and the red warning light is lit
continuously:: Extractioncapacityistoolow.Switch
offthelterunit.Checkthenozzles,tubesandext-
ractorarms,andcleanthemifnecessary.Ifthealarm
GB
ENGLISH